IllustrationWHILE DRIVING THIS VEHICLE, THE MOTOR WOULD JUST STOP AND THEN WOULD NOT START UNTIL IT COOLED OFF. HAD TO HAVE IT TOWED 6 TIMES WITHIN 6 MONTHS. HAVE NOT BEEN ABLE TO DRIVE IT SINCE.
1993 Saturn Sl
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1993 Saturn Sl do not stand out strongly from the model-year median of 171.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 175 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
24 crash reports8 fire reports13 injury reports
Engine And Engine Cooling complaints
30 reportsPROBLEMS WITH THE HARMONIC BALANCER HAVING EXCESSIVE RUN OUT CAUSING IMPROPER SERPENTINE BELT ALIGNMENT WHICH CREATED EXCESSIVE BELT WEAR. IF PROBLEM IS LEFT UNATTENDED, SERPENTINE BELT/BALANCER CAN SEPARATE CAUSING ENGINE STALL AND LOSS OF POWER STEERING WHICH MAY CAUSE ACCIDENT. CONTACTED MANUFACTURER BUT DID NOT ACKNOWLEDGE A…
Read full complaint
PROBLEMS WITH THE HARMONIC BALANCER HAVING EXCESSIVE RUN OUT CAUSING IMPROPER SERPENTINE BELT ALIGNMENT WHICH CREATED EXCESSIVE BELT WEAR. IF PROBLEM IS LEFT UNATTENDED, SERPENTINE BELT/BALANCER CAN SEPARATE CAUSING ENGINE STALL AND LOSS OF POWER STEERING WHICH MAY CAUSE ACCIDENT. CONTACTED MANUFACTURER BUT DID NOT ACKNOWLEDGE A PROBLEM EXISTED EVEN THOUGH THE BALANCER WAS REDESIGNED. BALANCER WAS REPLACED BY THE OWNER AS A PRECAUTIONARY MEASURE TO PREVENT POTENTIAL HAZARDS. I ALSO NOTICED SEVERAL FAILURE NOTICES BY OTHER OWNERS OF THIS SAME BRAND/MODEL OF VEHICLE POSTED ON THE INTERNET. VEHICLE IN QUESTION IS A 1993 SATURN SL2 SDN W/DOHC 1.9L ENGINE COULD NOT FIND THE PROPER CATEGORY TO CLASSIFY THE VEHICLE I THE NEXT PAGES.*JB
THE ALTERNATOR BELT BROKE FOUR TIMES SINCE OWNERSHIP. ON ONE OCCASION, THE CONSUMER WAS DRIVING AT 50 MPH AND THE BELT BROKE, WHICH CAUSED THE POWER STEERING TO BECOME INOPERATIVE, AND ALMOST RESULTING IN AN ACCIDENT. DEALER AND THE MANUFACTURER HAVE BEEN INFORMED OF THE PROBLEM.*AK THE SERPENTINE BELT…
Read full complaint
THE ALTERNATOR BELT BROKE FOUR TIMES SINCE OWNERSHIP. ON ONE OCCASION, THE CONSUMER WAS DRIVING AT 50 MPH AND THE BELT BROKE, WHICH CAUSED THE POWER STEERING TO BECOME INOPERATIVE, AND ALMOST RESULTING IN AN ACCIDENT. DEALER AND THE MANUFACTURER HAVE BEEN INFORMED OF THE PROBLEM.*AK THE SERPENTINE BELT FELL OFF WHILE DRIVING, DEALER REPLACED. *TS *JB
THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD.*JB *TS
VALVE TRAIN SEEMS TO FAIL AT ABOUT 95-160 THOUSAND MILES WITH UNKNOWN CAUSE. CALLED BOTH DEALER AND REPAIR SHOPS. BOTH SEEM TO SAY THE SAME. EITHER VALVE SEATS OR PISTON RINGS FAIL AT THESE POINTS OF MILAGE. BETWEEN 95,000 TO 160,000 MILES WITH UNKNOWN CAUSE. SOME SAID MIGHT BE THE ALUMINUM HEAD DEFECT, OTHERS SAID THAT THERE AR…
Read full complaint
VALVE TRAIN SEEMS TO FAIL AT ABOUT 95-160 THOUSAND MILES WITH UNKNOWN CAUSE. CALLED BOTH DEALER AND REPAIR SHOPS. BOTH SEEM TO SAY THE SAME. EITHER VALVE SEATS OR PISTON RINGS FAIL AT THESE POINTS OF MILAGE. BETWEEN 95,000 TO 160,000 MILES WITH UNKNOWN CAUSE. SOME SAID MIGHT BE THE ALUMINUM HEAD DEFECT, OTHERS SAID THAT THERE ARE STRESS CRACKS FROM THE MOLDING OF THE HEAD. THEY ALL SAY CAN NOT REALLY TELL UNTIL TAKEN APART AND VISUALLY CHECKED. HIGH COST TO DO THIS. BUT NO KNOWN RECALLS ON THE HEAD DEFECT OR VALVE SEAT OR VALVE TRAIN SYSTEM. ALSO ON THE DOOR HINGE, THE DOOR SEALS LET WATER DOWN TO THE HINGE AND IT ROTS OUT THE HINGE ON THE DOOR, CAUSING THE DOOR TO FALL OR ROT OFF.
THE CONSUMER ADDED COOLANT SEVERAL TIMES BUT THE LOW COOLANT LIGHT KEPT COMING. THE DEALER DETERMINED THE CAUSE TO BE A CRACKED CYLINDER HEAD WHICH WAS A MANUFACTURING DEFECT THAT CAUSED THE ENGINE OIL TO BE CONTAMINATED WITH THE ANTIFREEZE. *YH
MY BIGGEST PROBLEMS IS WITH THE STALLING OF THE CAR IN THE MIDDLE OF TRAFFIC. I HAVE ALMOST BEEN IN ONE ACCIDENT AND THERE HAS BEEN ALOT OF TIMES AT WHICH THIS CAR HAS STALLED. THIS VEHICLE IS VERY DANGEROUS TO ME AND MY 4 YEAR OLD BOY AND THE PLACE AT WHICH I AM STILL PAYING FOR THIS CAR AS NOT BEEN COOPERATIVE IN FIXING THIS P…
Read full complaint
MY BIGGEST PROBLEMS IS WITH THE STALLING OF THE CAR IN THE MIDDLE OF TRAFFIC. I HAVE ALMOST BEEN IN ONE ACCIDENT AND THERE HAS BEEN ALOT OF TIMES AT WHICH THIS CAR HAS STALLED. THIS VEHICLE IS VERY DANGEROUS TO ME AND MY 4 YEAR OLD BOY AND THE PLACE AT WHICH I AM STILL PAYING FOR THIS CAR AS NOT BEEN COOPERATIVE IN FIXING THIS PROBLEM WHICH WAS BROUGHT TO THERE ATTENTION FROM DAY ONE. ANNA COLE. *AK
TIMING CHAIN AND GUIDES FAILED. *SLC
ENGINE ACCESS MOUNT COLLAPSED DUE TO AGE AND BECAUSE IT HAS WORN OUT, CAUSING VEHICLE TO SHAKE AND RATTLE BAD. *AK *ML
I WAS TOLD THE PROBLEM COULD POSSIBLY BE WITH THE VALVE GUILDES AND TO SEE IF THERE WAS A RECALL BECAUSE IT IS A COMMON PROBLEM WITH OLDER SATURNS. I CAN NOT FIND ANYTHING ON THIS AND HOPE YOU CAN HELP. *AK
Official recalls
293V132000 · Electrical System:alternator/generator/regulator
Aug 10, 1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
Consequence & remedy
Consequence: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROUNDINGMATERIALS. IF THIS OCCURS, AN UNDERHOOD FIRE COULD RESULT WITH OR WITHOUT THEENGINE RUNNING AND WITHOUT PRIOR WARNING.
Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.
93V094000 · Electrical SYSTEM:12V/24V/48V Battery:cables
May 25, 1993
THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CIRCUIT BETWEEN THE BATTERY CABLE ANDTHE STARTER HOUSING CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: INSPECT AND, IF NECESSARY, ADJUST THE CLEARANCE BETWEEN THE POSITIVE BATTERY CABLE TERMINAL SO THAT IT DOES NOT CONTACT THE STARTER SOLENOID HOUSING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA95003 · Cruise Control Failures
Opened Feb 24, 1995 · Closed May 31, 1996
Status: closed (inferred from source dates) · Equipment
THIS INVESTIGATION DOCUMENTED HTE FUNCTIONAL ABERATIONS THAT HAVE OCCURRED IN THE PERFORMANCE OF THE SUBJECT CRUISE CONTROL SYSTEM.MOST OF THE MALFUNCTIONS INVOLVED FAILURE OF THE SYSTEM TO PROPERLY REGULATE VEHICLE SPEED WHEN ENGAGED, FAILURE OF THE SYSTEM TO ENGAGE, OR SELF-DISENGAGEMENT OF THE SYSTEM. THESE PROBLEMS WERE INVESTIGATED AND STEPS TAKEN BY THE MANUFACTURER TO REMEDY THEIR OCCURRENCES.SERVICE PROCEDURES WERE ISSUED FOR VEHICLES IN USE, AND A DESIGN MODIFICATION MADE FOR NEW VEHICLES.NO CONFIRMED ALLEGATIONS OF FAILURE OF THE SYSTEM TO DISENGAGE UPON COMMAND WERE IDENTIFIED.IMPROVED QUALITY CONTROL PROCEDURES AND DESIGN MODIFICATIONSIN THE SYSTEM WERE UNDERTAKEN TO ENSURE A MORE CONSISTENT LEVEL OF SYSTEM PERFORMANCE.THE DETAILS OF THESE FINDINGS AND THE RESULTING CONCLUSIONS ARE CONTAINED INTHE SUBJECT ENGINEERING ANALYSIS CLOSING REPORT.A SAFETY-RELATED DEFECT TREND WAS NOT IDENTIFIED AT EHIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE94079 · Cruise Control Failure
Opened Nov 7, 1994 · Closed Feb 24, 1995
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
PE93022 · Steering System Lockup
Opened Apr 5, 1993 · Closed Sep 30, 1993
Status: closed (inferred from source dates) · Steering
There is no summary currently available