IN OCTOBER 2006, MY ENGINE COOLANT LIGHT CAME ON. I WAS TOLD IT WAS A BAD CAP THAT WAS NOT HOLDING THE PRESSURE. WITHIN TWO WEEKS, THE SAME LIGHT CAME ON. I WENT BACK AND THEY SAID CAP WAS FINE AND COULD NOT FIND A PROBLEM. STATED THAT THEY HAD ADDED A DYE TO THE ENGINE COOLANT TO LOOK FOR THE PROBLEM AND COME BACK IN TWO WEEKS.…
Read full complaint
IN OCTOBER 2006, MY ENGINE COOLANT LIGHT CAME ON. I WAS TOLD IT WAS A BAD CAP THAT WAS NOT HOLDING THE PRESSURE. WITHIN TWO WEEKS, THE SAME LIGHT CAME ON. I WENT BACK AND THEY SAID CAP WAS FINE AND COULD NOT FIND A PROBLEM. STATED THAT THEY HAD ADDED A DYE TO THE ENGINE COOLANT TO LOOK FOR THE PROBLEM AND COME BACK IN TWO WEEKS. ALMOST EXACTLY TWO WEEKS LATER, DEC. 1, I RETURNED BECAUSE I HAD FOUND THE PROBLEM. THE COOLANT - INCLUDING THE BRIGHT, FLUORESCENT GREENISH, YELLOWISH DYED - LEAKED ALL IN THE PASSENGER FLOORBOARD AND WAS BEING SOAKED INTO THE MAT AND UPHOLSTERY. MY HEATER CORE HAD FAILED. WHEN I QUESTIONED THE WISDOM OF USING THE DYE, SATURN SAID THERE WAS NO WAY FOR THEM TO KNOW THIS WOULD HAPPEN, IE LEAK INTO MY CAR - YET I HAVE FOUND ONLINE MANY COMPLAINTS OF THE SAME HEATER CORE PROBLEM. *JB
NHTSA ODI #10174913
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP08002 · Timing Chain FAILURE-STALL
Opened Jun 18, 2008 · Closed Oct 16, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JUNE 6, 2006, ODI OPENED AN INVESTIGATION OF TIMING CHAIN FAILURE RESULTING IN ENGINE STALL WHILE DRIVING WITH NO RESTART IN APPROXIMATELY 20,514 MODEL YEAR (MY) 2001 SATURN L-SERIES VEHICLES EQUIPPED WITH 2.2L ENGINES (L61) BUILT FROM NOVEMBER 2000 THROUGH FEBRUARY 2001 (EA06-009).THE VEHICLES BUILT DURING THOSE MONTHS EXHIBITED HIGHER FAILURE RATES THAN SIMILARLY EQUIPPED VEHICLES BUILT BEFORE AND AFTER.GM INTRODUCED A NEW TIMING CHAIN DESIGN IN PRODUCTION IN MAY 2002.ODI CLOSED ITS INVESTIGATION AFTER GM INITIATED A SAFETY RECALL ON NOVEMBER 7, 2007 (RECALL 07V-519). ON MAY 22, 2008, THE NORTH CAROLINA CONSUMERS COUNCIL (NCCC) SUBMITTED A DEFECT PETITION TO ODI REQUESTING THE EXPANSION OF RECALL 07V-519 TO INCLUDE ALL MY 1999 THROUGH 2003 SATURN L-SERIES VEHICLES WITH 2.2L ENGINES USING THE SAME TIMING CHAIN DESIGN AS THE RECALLED POPULATION.THE PETITION STATES THAT THE NCCC CONTINUES TO RECEIVE COMPLAINTS FROM CONSUMERS THAT HAVE HAD A TIMING CHAIN FAIL IN VEHICLES BUILT OUTSIDE THE PRODUCTION RANGE COVERED BY THE RECALL.THE PETITION ALSO NOTES THAT ODI HAS CONTINUED TO RECEIVE COMPLAINTS.SINCE THE CLOSING OF EA06-009 ODI HAS RECEIVED 80 NEW COMPLAINTS FROM CONSUMERS WHO HAD A TIMING CHAIN FAIL IN A MY 2000 THROUGH 2002 SATURN L-SERIES WITH THE 2.2L ENGINE THAT WERE NOT COVERED BY RECALL 07V-519 AND WERE BUILT PRIOR TO THE TIMING BELT CHANGE IN MAY 2002.THE COMPLAINTS DESCRIBE THE SAME FAILURE MODE AS THE RECALLED POPULATION WHERE THE TIMING CHAIN CAN BREAK SUDDENLY AND WITHOUT WARNING, RESULTING IN ENGINE DAMAGE AND LOSS OF MOTIVE POWER.THE DEFECT PETITION HAS BEEN GRANTED. A PRELIMINARY EVALUATION (PE08-061) HAS BEEN OPENED.
2001 Saturn Saturn L Series Problems, Complaints & Recalls | Skip That Year
Illustration