NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
573 reportsMileage unknown · Jun 24, 2014
EngineFuel/propulsion SystemPower Train
**THE OTHER AFFECTED PART WAS SPEED CONTROL.... ASIDE OF THE CURRENT RECALL ISSUE HAVING BEEN A PROBLEM SINCE I PURCHASED THE VEHICLE IN 2005 (WHICH HAS "BEEN REPAIRED"-I GUESS SO IF YOU CALL REPAIRED THE CAR TRYING TO START ITSELF, NOT STARTING AT ALL, CURRENT PCM OVERLOAD THANKS TO SOO MANY NEGATIVE CODES BEING THROWN FOR THI…
Read full complaint
**THE OTHER AFFECTED PART WAS SPEED CONTROL.... ASIDE OF THE CURRENT RECALL ISSUE HAVING BEEN A PROBLEM SINCE I PURCHASED THE VEHICLE IN 2005 (WHICH HAS "BEEN REPAIRED"-I GUESS SO IF YOU CALL REPAIRED THE CAR TRYING TO START ITSELF, NOT STARTING AT ALL, CURRENT PCM OVERLOAD THANKS TO SOO MANY NEGATIVE CODES BEING THROWN FOR THIS WORTHLESS PIECE OF JUNK.) I HAVE FILED NUMEROUS COMPLAINTS WITH THE DEALERSHIP ABOUT THE THROTTLE BODY AND AM CONSTANTLY AND CONSISTENTLY PROVIDED THE SAME ANSWER AND IT IS BECOMING A BIG PROBLEM. YOU SEE THIS CAR HAS LEFT ME STRANDED NUMEROUS TIMES (TO THE POINT WHERE I CANNOT KEEP COUNT ANY LONGER) BECAUSE THE THROTTLE BODY IS TRASH. NOT ONE BUT TWO CHECK ENGINES LIGHTS APPEAR ON THE DASH, THE CAR SHAKES (LITERALLY TO THE POINT WHERE IT FEELS LIKE EVERY PLASTIC PANEL IS GOING TO FALL OFF), I CANNOT TRAVEL ANY HIGHER THAN APPROX. 10MPH AND HAVE TO PULL OVER, TURN THE CAR OFF (KEYS OF COURSE BECOME STUCK IN THE IGNITION DUE TO THE FAULTY SWITCH) AND WAIT UNTIL MY CAR IS THEN READY TO START AND THE THROTTLE BODY WANTS TO OPERATE AS IT SHOULD. I AM NOW FILING THIS COMPLAINT AS THE MOST RECENT CODES PULLING ARE ONCE AGAIN THE THROTTLE BODY AND THE NOW THE PCM. THIS PART NEEDS TO BE ADDED TO RECENT RECALLS. IT IS NOT SAFE TO BE TRAVELING AT 45MPH OR HIGHER, THEN THE VEHICLE SHUTS DOWN AND LOWERS SPEED TO 10MPH OR LESS-ESP. IF YOU HAVE NO WHERE TO PULL OVER SAFELY (YES, THIS HAS HAPPENED TO ME ON MORE THAN ONCE.) I HAVE MY CAR BACK FROM THE RECALL THE CAR TO STILL WONT START, TRIES TO TURN ITSELF OVER & KEEPS MY KEYS STUCK IN THE IGNITION. MY STEERING COLUMN HAS BEEN BUSTED OPEN ON THE BOTTOM IN ORDER TO RELEASE THE KEYS WHICH IS RIDICULOUS YET MY CAR IS STILL NOT FUNCTIONAL DUE TO OTHER FAULTY, CRAP, JUNK, TRASH (WHATEVER YOU WOULD PREFER TO LIST THEM AS IN THIS DOCUMENTATION) PARTS THAT I WILL MOST LIKELY BE EXPECTED TO PAY FOR YET AGAIN. *TR
NHTSA ODI #10605583
Mileage unknown · Jun 16, 2014
Electrical SystemEngineSuspension
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO SEVERAL RECALL DEFECTS AND REQUESTS REIMBURSEMENT FOR VEHICLE REPAIRS. *SMD THE CONSUMER STATED THE VEHICLE BROKE DOWN AND HAD TO BE TOWED TO THE NEAREST REPAIR FACTUALITY, WHERE THERE KEPT THE VEHICLE FOR OVER TWO MONTHS. AFTER THE VEHICLE WAS RETURNED, THE PROBLEMS CONTINUED. …
Read full complaint
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO SEVERAL RECALL DEFECTS AND REQUESTS REIMBURSEMENT FOR VEHICLE REPAIRS. *SMD THE CONSUMER STATED THE VEHICLE BROKE DOWN AND HAD TO BE TOWED TO THE NEAREST REPAIR FACTUALITY, WHERE THERE KEPT THE VEHICLE FOR OVER TWO MONTHS. AFTER THE VEHICLE WAS RETURNED, THE PROBLEMS CONTINUED. THE ENGINE LIGHT WAS ON AND THERE WAS A PROBLEM WITH THE IGNITION SWITCH. ALSO, THE ENGINE VALES, TIMING CHAIN AND SWAY BAR LINKS WERE REPLACED. *JB
NHTSA ODI #10595094
61,399 miles · Jun 15, 2014
Electrical System
ISSUE STARTED IN 2009. IGNITION SWITCH WOULD NOT START CAR. ONCE CAR WAS RUNNING COULD NOT TURN OFF CAR WITH IGNITION SWITCH ON OFF. KEY WOULD NOT COME OUT OF IGNITION SWITCH. THAT WAS THE FIRST TIME I HAD THE SWITCH REPLACED. HAD THE IGNITION SWICH REPLACED 2 MORE TIMES IN THE NEXT 4 YEARS. I AM STILL HAVING AN ISSUE WITH GETT…
Read full complaint
ISSUE STARTED IN 2009. IGNITION SWITCH WOULD NOT START CAR. ONCE CAR WAS RUNNING COULD NOT TURN OFF CAR WITH IGNITION SWITCH ON OFF. KEY WOULD NOT COME OUT OF IGNITION SWITCH. THAT WAS THE FIRST TIME I HAD THE SWITCH REPLACED. HAD THE IGNITION SWICH REPLACED 2 MORE TIMES IN THE NEXT 4 YEARS. I AM STILL HAVING AN ISSUE WITH GETTING MY KEY OUT OF THE SWITCH, EVEN AFTER THE LAST RECALL WITH IT BEING REPLACED THE 4TH TIME. *JS
NHTSA ODI #10598355
Mileage unknown · Jun 14, 2014
Electrical SystemSteering
HAVE A 2005 SATURN ION THAT WAS PART OF IGNITION SWITCH AND CYLINDER RECALLS. HAVE HAD ISSUES WITH IGNITION AND ELECTRICAL SINCE 2006, BUT WAS "PUT OFF" BY LOCAL SATURN DEALERSHIP ON AT LEAST 6 OCCASIONS WHEN I QUESTIONED THEM ABOUT THE PROBLEM. FINALLY RECEIVED RECENT IGNITION RECALL, AND CONTACTED CHEVY DEALER TO FIX. DEALER P…
Read full complaint
HAVE A 2005 SATURN ION THAT WAS PART OF IGNITION SWITCH AND CYLINDER RECALLS. HAVE HAD ISSUES WITH IGNITION AND ELECTRICAL SINCE 2006, BUT WAS "PUT OFF" BY LOCAL SATURN DEALERSHIP ON AT LEAST 6 OCCASIONS WHEN I QUESTIONED THEM ABOUT THE PROBLEM. FINALLY RECEIVED RECENT IGNITION RECALL, AND CONTACTED CHEVY DEALER TO FIX. DEALER PAID FOR RENTAL CAR UNTIL REPAIR WAS DONE (ABOUT 1 MONTH) AS INSTRUCTED BY GM CORPORATE. I ASKED DEALER ABOUT POWER STEERING RECALL AS CORPORATE HAD STATED MY VEHICLE WAS INVOLVED IN THAT RECALL AS WELL. DEALER FOUND NO HISTORY OF RECALL IN THEIR SYSTEM (CHECKED ON 2 OCCASIONS). I CALLED GM CORPORATE 3 TIMES AND WAS TOLD THE SAME STORY...MY CAR IS PART OF POWER STEERING RECALL (AS PER VIN), AND I WOULD RECEIVE MY RECALL LETTER SHORTLY. IT IS NOW JUNE, HAVE NOT RECEIVED RECALL LETTER FOR POWER STEERING. IGNITION WORKING OKAY NOW, BUT OTHER ELECTRICAL PROBLEMS STILL OCCURRING. ALERT CHIME FOR HEADLIGHTS AND TURN SIGNALS DOES NOT WORK. UNABLE TO CHANGE RADIO STATION ON DIGITAL FACTORY RADIO WITH DIGITAL SCREEN TURNING OFF WHEN I ATTEMPT ANY STATION CHANGE OR PRESS ANY BUTTON ON THE RADIO. ALL WINDOWS BUT DRIVER'S BACK WINDOW WOULDN'T ROLL DOWN. WAS TOLD BY CHEVY DEALER THAT THE ELECTRICAL ISSUES WERE NOT RELATED TO IGNITION SWITCH, MAY BE RELATED TO DASHBOARD MALFUNCTION. WINDOWS WERE RELATED TO DOOR MOTOR (REPLACED MYSELF, 3RD TIME FOR THIS). DEALER REFUSED TO FIX ELECTRICAL ISSUES, AND REFUSED TO PROACTIVELY FIX THE POWER STEERING IN ACCORDANCE WITH CORPORATE RECALL CAUSE THEY DIDN'T HAVE PAPERWORK. DEALER WAS GOING TO CHARGE ME LARGE FEE FOR FIXING ANY OF THE OTHER ISSUES EXCEPT FOR IGNITION SWITCH AND CYLINDER. GM HAS MADE SUBSTANDARD VEHICLES FOR YEARS AND DRAGGING THEIR FEET TO FIX THEIR MISTAKES. CAN'T TRADE OR SELL MY VEHICLE TIL THIS IS FIXED. FEEL LIKE I'VE BEEN DRIVING AROUND A DEATH TRAP. DO SOMETHING SOME ONE PLEASE!!!!!! *JS
NHTSA ODI #10598309
Mileage unknown · Jun 13, 2014
Electrical SystemEngineVisibility/wiper
I'VE MADE REPORTS OF FAULTY SWITCH IGNITION PROBLEMS IN 2010 TO GM THE REPLACED IT WITH ANOTHER AND I STILL HAD ISSUES WITH IT. I ALSO HAD ISSUES WITH MY WINDSHIELD WIPERS WHICH I ENDED UP REPLACING AFTER I WAS TOLD THEY WERE NOT AT FAULT. I'VE BEEN HAVING PROBLEMS STARTING THE CAR OR EITHER IT WOULD CUT OFF WHILE DRIVING AND C…
Read full complaint
I'VE MADE REPORTS OF FAULTY SWITCH IGNITION PROBLEMS IN 2010 TO GM THE REPLACED IT WITH ANOTHER AND I STILL HAD ISSUES WITH IT. I ALSO HAD ISSUES WITH MY WINDSHIELD WIPERS WHICH I ENDED UP REPLACING AFTER I WAS TOLD THEY WERE NOT AT FAULT. I'VE BEEN HAVING PROBLEMS STARTING THE CAR OR EITHER IT WOULD CUT OFF WHILE DRIVING AND CAUSE PROBLEMS FOR ME TO RESTART IT. I RECENTLY TOOK IT TO A DEALERSHIP TO HAVE THE RECALL ISSUE FIXED BUT I WAS INFORMED THAT OTHER ISSUES ALSO OCCURRED AND GM REFUSED TO FIX. *JS
NHTSA ODI #10598179
Mileage unknown · Jun 12, 2014
Electrical SystemSteering
REACHED OUT TO DEALER IN APRIL REGARDING IGNITION SWITCH AND CYLINDER, AND POWER STEERING ASSIST RECALLS. PARTS HAVE ALLEGEDLY BEEN ORDERED FOR THE IGNITION SWITCH AND CYLINDER RECALLS. HOWEVER, NEVER BEEN CALLED STATING PARTS ARE IN. NEVER BEEN ASKED TO MAKE APPOINTMENT TO BRING CAR IN. NEVER ANY MENTION OF THE POWER STEERI…
Read full complaint
REACHED OUT TO DEALER IN APRIL REGARDING IGNITION SWITCH AND CYLINDER, AND POWER STEERING ASSIST RECALLS. PARTS HAVE ALLEGEDLY BEEN ORDERED FOR THE IGNITION SWITCH AND CYLINDER RECALLS. HOWEVER, NEVER BEEN CALLED STATING PARTS ARE IN. NEVER BEEN ASKED TO MAKE APPOINTMENT TO BRING CAR IN. NEVER ANY MENTION OF THE POWER STEERING RECALL. DEALER I CONTACTED IS CHEVROLET OF HOMEWOOD. 18033 HALSTED ST, HOMEWOOD, IL 60430. (708) 799-2000. EVERYTIME I CALL, I AM TOLD PARTS HAVE NOT BEEN RECEIVED YET. HOWEVER, I DID RECEIVE A CARD IN THE MAIL FROM SATURN STATING THEIR RECORDS INDICATE I HAVE NOT HAD MY CAR IN THE RECALL YET. WOULD VERY MUCH LIKE TO GET IN. CARD MAKES ME BELIEVE DEALER MAY BE BLOWING OFF. NEED ASSISTANCE IN MAKING THIS HAPPEN. *TR
NHTSA ODI #10597945
89,450 miles · Jun 12, 2014
Air BagsElectrical System
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO REIMBURSEMENT REQUEST INFORMATION. *SMD
NHTSA ODI #10597159
Mileage unknown · Jun 11, 2014
Steering
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO POWER STEERING GOING OUT CONSTANTLY. *SMD THE CONSUMER COULD NOT AFFORD THE $500 REPAIR BILL, FOR THE STEERING ISSUE, AND HAS SINCE SOLD THE VEHICLE. *JB
NHTSA ODI #10594070
60,000 miles · Jun 5, 2014
Electrical System
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF, THE KEY COULD NOT BE REMOVED FROM THE IGNITION SWITCH. THE CONTACT INDICATED THAT AFTER SEVERAL HOURS THE KEY WAS ABLE TO BE REMOVED FROM THE IGNITION SWITCH. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED ON MULTIPLE OCCASIONS. THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF, THE KEY COULD NOT BE REMOVED FROM THE IGNITION SWITCH. THE CONTACT INDICATED THAT AFTER SEVERAL HOURS THE KEY WAS ABLE TO BE REMOVED FROM THE IGNITION SWITCH. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS REPAIRED UNDER NHTSA RECALL CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10596382
Mileage unknown · Jun 5, 2014
Electrical SystemEngine
ON APRIL 28, I CALLED A DEALER IN SYRACUSE, NY ABOUT GETTING THE RECALLED IGNITION SWITCH REPLACED. CALLED LAST WEEK ABOUT IT. THEY STILL HAVEN'T ORDERED IT. THREE WEEKS AGO I CALLED ANOTHER DEALERSHIP, DAVIDSONS IN WATERTOWN, NY. STILL HAVEN'T BEEN CONTACTED BY EITHER OF THESE. HOW LONG SHOULD WE HAVE TO WAIT TO GET THIS D…
Read full complaint
ON APRIL 28, I CALLED A DEALER IN SYRACUSE, NY ABOUT GETTING THE RECALLED IGNITION SWITCH REPLACED. CALLED LAST WEEK ABOUT IT. THEY STILL HAVEN'T ORDERED IT. THREE WEEKS AGO I CALLED ANOTHER DEALERSHIP, DAVIDSONS IN WATERTOWN, NY. STILL HAVEN'T BEEN CONTACTED BY EITHER OF THESE. HOW LONG SHOULD WE HAVE TO WAIT TO GET THIS DANGEROUS SITUATION RESOLVED.. *TR
NHTSA ODI #10596277
Official recalls
3Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration