IllustrationDASH LIGHTS GO OUT AND ALL SYSTEMS ARE YOU FUNCTIONING PROPERTY
2005 Saturn Ion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Saturn Ion do not stand out strongly from the model-year median of 816.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
640–25K
10425–50K
11450–75K
7875–100K
75100–150K
31150K+
466 reports with mileage · 107 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 265 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports4 fire reports13 injury reports
Vehicle Speed Control complaints
18 reportsTHIS HAS HAPPENED SEVERAL TIMES IN RECENT MONTHS, BUT HERE IS WHAT HAPPENED THIS MORNING: I WAS ON THE INTERSTATE, GOING ABOUT 60MPH, AND I SPED UP TEMPORARILY TO PASS THE SEMI NEXT TO ME SO THAT I COULD MERGE INTO THE RIGHT LANE AND CATCH THE NEXT EXIT. UPON MERGING, I RELEASED THE GAS PEDAL BUT IT DID NOT COME BACK NATURALLY W…
Read full complaint
THIS HAS HAPPENED SEVERAL TIMES IN RECENT MONTHS, BUT HERE IS WHAT HAPPENED THIS MORNING: I WAS ON THE INTERSTATE, GOING ABOUT 60MPH, AND I SPED UP TEMPORARILY TO PASS THE SEMI NEXT TO ME SO THAT I COULD MERGE INTO THE RIGHT LANE AND CATCH THE NEXT EXIT. UPON MERGING, I RELEASED THE GAS PEDAL BUT IT DID NOT COME BACK NATURALLY WITH MY FOOT AND INSTEAD WENT TO THE FLOOR AND MY CAR STARTED ACCELERATING AS I EXITED THE INTERSTATE ONTO A FLYOVER RAMP. I IMMEDIATELY HIT MY BRAKES AND WAS ABLE TO REGAIN CONTROL OF THE SPEED, BUT IT SCARED ME, ESPECIALLY AS THE FLYOVER RAMP REQUIRES A SLOWER SPEED ALONG THE CURVE. TO THE BEST OF MY RECOLLECTION, IN ALL CASES WHERE THIS HAS HAPPENED, I HAVE BEEN GOING AT LEAST 35 MPH WHEN IT HAPPENED, AND MY CRUISE CONTROL WAS ON BUT NOT ACTIVE (IN OTHER WORDS I HAD IT AVAILABLE TO ME BUT IT WAS NOT CURRENTLY SET AT ANY PARTICULAR SPEED). I HAVE SEEN MULTIPLE SIMILAR COMPLAINTS IN FORUMS ONLINE, BUT I AM NOT AWARE OF A RECALL. THIS IS OBVIOUSLY AN EXTREMELY DANGEROUS ISSUE, ESPECIALLY AT HIGH SPEEDS IN DENSE TRAFFIC. PLEASE INVESTIGATE FURTHER -- I CANNOT AFFORD TO HAVE MY MECHANIC REPLACE ALL THE POSSIBLE FAULTY PARTS WITH OTHER POTENTIALLY FAULTY PARTS, AND I WOULD HATE TO BE THE CAUSE OF AN ACCIDENT BECAUSE THE CAR WAS OUT OF MY CONTROL THROUGH NO FAULT OF MINE.
TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING 10 MPH AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A BUILDING AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING 10 MPH AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A BUILDING AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.
AFTER OWNING THIS CAR FOR A FEW YEARS NOW AND BECOMING HIGHLY INVOLVED IN THE FORUMS. I'VE LEARNED THAT IT'S A COMMON ISSUE FOR THE CLOCK SPRING TO BREAK. WHEN IT DOES, IT CUTS POWER PERMANENTLY TO THE DRIVER AIR BAG, AND CRUISE CONTROL UNTIL REPAIRED. THIS IS A BIG SAFETY CONCERN AS NO POWER TO THE AIRBAG WOULD RESULT IN MORE S…
Read full complaint
AFTER OWNING THIS CAR FOR A FEW YEARS NOW AND BECOMING HIGHLY INVOLVED IN THE FORUMS. I'VE LEARNED THAT IT'S A COMMON ISSUE FOR THE CLOCK SPRING TO BREAK. WHEN IT DOES, IT CUTS POWER PERMANENTLY TO THE DRIVER AIR BAG, AND CRUISE CONTROL UNTIL REPAIRED. THIS IS A BIG SAFETY CONCERN AS NO POWER TO THE AIRBAG WOULD RESULT IN MORE SERIOUS INJURY OR POSSIBLY DEATH. *TR
MY SEAT BELTS WILL NO LONGER BUCKLE. MY SHIFT GETS STUCK IN PARK AND JUMPS INTO OTHER GEARS(NEUTRAL) AND THE CAR REVS ON IT'S OWN WITHOUT PUTTING FOOT ON GAS. MY SHIFT IS DOING THE EXACT SAME THING AS THE RECALL FOR THE AURA AND THE DEALER WANTS TO CHARGE ME $700.00 IN REPAIRS AND THE PARTS ARE ON BACK ORDER FOR 6 MONT…
Read full complaint
MY SEAT BELTS WILL NO LONGER BUCKLE. MY SHIFT GETS STUCK IN PARK AND JUMPS INTO OTHER GEARS(NEUTRAL) AND THE CAR REVS ON IT'S OWN WITHOUT PUTTING FOOT ON GAS. MY SHIFT IS DOING THE EXACT SAME THING AS THE RECALL FOR THE AURA AND THE DEALER WANTS TO CHARGE ME $700.00 IN REPAIRS AND THE PARTS ARE ON BACK ORDER FOR 6 MONTHS. I DO NOT HAVE MY VIN# AT THIS TIME. PLEASE CHECK WITH HERB CHAMBERS SATURN -WARWICK, RI. *TR
THE GAS PEDAL GETS STUCK WHILE DRIVING AND THE CHECK ENGINE LIGHT COMES ON. CAR WILL NOT EXCEED 5 MPH EVEN IF THE PEDAL IS PUSHED TO THE FLOOR. CAR MUST BE TURNED ON AND OFF 3 TIMES FOR THE PEDAL TO GO BACK TO NORMAL. ANOTHER INCIDENT IS THE CAR WILL STALL WHEN STOPPING AT A LIGHT OR STOP SIGN. TURNS BACK ON WITH NO PROBLEM. I H…
Read full complaint
THE GAS PEDAL GETS STUCK WHILE DRIVING AND THE CHECK ENGINE LIGHT COMES ON. CAR WILL NOT EXCEED 5 MPH EVEN IF THE PEDAL IS PUSHED TO THE FLOOR. CAR MUST BE TURNED ON AND OFF 3 TIMES FOR THE PEDAL TO GO BACK TO NORMAL. ANOTHER INCIDENT IS THE CAR WILL STALL WHEN STOPPING AT A LIGHT OR STOP SIGN. TURNS BACK ON WITH NO PROBLEM. I HAVE HAD ALL RECALLS PERFORMED. *TR
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED THE VEHICLE FAILED TO RESPOND. THE CONTACT HAD TO WAIT BEFORE THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE DEALER DIAGNOSED THAT THE ELECTRONICS ON THE PEDAL FAILED. HOWEVER, THE PART …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED THE VEHICLE FAILED TO RESPOND. THE CONTACT HAD TO WAIT BEFORE THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE DEALER DIAGNOSED THAT THE ELECTRONICS ON THE PEDAL FAILED. HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.
THE DAY I BROUGHT THE CAR HOME FROM THE DEALER I DROVE THE CAR TO WORK. PIZZA DELIVERY, DROVE THE CAR FOR APPROXIMATELY 1 HOUR THE CAR WAS IN DRIVE AND SUDDENLY THE CAR ACTED AS IF IT WAS IN NEUTRAL I PRESSED ON THE ACCELERATOR SLIGHTLY AND THE ENGINE REVVED BUT WOULD ONLY ROLL SLIGHTLY. I THEN PUT THE CAR IN PARK TURNED THE CA…
Read full complaint
THE DAY I BROUGHT THE CAR HOME FROM THE DEALER I DROVE THE CAR TO WORK. PIZZA DELIVERY, DROVE THE CAR FOR APPROXIMATELY 1 HOUR THE CAR WAS IN DRIVE AND SUDDENLY THE CAR ACTED AS IF IT WAS IN NEUTRAL I PRESSED ON THE ACCELERATOR SLIGHTLY AND THE ENGINE REVVED BUT WOULD ONLY ROLL SLIGHTLY. I THEN PUT THE CAR IN PARK TURNED THE CAR OFF RESTARTED THE CAR. IT THEN DROVE FINE FOR 15 MIN. SAME ISSUE AGAIN. I AM VERY DISAPPOINTED WITH MY NEW PURCHASE FROM THE DEALER. I ALSO FOUND OUT THAT THEIR ARE RECALLS ON THE CAR AND THE DEALER FAILED TO MENTION THAT. FIRST DAY WITH MY CAR AND I AM WORRIED. *TR
MY CAR CONSTANTLY DOES NOT START. ALSO, WHEN I GO OVER SPEED BUMPS OR HIT POT HOLES MY CAR WILL TURN OFF. *JS
WE BOUGHT OUR 2005 SATURN ION USED SEPT. 4, 2012,(87,812) BEFORE EVEN COULD TAKE OFF LOT THEY HAD TO INSTALL AN IGNITION CYLINDER AND CUT NEW KEY, AND THE THROTTLE WAS STUCK COULD PRESS ALL THE WAY TO FLOOR, AND WOULD ONLY GET UP TO ABOUT 20MPH. THIS WAS ALSO FIXED. (OR SO WE THOUGHT). SINCE OUR PURCHASE, WE STILL HAVE TROUBLE …
Read full complaint
WE BOUGHT OUR 2005 SATURN ION USED SEPT. 4, 2012,(87,812) BEFORE EVEN COULD TAKE OFF LOT THEY HAD TO INSTALL AN IGNITION CYLINDER AND CUT NEW KEY, AND THE THROTTLE WAS STUCK COULD PRESS ALL THE WAY TO FLOOR, AND WOULD ONLY GET UP TO ABOUT 20MPH. THIS WAS ALSO FIXED. (OR SO WE THOUGHT). SINCE OUR PURCHASE, WE STILL HAVE TROUBLE WITH THE KEY GETTING STUCK, IT NOT TURNING OFF WITH CAR STILL RUNNING, OR THE CAR WON'T START, IT HAPPENS SO MUCH THAT OUR DAUGHTER WHO DRIVES IT JUST FIGURES THAT'S THEY WAY IT'S SUPPOSE TO BE, BECAUSE WHEN TAKE BACK TO DEALER EITHER IT WON'T DO IT FOR THEM OR DOESN'T DO IT FOR A MONTH OR SO. NOW THE WARRANTY HAS RAN OUT SO IF IT HAPPENS AGAIN THEY TOLD US WE HAD TO TAKE CARE OF, WELL IT HAPPENED AGAIN TODAY, SHE PARKED WOULD NOT SHUT OFF, CALLED DEALERSHIP, THEY CAN'T DO ANYTHING BECAUSE GM HASN'T GIVEN THEM RECALL YET! WAS IN ACCIDENT ON JAN. 2, 2014 FRONT END AIR BAGS DID NOT DEPLOY! NOT SURE WHY NOT!!! THIS JULY WAS COMING HOME AND DRIVING DOWN ROAD CAR JUST SHUT OFF WHILE DRIVING ABOUT 30MPH AND HAD TO MANUALLY TRY TO GET CAR OFF ROAD WITHOUT HURTING CAR OR ANYONE ELSE'S CAR, AFTER SOMETIME GOT CAR TO START AGAIN AND GOT IT HOME, CALLED DEALERSHIP THEIR RESPONSE IF HAPPENS AGAIN BRING IT IN. AND STILL TO THIS DATE SOMETIMES HER THROTTLE WILL STICK, AS A PARENT I'M HOLDING MY BREATH EVERY TIME SHE LEAVES OUR DRIVE IN THIS VEHICLE. PLEASE HELP SOON. *TR
Official recalls
314V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.