IllustrationAUTOMATIC SEATBELTS FAILS TO OPERATE. *AK
1991 Saturn Sc
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sc years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
5 reportsMY WIFE WAS DRIVING THE CAR WHEN SMOKE BEGAN TO EMIT AND THE GENERATOR LIGHT WAS ON. THE CAR WAS TOWED TO OUR HOUSE. UPON EXAMINING THE VEHICLE, THE ENGINE BLOCK WAS CRACKED WHERE THE GENERATOR IS SCREWED TO THE ENGINE BLOCK. THE VEHICLE WAS TOWED TO SATURN OF DADELAND ON 05/29/1998. THEY REPLACED CRACKED ENGINE BLOCK, ALL CR…
Read full complaint
MY WIFE WAS DRIVING THE CAR WHEN SMOKE BEGAN TO EMIT AND THE GENERATOR LIGHT WAS ON. THE CAR WAS TOWED TO OUR HOUSE. UPON EXAMINING THE VEHICLE, THE ENGINE BLOCK WAS CRACKED WHERE THE GENERATOR IS SCREWED TO THE ENGINE BLOCK. THE VEHICLE WAS TOWED TO SATURN OF DADELAND ON 05/29/1998. THEY REPLACED CRACKED ENGINE BLOCK, ALL CRANKSHAFT BEARINGS, TIMING CHAIN & GUIDES, PISTON RINGS, VALVE STEM SEALS, & LAPPED ALL VALVES, INSTALLED NEW GENERATOR & BOLTS. TOTAL COST: $3196.67
WHEN OPENING THE DOOR TO GET INTO THE VEHICLE THE SEAT BELT RETRACTOR DOESN'T MOVE. ONCE GETTING IN AND CLOSING THE DOOR, THE SEAT BELT RETRACTOR STILL WILL NOT MOVE. AK CONSUMER ALSO STATED THAT THE ENGINE HAD TO BE REBUILT.*JB
STEERING FAILED, CAUSING ACCIDENT.
BOTH FRONT PASSIVE RESTRAINTS FAIL TO OPERATE, W/OWNER NOTIFYING SATURN MANUFACTURER. PLEASE DESCRIBE DETAILS. TT
Official recalls
193V132000 · Electrical System:alternator/generator/regulator
Aug 10, 1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
Consequence & remedy
Consequence: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROUNDINGMATERIALS. IF THIS OCCURS, AN UNDERHOOD FIRE COULD RESULT WITH OR WITHOUT THEENGINE RUNNING AND WITHOUT PRIOR WARNING.
Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA93016 · Fr Seatback Recliner Fails
Opened Jun 8, 1993 · Closed Jul 26, 1994
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available