Engine And Engine Cooling. Review the 200 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

12 crash reports12 fire reports5 injury reports

What owners actually said

493 reports

Mileage unknown · May 1, 2023

Electrical SystemExterior Lighting

Rear tail lights will not work. Have checked all fuses relays,and even changed the turn signal switch. My car is currently at the garage. Original appointment was only for inspection. Mechanic has not yet located the issue. Also has no dash lights. Parking lights. Had I known this in advance would have returned car immediately.

NHTSA ODI #11519745

118,000 miles · Apr 3, 2023

Electrical SystemUnknown Or Other

Read full complaint

The contact owns a 2002 Saturn J-Type. The contact stated that while driving at an undisclosed speed, the vehicle's brake lights failed to illuminate. The contact related the failure to NHTSA Campaign Number: 05V245000 (Exterior Lighting), however, the part to do the recall repair is no longer being manufactured. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.

NHTSA ODI #11515269

Mileage unknown · Jun 23, 2022

Engine

The same thing is happening to my car that happened to many Saturn owners of the same year. The car is turning but only stays on for a few seconds before shutting off. This seems to be the same as the ignition module and spark plugs issue as it is the same symptoms as those people were experiencing.

NHTSA ODI #11470765

102,057 miles · Feb 10, 2021

Engine

ENGINE STALLED WHILE DRIVING AT HIGHWAY SPEEDS AROUND 65-70 MPH. ENGINE COULD NOT BE RESTARTED AND HAD TO BE TOWED BACK HOME. MECHANIC INSPECTION REVEALED COMPLETE LOSS OF COMPRESSION IN TWO CYLINDERS AND PARTIAL COMPRESSION LOSS IN OTHER TWO. ENGINE WAS PERMANENTLY DAMAGED AND WOULD HAVE TO BE REPLACED OR REBUILT AT HIGH COS…

Read full complaint

NHTSA ODI #11395636

130,000 miles · May 26, 2020

Electrical System

MECHANIC FOUND SHORT CIRCUIT IN TAIL LAMP ASSEMBLIES CAUSING BRAKE LIGHTS TO COME ON, AND STAY ON, WHEN HEADLAMPS DO. *TR

NHTSA ODI #11325941

175 miles · Sep 24, 2019

EngineService BrakesSteering

Read full complaint

VEHICLE WAS IN MOTION AT 30 MPH ON CITY STREET, ENGINE COMPLETELY STOPPED WORKING WITH LOSS OF POWER STEERING AND POWER BRAKES. COASTED VEHICLE TO A SIDE STREET & STOPPED. HAD CAR TOWED TO A MECHANIC. WE WERE QUOTED $1700 BILL TO REPAIR DUE TO BROKEN TIMING CHAIN. RESEARCHED RECALLS AND FOUND THAT NHTSA HAD A RECALL #07V519000 FOR 2001 SATURN L100. THIS SEEMS GROSSLY SHORTSIGHTED ON THE PART OF NHTSA, AS THERE HAVE BEEN DOZENS OF DUPLICATE COMPLAINTS. THIS PROMPTED THE STATE OF NORTH CAROLINA CONSUMERS COUNCIL TO ISSUE A DEFECT PETITION FOR 2000-2003 SATURN L SERIES WITH THE 2.2L ENGINE WITH THE NHTSA. IT IS SURPRISING HOW LITTLE EFFORT THE NHTSA HAS MADE IN LIGHT OF THE SCOPE OF THIS PROBLEM.

NHTSA ODI #11257582

Mileage unknown · Jul 30, 2018

Electrical SystemElectronic Stability Control (esc)Power Train

Read full complaint

TAKATA RECALL VEHICLE IN PARK WHEN STARTED. LIGHTS DIM AN GO BRIGHT ON DASH. FAN GOES ON WHEN MOTOR NOT HOT. WHEN FAN GOES ON AND CAR IS BEING DRIVEN CAR WILL JUMP WHEN CAR SHIFTS GEARS. I ONLY CAN DRIVE ON SIDE ROADS. TO NERVOUS TO GO ON HIGHWAY NOW. ONLY HAPPENS WHEN COOLING FAN IS ON. I HAVE SEEN LOTS OF REPORTS THAT PEOPLE POST OF OTHER CARS LIKE MINE HAVING SAME ISSUES. WAS TOLD THEY REPORTED IT. NOTHING WAS DONE. SERIOUSLY THIS NEEDS TO BE ADDRESSED. SHOULDN'T MATTER WERE THE CAR WAS MADE. PARTS ARE THE SAME. I HAVEN'T BROUGHT IT IN SINCE 2017. I DON'T HAVE MONEY FOR REPAIRS OR FIX IT IF IT'S THE MANUFACTURS FAULTY PARTS. I'VE ALREADY PUT 1400 DOLLARS FOR REPLACEMENT OF FUEL PUMP AN OTHER PARTS. AN THIS PROBLEM STILL EXISTS. PLEASE LET ME KNOW IF AN WHEN YOU CAN LOOK INTO THIS ISSUE.

NHTSA ODI #11114655

117,000 miles · Feb 15, 2018

Fuel/propulsion SystemService Brakes, HydraulicStructure

Read full complaint

TL* THE CONTACT OWNS A 2002 SATURN LS. WHILE PUMPING FUEL INTO THE FUEL TANK, THE CONTACT NOTICED THAT FUEL WAS LEAKING OUT OF THE TANK. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE LEAKAGE SEEMED TO COME FROM THE TUBE, BUT WAS NOT COMPLETELY SURE. THE CONTACT ALSO NOTICED THAT THE BRAKE LINES WERE RUSTED. THE CONTACT RESEARCHED THE FAILURE ONLINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE CONTACT ALSO STATED THAT THE SERVICE ENGINE INDICATOR WAS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.

NHTSA ODI #11073072

Mileage unknown · Dec 26, 2017

Electrical SystemSteering

Read full complaint

HELLO I AM CONCERNED THAT MY VEHICLE HAS HAD A RECALL ON IT AND I WAS NOT AWARE OF IT I WAS ASKED TO GET IN TOUCH WITH YOU ALL ON SATURDAY WHEN THE KEYS TO MY SATURN WOULD NOT START MY VEHICLE , IT IS A USED VEHICLE, THE ONLY CAR I HAVE TO GET TO AND FROM WORK ,WHEN I PURCHASED THIS VEHICLE THERE WAS NOTHING WRONG WITH IT AND STILL NOTHING IS WRONG EXCEPT THAT IGNITON,. I PURCHASED IT 05-09-13, I AM UNABLE TO GET TO WORK WITHOUT IT. NOW I UNDERSTAND THAT THERE WAS IN FACT A RECALL ON THIS VEHICLE ON PARTS OF IT, NOW THE PART I NEED REPAIRED IS MY IGNITION AND I SEE WHERE THAT IS PART OF YOU ALL REPAIR AGREEMENT AND I WAS WONDERING COULD YOU ALL REPAIR IT? MY VEHICLE WAS WORKING FINE UP UNTIL SATURDAY MORNING WHEN I DROVE MY VEHICLE TO THE LOCAL GROCERY STORE HER IN OUR TOWN AND ALL, I HAD GOT IN MY VEHICLE AND PUT KEY IN IGNITION AND IT WOULDN'T START, THIS HAPPENED WHEN I CAME OUT OF GROCERY STORE, THE KEY WOULDN'T BUDGE, THEREFORE I TRIED OTHER KEY THAT I HAVE TO THE CAR AND IT WOULDN'T BUDGE, I THEN PANICKED AND CALLED NEIGHBOR WHO CHECKS MY VEHICLE FROM TIME TO TIME , NOW MIND YOU WE ARE IN THE GROCERY STORES PARKING LOT IT WAS COLD AND SLIGHTLY WINDY, HE CAME OUT CHECKED ENGINE ALTERNATOR AND BATTERY IT WAS NEITHER , THEREFORE HE USED A METHOD TO GET KEY INSIDE AND TURN , WHICH HE STATED THAT THE TUMBLER INSIDE THE IGNITION HAD DROPPED , WHICH IT TOOK THE COLUMN OFF THE IGNITON AREA AND STATED THAT I NOT REMOVE KEY FROM CAR IF I WANTED TO DRIVE IT ,THAT WAS NOT WHAT I WANTED TO HEAR, I WAS HURT IT IS THE ONLY VEHICLE I CAN AFFORD AT THIS PRESENT TIME I HAD TO GET HIM TO GET IT TO MY HOUSE , AND HAVE NOT DROVE IT , NOW I HAVE TO WORK AND WITHOUT MY VEHICLE I HAVE NO ONE TO TAKE ME TO AND FROM WORK SO IF YOU CAN WILL U PLEASE SEE IF YOU CAN REPAIR MY VEHICLE. I WIL BE GREATLY APPRECIATED.

NHTSA ODI #11056381

161,000 miles · Nov 21, 2017

Engine

TL* THE CONTACT OWNS A 2002 SATURN LS. WHILE DRIVING 15 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED …

Read full complaint

NHTSA ODI #11047853

Official recalls

05V245000 · Exterior Lighting:brake Lights

Jun 2, 2005

ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.

Consequence & remedy

Consequence: THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP) OR TAIL LAMPS. A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSTALL TWO NEW TAIL LAMP REINFORCING SOCKET ADAPTERS AND SOCKETS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.

05V158000 · Seat Belts

Apr 20, 2005

CERTAIN WAGONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE SEAT BELT ANCHOR MAY SEPARATE FROM THE FLOOR OF THE VEHICLE BEFORE HOLDING THE REQUIRED TEST LOAD FOR THE REQUIRED TIME.

Consequence & remedy

Consequence: IF A SEPARATION OCCURRED IN CRASH, THE RIGHT AND CENTER REAR SEAT OCCUPANTS MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A REAR SEAT CENTER BELT ANCHOR REINFORCEMENT PLATE TO THE FLOOR PAN OF THE VEHICLE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 25, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.

03V231000 · Electrical System:ignition:module

Jun 23, 2003

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L L4 (L61) ENGINES, A FAILURE OF THE IGNITION CONTROL MODULE MAY CAUSE DETERIORATION IN IDLE QUALITY, REDUCTION IN OVERALL ENGINE POWER, AND THE VEHICLE MAY BE HARD TO START. CONTINUED OPERATION OF THE VEHICLE AFTER SUCH AN IGNITION MODULE FAILURE WILL RESULT IN THE "SERVICE ENGINE SOON" LIGHT FLASHING, AND MAY LEAD TO SECONDARY FAILURES OF THE CATALYTIC CONVERTER, OXYGEN SENSOR, AND EXHAUST RESONATOR.

Consequence & remedy

Consequence: FAILURE OF THE RESONATOR WILL CAUSE INCREASED EXHAUST NOISE. PROLONGED OPERATION OF THE VEHICLE FOLLOWING A RESONATOR FAILURE MAY LEAD TO A FIRE.

Remedy: DEALERS WILL (1) REPLACE THE IGNITION CONTROL MODULE, (2) REPLACE THE IGNITION CONTROL MODULE AND SPARK PLUGS, OR (3) REPLACE THE IGNITION CONTROL MODULE, SPARK PLUGS, AND UPDATE THE POWERTRAIN CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN ON AUGUST 4, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000, PROMPT 3.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE09028 · Fuel Pump Leaks

Opened May 21, 2009 · Closed Oct 27, 2009

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION BASED ON NINE VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS ALLEGING GASOLINE LEAKAGE FROM THE IN-TANK FUEL PUMP ASSEMBLY.SOME COMPLAINANTS REPORTED LEAKS FROM THE FUEL PUMP NIPPLE (I.E., THE FITTING FOR THE FUEL SUPPLY AND/OR RETURN HOSES).OTHERS REPORTED LEAKAGE FROM FUEL PUMP CRACKS, FUEL PUMP LINES, AND FROM THE TOP OF THE FUEL TANK.ODI WAS UNABLE TO VERIFY THAT ALL OF THE LEAKS ORIGINATED FROM THE FUEL PUMP HOSE FITTINGS AND OR NIPPLES.ODI'S ANALYSIS OF THE AVAILABLE COMPLAINT DATA ATTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES SHOW A LOW OVERALL RATE AND A DECLINING TREND, AS 75% OF THE REPORTS WERE RECEIVED PRIOR TO CALENDAR YEAR 2009.COMPLAINT DATA FOR MODEL YEAR 2001 AND 2003 VEHICLES ALSO DEMONSTRATES A LOW RATE AND SIMILAR DECLINING TREND.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Additional source detail variants (2)

Fuel System, Gasoline:delivery:fuel Pump

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

PE08061 · Timing Chain Breaks, Engine Stall

Opened Oct 16, 2008 · Closed Apr 8, 2009

Status: closed (inferred from source dates) · Engine And Engine Cooling

ON MAY 22, 2008, THEOFFICE OF DEFECTS INVESTIGATION (ODI) WAS PETITIONED BY THE NORTH CAROLINA CONSUMERS COUNCIL (NCCC) TO BROADEN THE SCOPE OF SAFETY RECALL 07V-519, WHICH WAS CONDUCTED BY GENERAL MOTORS CORPORATION (GM) FOR MODEL YEAR (MY) 2001 SATURN L-SERIES VEHICLES EQUIPPED WITH THE L61 2.2L ENGINE AND BUILT DURING A 4-MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001 (DP08-002). ON OCTOBER 16, 2008, ODI GRANTED DP08-002 AND OPENED PE08-061 TO INVESTIGATE TIMING CHAIN FAILURES RESULTING IN ENGINE STALL WHILE DRIVING (SWD) IN THE SATURN L-SERIES VEHICLES EQUIPPED WITH L61 ENGINES AND THAT USED THE SAME DESIGN TIMING CHAIN AND TIMING CHAIN LUBRICATION SYSTEM AS THE RECALLED VEHICLES.A REDESIGNED TIMING CHAIN AND LUBRICATION SYSTEM WERE IMPLEMENTED LATE IN MY 2002 PRODUCTION (MAY 1, 2002).HENCE, THE SUBJECT VEHICLES FOR THIS INVESTIGATION ARE ALL MY 2000 THROUGH 2002 SATURN L-SERIES VEHICLES EQUIPPED WITH 2.2L L61 ENGINES AND BUILT PRIOR TO MAY 2002 THAT WERE NOT INCLUDED IN RECALL 07V-519. IN THIS INVESTIGATION, ODI ANALYZED UPDATED COMPLAINT AND WARRANTY CLAIMS DATA FOR TIMING CHAIN FAILURES RESULTING IN INCIDENTS OF ENGINE STALL WHILE DRIVING, WHICH COMPRISE SLIGHTLY OVER HALF OF ALL TIMING CHAIN FAILURES OCCURRING IN THE SUBJECT VEHICLE POPULATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA SHOWS THAT VEHICLES PRODUCED WITH THE SUBJECT TIMING CHAIN AND LUBRICATION SYSTEM EXPERIENCED ELEVATED FAILURE RATES WHEN COMPARED WITH THE MY 2002 THROUGH 2003 VEHICLES USING THE REVISED COMPONENTS.HOWEVER, THE ANALYSIS ALSO SHOWED THAT THE MY 2001 SATURN L-SERIES VEHICLES RECALLED IN 07V-518 EXPERIENCED A SIGNIFICANTLY HIGHER RATE OF TIMING CHAIN FAILURES THAN THE SUBJECT VEHICLES.THE COMPLAINT RATE FOR TIMING CHAIN FAILURES RESULTING IN SWD WAS APPROXIMATELY 5 TIMES HIGHER FOR THE RECALLED VEHICLES,19.2 INCIDENTS PER THOUSAND VEHICLES (IPTV), THAN FOR THE SUBJECT VEHICLES, 3.7 IPTV.THE WARRANTY CLAIMS RATE FOR CHAIN FAILURES RESULTING IN SWD WAS OVER 3 TIMES HIGHER FOR THE RECALLED VEHICLES, 2.4 PERCENT, THAN FOR THE SUBJECT VEHICLES, 0.7 PERCENT.THE COMPLAINT AND WARRANTY RATES FOR THE SUBJECT VEHICLES WERE SIMILAR TO RATES RECORDED IN OTHER RECENTLY CLOSED INVESTIGATIONS FOR CONDITIONS THAT COULD RESULT IN SWD WITH NO ENGINE RE-START, EA07-015 AND EA07-018.ANALYSIS OF ALL COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS FOUND NO ALLEGATIONS OF CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AFTER APPROXIMATELY 7 TO 9 YEARS IN SERVICE. ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM TIMING CHAIN FAILURES IN THE SUBJECT VEHICLES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND ALMOST ALWAYS RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE SEVERITY OF STALLING INCIDENTS.HOWEVER, ANALYSIS OF SWD FAILURE RATES IN THE SUBJECT VEHICLES SHOW THAT THEY HAVE OCCURRED AT MUCH LOWER RATES THAN WERE OBSERVED IN THE RECALLED POPULATION.IN ADDITION, THE SWD COMPLAINT AND WARRANTY RATES FOR THE SUBJECT VEHICLES ARE SIMILAR TO RATES OBSERVED IN PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES THAT WERE CLOSED WITH NO ACTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.

DP08002 · Timing Chain FAILURE-STALL

Opened Jun 18, 2008 · Closed Oct 16, 2008

Status: closed (inferred from source dates) · Engine And Engine Cooling

ON JUNE 6, 2006, ODI OPENED AN INVESTIGATION OF TIMING CHAIN FAILURE RESULTING IN ENGINE STALL WHILE DRIVING WITH NO RESTART IN APPROXIMATELY 20,514 MODEL YEAR (MY) 2001 SATURN L-SERIES VEHICLES EQUIPPED WITH 2.2L ENGINES (L61) BUILT FROM NOVEMBER 2000 THROUGH FEBRUARY 2001 (EA06-009).THE VEHICLES BUILT DURING THOSE MONTHS EXHIBITED HIGHER FAILURE RATES THAN SIMILARLY EQUIPPED VEHICLES BUILT BEFORE AND AFTER.GM INTRODUCED A NEW TIMING CHAIN DESIGN IN PRODUCTION IN MAY 2002.ODI CLOSED ITS INVESTIGATION AFTER GM INITIATED A SAFETY RECALL ON NOVEMBER 7, 2007 (RECALL 07V-519). ON MAY 22, 2008, THE NORTH CAROLINA CONSUMERS COUNCIL (NCCC) SUBMITTED A DEFECT PETITION TO ODI REQUESTING THE EXPANSION OF RECALL 07V-519 TO INCLUDE ALL MY 1999 THROUGH 2003 SATURN L-SERIES VEHICLES WITH 2.2L ENGINES USING THE SAME TIMING CHAIN DESIGN AS THE RECALLED POPULATION.THE PETITION STATES THAT THE NCCC CONTINUES TO RECEIVE COMPLAINTS FROM CONSUMERS THAT HAVE HAD A TIMING CHAIN FAIL IN VEHICLES BUILT OUTSIDE THE PRODUCTION RANGE COVERED BY THE RECALL.THE PETITION ALSO NOTES THAT ODI HAS CONTINUED TO RECEIVE COMPLAINTS.SINCE THE CLOSING OF EA06-009 ODI HAS RECEIVED 80 NEW COMPLAINTS FROM CONSUMERS WHO HAD A TIMING CHAIN FAIL IN A MY 2000 THROUGH 2002 SATURN L-SERIES WITH THE 2.2L ENGINE THAT WERE NOT COVERED BY RECALL 07V-519 AND WERE BUILT PRIOR TO THE TIMING BELT CHANGE IN MAY 2002.THE COMPLAINTS DESCRIBE THE SAME FAILURE MODE AS THE RECALLED POPULATION WHERE THE TIMING CHAIN CAN BREAK SUDDENLY AND WITHOUT WARNING, RESULTING IN ENGINE DAMAGE AND LOSS OF MOTIVE POWER.THE DEFECT PETITION HAS BEEN GRANTED. A PRELIMINARY EVALUATION (PE08-061) HAS BEEN OPENED.

PE06006 · Timing Chain Failure

Opened Jan 24, 2006 · Closed Jun 6, 2006

Status: closed (inferred from source dates) · Engine And Engine Cooling

ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).

DP05008 · Timing Chain Failure

Opened Dec 20, 2005 · Closed Feb 6, 2006

Status: closed (inferred from source dates) · Engine And Engine Cooling

ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.

PE05010 · Inoperative Tail Lamps

Opened Feb 15, 2005 · Closed Jun 3, 2005

Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights

GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.

Additional source detail variants (4)

Electrical System

Exterior Lighting:brake Lights

Exterior Lighting

Exterior Lighting:tail Lights

DP05001 · Inoperative Tail Lamps

Opened Feb 10, 2005 · Closed Feb 22, 2005

Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch

ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).

Additional source detail variants (5)

Electrical System

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

PE03017 · Headlamps Flicker Off And On

Opened Apr 17, 2003 · Closed Aug 25, 2003

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch

THIS PE WAS OPENED BASED ON SIX ODI COMPLAINTS THAT HEADLAMPS FLICKER OFF AND ON, AND TWO ODI COMPLAINTS THAT THE SWITCH IS HOT TO THE TOUCH.THE INVESTIGATION HAS FOUND NO OCCURRENCES OF HEADLAMPS GOING OUT.THE COMPLAINTS ARE DUE TO SPORADIC DIMMING (FLICKERING) OF THE HEADLAMPS AS A RESULT OF VARIATION OF THE VOLTAGE TO THE HEADLAMPS.GM HAS SHOWN THAT A 1.5 -2.0 VOLTAGE DROP OCCURS WHEN OTHER ELECTRICAL DEVICES ARE ACTIVATED, HOWEVER AT NO TIME DO THE HEADLAMPS TURN COMPLETELY OFF.WITH RESPECT TO ALLEGATIONS THAT THE HEADLAMP SWITCH IS HOT TO THE TOUCH, GM REPORTS THAT THE AMBIENT TEMPERATURE OF THE SWITCH IS 35 DEGREES C WHICH IS NOT HOT ENOUGH TO BURN A FINGER OR HAND.IN MAY 2001, GM MODIFIED THE HEADLAMP SWITCH CRIMPING OPERATION TO ELIMINATE THE OCCURRENCE OF HOT SWITCHES.ODI EVALUATED THE COMPLAINTS AND WARRANTY RETURNS AND FOUND NO EVIDENCE OF MELTING OR BURNING. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Additional source detail variants (8)

Exterior Lighting

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch