TL* THE CONTACT OWNS A 1993 SATURN SL. THE CONTACT STATED THAT THE PASSENGER SIDE WINDSHIELD WIPER SEPARATED FROM THE ARM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT ALSO STATED THAT THE DRIVER'S SEAT, HORN, IGNITION, AND WINDOWS ALSO FAILED. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE FAILURE MILEAGE WAS 60,…
Read full complaint
TL* THE CONTACT OWNS A 1993 SATURN SL. THE CONTACT STATED THAT THE PASSENGER SIDE WINDSHIELD WIPER SEPARATED FROM THE ARM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT ALSO STATED THAT THE DRIVER'S SEAT, HORN, IGNITION, AND WINDOWS ALSO FAILED. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 172,727. UPDATED 09/15/14*LJ UPDATED 1/13/2014 *JS
NHTSA ODI #10585967
Mileage unknown · Oct 19, 2002
Engine And Engine CoolingStructure
VALVE TRAIN SEEMS TO FAIL AT ABOUT 95-160 THOUSAND MILES WITH UNKNOWN CAUSE. CALLED BOTH DEALER AND REPAIR SHOPS. BOTH SEEM TO SAY THE SAME. EITHER VALVE SEATS OR PISTON RINGS FAIL AT THESE POINTS OF MILAGE. BETWEEN 95,000 TO 160,000 MILES WITH UNKNOWN CAUSE. SOME SAID MIGHT BE THE ALUMINUM HEAD DEFECT, OTHERS SAID THAT THERE AR…
Read full complaint
VALVE TRAIN SEEMS TO FAIL AT ABOUT 95-160 THOUSAND MILES WITH UNKNOWN CAUSE. CALLED BOTH DEALER AND REPAIR SHOPS. BOTH SEEM TO SAY THE SAME. EITHER VALVE SEATS OR PISTON RINGS FAIL AT THESE POINTS OF MILAGE. BETWEEN 95,000 TO 160,000 MILES WITH UNKNOWN CAUSE. SOME SAID MIGHT BE THE ALUMINUM HEAD DEFECT, OTHERS SAID THAT THERE ARE STRESS CRACKS FROM THE MOLDING OF THE HEAD. THEY ALL SAY CAN NOT REALLY TELL UNTIL TAKEN APART AND VISUALLY CHECKED. HIGH COST TO DO THIS. BUT NO KNOWN RECALLS ON THE HEAD DEFECT OR VALVE SEAT OR VALVE TRAIN SYSTEM. ALSO ON THE DOOR HINGE, THE DOOR SEALS LET WATER DOWN TO THE HINGE AND IT ROTS OUT THE HINGE ON THE DOOR, CAUSING THE DOOR TO FALL OR ROT OFF.
NHTSA ODI #768642
Mileage unknown · Apr 16, 1997
Structure
DRIVER'S SIDE POWER DOOR LOCK WILL NOT UNLOCK AND CANNOT GET DOOR OPEN, IN FOR REPAIRS. *AK
NHTSA ODI #811046
Mileage unknown · Feb 7, 1996
Structure
ENERGY ABSORBENCE FROM A REAR-END IMPACT. (ATTORNEY FOR CLIENT)*SD
NHTSA ODI #501420
Mileage unknown · Oct 24, 1995
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
PURCHASE CAR NEW THE ENGINE BLEW THE PASSENGER SIDE DOOR WILL NOT SHUT RIGHT AND THE CAR HARD TO START THE FRONT END SHAKES, THE BRAKE GOES TO THE FLOOR . TT
NHTSA ODI #973827
Mileage unknown · Jul 25, 1995
Structure
SPOT WELDS HAVE FAILED IN (3) AREAS. MANUFACTURER/DEALER FAIL TO ACKNOWLEDGE PROBLEM EXIST. PLEASE DESCRIBE DETAILS. TT
NHTSA ODI #969425
Mileage unknown · Apr 11, 1995
Structure
THE FRONT FENDER AND SKIRT CRACKED IN SUB FRIGID WEATHER. TT
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
Consequence & remedy
Consequence: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROUNDINGMATERIALS. IF THIS OCCURS, AN UNDERHOOD FIRE COULD RESULT WITH OR WITHOUT THEENGINE RUNNING AND WITHOUT PRIOR WARNING.
Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.
THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CIRCUIT BETWEEN THE BATTERY CABLE ANDTHE STARTER HOUSING CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: INSPECT AND, IF NECESSARY, ADJUST THE CLEARANCE BETWEEN THE POSITIVE BATTERY CABLE TERMINAL SO THAT IT DOES NOT CONTACT THE STARTER SOLENOID HOUSING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA95003 · Cruise Control Failures
Opened Feb 24, 1995 · Closed May 31, 1996
Status: closed (inferred from source dates) · Equipment
THIS INVESTIGATION DOCUMENTED HTE FUNCTIONAL ABERATIONS THAT HAVE OCCURRED IN THE PERFORMANCE OF THE SUBJECT CRUISE CONTROL SYSTEM.MOST OF THE MALFUNCTIONS INVOLVED FAILURE OF THE SYSTEM TO PROPERLY REGULATE VEHICLE SPEED WHEN ENGAGED, FAILURE OF THE SYSTEM TO ENGAGE, OR SELF-DISENGAGEMENT OF THE SYSTEM. THESE PROBLEMS WERE INVESTIGATED AND STEPS TAKEN BY THE MANUFACTURER TO REMEDY THEIR OCCURRENCES.SERVICE PROCEDURES WERE ISSUED FOR VEHICLES IN USE, AND A DESIGN MODIFICATION MADE FOR NEW VEHICLES.NO CONFIRMED ALLEGATIONS OF FAILURE OF THE SYSTEM TO DISENGAGE UPON COMMAND WERE IDENTIFIED.IMPROVED QUALITY CONTROL PROCEDURES AND DESIGN MODIFICATIONSIN THE SYSTEM WERE UNDERTAKEN TO ENSURE A MORE CONSISTENT LEVEL OF SYSTEM PERFORMANCE.THE DETAILS OF THESE FINDINGS AND THE RESULTING CONCLUSIONS ARE CONTAINED INTHE SUBJECT ENGINEERING ANALYSIS CLOSING REPORT.A SAFETY-RELATED DEFECT TREND WAS NOT IDENTIFIED AT EHIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE94079 · Cruise Control Failure
Opened Nov 7, 1994 · Closed Feb 24, 1995
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
PE93022 · Steering System Lockup
Opened Apr 5, 1993 · Closed Sep 30, 1993
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1993 Saturn Sl Problems, Complaints & Recalls | Skip That Year
Illustration