IllustrationTL*THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING ASSIST FAILED WITHOUT WARNING. IT REQUIRED GREAT FORCE FOR THE CONTACT TO TURN THE STEERING WHEEL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 98,000.
2005 Saturn Ion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Saturn Ion do not stand out strongly from the model-year median of 816.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
640–25K
10425–50K
11450–75K
7875–100K
75100–150K
31150K+
466 reports with mileage · 107 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 265 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports4 fire reports13 injury reports
Steering complaints
265 reportsPOWER STEERING ON MY SATURN KEEPS TURNING OFF WHILE CAR IS MOVING. INTERMITTENT PROBLEM. *TR
TL*THE CONTACT OWNS A 2005 SATURN ION 3. THE CONTACT STATED THAT SHE HAS BEEN EXPERIENCING FAILURES WITH THE IGNITION IN HER VEHICLE. DURING COLD TEMPERATURES IN THE WINTER SEASONS, THE KEY WOULD FAIL TO START THE ENGINE. ALL OF THE INTERIOR LIGHTING IN THE VEHICLE WOULD ILLUMINATE; HOWEVER, THE VEHICLE WOULD NOT START AT ALL…
Read full complaint
TL*THE CONTACT OWNS A 2005 SATURN ION 3. THE CONTACT STATED THAT SHE HAS BEEN EXPERIENCING FAILURES WITH THE IGNITION IN HER VEHICLE. DURING COLD TEMPERATURES IN THE WINTER SEASONS, THE KEY WOULD FAIL TO START THE ENGINE. ALL OF THE INTERIOR LIGHTING IN THE VEHICLE WOULD ILLUMINATE; HOWEVER, THE VEHICLE WOULD NOT START AT ALL. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED THAT NUMEROUS CONSUMERS WERE EXPERIENCING THE SAME FAILURE. SHE READ INFORMATION CONCERNING WARMING UP THE STEERING COLUMN IN ORDER TO RESTART THE VEHICLE. THE INFORMATION STATED THAT SHE MUST SOMEHOW HEAT UP THE STEERING COLUMN. THE CONTACT STATED THAT SHORTLY AFTER SHE FOLLOWED THIS ADVICE, THE ENGINE STARTED IN HER VEHICLE. SHE HAS NOT TAKEN THE VEHICLE TO THE DEALER BECAUSE THE VEHICLE IS OUT OF WARRANTY. SHE DOES NOT BELIEVE THAT SHE SHOULD PAY FOR SOMETHING THAT SHE FEELS IS A MANUFACTURER DEFECT. THE FAILURE DID NOT OCCUR IN PREVIOUS WINTERS BECAUSE THE VEHICLE WAS PARKED IN AN INDOOR GARAGE. THE VEHICLE IS CURRENTLY BEING PARKED IN AN OUTSIDE PARKING LOT. THE FAILURE AND CURRENT MILEAGES WERE 18,000. UPDATED 2/23/09 *CN THE CONSUMER ALSO STATED THE KEY WOULD GET STUCK IN THE IGNITION WHEN TRYING TO TURN THE VEHICLE OFF. ALSO THE ANIT-THEFT LIGHT ILLUMINATED AS WELL. UPDATED 02/26/09. *JB
I WAS DRIVING MY 2005 SATURN ION, IT WAS SNOWING HERE IN SEATTLE. THE POWER STEERING WITHOUT ANY WARNING GAVE OUT. I COULD NOT MANEUVER MY CAR AND THE CAR ENDED UP HITTING THE SIDEWALK WITH ALOT OF FORCE AND CAUSING FRONT DAMAGE. WHEN I CONTACTED SATURN THEY STATED THEY WERE AWARE OF THE PROBLEM BUT THEY WERE NOT ISSUING A RECAL…
Read full complaint
I WAS DRIVING MY 2005 SATURN ION, IT WAS SNOWING HERE IN SEATTLE. THE POWER STEERING WITHOUT ANY WARNING GAVE OUT. I COULD NOT MANEUVER MY CAR AND THE CAR ENDED UP HITTING THE SIDEWALK WITH ALOT OF FORCE AND CAUSING FRONT DAMAGE. WHEN I CONTACTED SATURN THEY STATED THEY WERE AWARE OF THE PROBLEM BUT THEY WERE NOT ISSUING A RECALL. *TR
I HAVE A 2005 SATURN ION-3 WITH 87,639 MILES ON IT. LAST WEEK ON THE FREEWAY OUT OF NOW WHERE MY POWER STEERING STOPPED WORKING. THIS PROBLEM CAUSED ME TO SWERVE ALMOST CAUSING AN ACCIDENT. I THEN PULLED OFF TO THE SIDE OF THE ROAD TO RE-GROUP AND TRY TO FIGURE OUT WHAT WENT WRONG. AFTER A FEW MINUTES I STARTED THE CAR AND S…
Read full complaint
I HAVE A 2005 SATURN ION-3 WITH 87,639 MILES ON IT. LAST WEEK ON THE FREEWAY OUT OF NOW WHERE MY POWER STEERING STOPPED WORKING. THIS PROBLEM CAUSED ME TO SWERVE ALMOST CAUSING AN ACCIDENT. I THEN PULLED OFF TO THE SIDE OF THE ROAD TO RE-GROUP AND TRY TO FIGURE OUT WHAT WENT WRONG. AFTER A FEW MINUTES I STARTED THE CAR AND STARTED DRIVING, IT WAS AS IF NOTHING EVER HAPPENED. THIS HAPPENS ALMOST EVERY TIME I DRIVE IT NOW. IT OCCASIONALLY TRIPS THE POWER STEERING LIGHT, SO I TOOK IT TO MY LOCAL SATURN DEALER. THEY SCANNED THE CAR TO CHECK THE PROBLEM AND SAID THAT I NEED TO REPLACE THE ENTIRE STEERING COLUMN DUE TO A FAILED POWER STEERING MODULE. THEY WANT $955.00 PLUS TAX TO ADDRESS THIS ISSUE. I DO NOT FEEL SAFE DRIVING MY CAR. HOWEVER I HAVE NO CHOICE BUT TO DEAL WITH IT FOR I HAVE NO OTHER MEANS OF TRANSPORTATION AND I HAVE TO BE ABLE TO MAKE IT BACK AND FORTH TO WORK TO SUPPORT THE FAMILY. *TR
TL*THE CONTACT OWNS A 2005 SATURN ION. A MONTH AFTER PURCHASING THE VEHICLE, THE POWER STEERING WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ATTEMPTED TO TURN THE STEERING COLUMN, BUT WAS UNSUCCESSFUL. SHE TURNED OFF AND THEN RESTARTED THE VEHICLE AND THE STEERING COLUMN RESUMED WORKING. SHE STATED THAT…
Read full complaint
TL*THE CONTACT OWNS A 2005 SATURN ION. A MONTH AFTER PURCHASING THE VEHICLE, THE POWER STEERING WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ATTEMPTED TO TURN THE STEERING COLUMN, BUT WAS UNSUCCESSFUL. SHE TURNED OFF AND THEN RESTARTED THE VEHICLE AND THE STEERING COLUMN RESUMED WORKING. SHE STATED THAT THE STEERING COLUMN LOCKED ON THREE OCCASIONS WHILE DRIVING. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS AN ELECTRICAL ISSUE AND THEN REPAIRED THE VEHICLE. THE MANUFACTURER STATED THAT THEY WOULD NOT REIMBURSE HER FOR THE COST OF THE REPAIRS. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 12/10/08 *CN THE FOG LAMP WAS CRAXKED. UPDATED 12/16/08.*JB
WHEN I SHUT OFF MY 2005 SATURN ION, THE KEY DOES NOT ALWAYS COME OUT OF THE IGNITION AS IT SHOULD. I HAVE TO WAIT A FEW MINUTES BEFORE THE KEY WILL COME OUT. THIS IS A RECURRING PROBLEM AND HAS BEEN GOING ON FOR OVER A YEAR. I AM ALSO HAVING PROBLEMS WITH MY POWER STEERING. THE PWR STR COMES ON ALL THE TIME. WHEN I SHUT TH…
Read full complaint
WHEN I SHUT OFF MY 2005 SATURN ION, THE KEY DOES NOT ALWAYS COME OUT OF THE IGNITION AS IT SHOULD. I HAVE TO WAIT A FEW MINUTES BEFORE THE KEY WILL COME OUT. THIS IS A RECURRING PROBLEM AND HAS BEEN GOING ON FOR OVER A YEAR. I AM ALSO HAVING PROBLEMS WITH MY POWER STEERING. THE PWR STR COMES ON ALL THE TIME. WHEN I SHUT THE CAR OFF, IT RESETS, BUT AFTER A FEW MINUTES IT COMES BACK ON AGAIN. THIS HAS BEEN HAPPENING FOR THE PAST TWO MONTHS. I TOOK MY CAR TO SATURN OF FAYETTEVILLE (NC) WHEN THE POWER STEERING FIRST STARTED ACTING UP, AND THE MECHANIC SAID HE COULD NOT FIND THE PROBLEM, BUT IF IT KEPT HAPPENING I WOULD HAVE TO HAVE THE STEERING CONSOLE REPLACED. THE ESTIMATED COST OF FIXING IT? OVER $900. *TR
I HAVE 2005 SATURN ION AND WHEN I GO TO TURN THE CAR OFF THE KEY GETS STUCK. THIS PROBLEM CAUSED MORE PROBLEMS WITH THE CAR SO FAR. SATURN IS NOT WILLING TO FIX IT. *TR
2005 SATURN ION 2 - TWO PROBLEMS 1. MOST RECENT - KEY STUCK IN IGNITION AND THE CAR WILL NOT SHUT OFF! TURNED KEY MANY TIMES, TRIED PLIERS AND THE KEY STILL STUCK. BATTERY NOW DISCONNECTED AND RELAY DISCONNECTED. HAVE SEEN OTHER COMPLAINTS OF THIS PROBLEM WITH IONS. 2. STEERING COLUMN - FAULT CODE "PWR STR" COMES UP AND C…
Read full complaint
2005 SATURN ION 2 - TWO PROBLEMS 1. MOST RECENT - KEY STUCK IN IGNITION AND THE CAR WILL NOT SHUT OFF! TURNED KEY MANY TIMES, TRIED PLIERS AND THE KEY STILL STUCK. BATTERY NOW DISCONNECTED AND RELAY DISCONNECTED. HAVE SEEN OTHER COMPLAINTS OF THIS PROBLEM WITH IONS. 2. STEERING COLUMN - FAULT CODE "PWR STR" COMES UP AND CAR LOSES POWER STEERING. WILL RESET IF CAR IS TURNED OFF, BUT WILL DO IT AGAIN WITHIN A COUPLE OF MINUTES. *TR
THE POWER STEERING ON MY 2005 SATURN ION COMPLETELY STOPPED WORKING RIGHT AT ABOUT 37000, RIGHT AFTER THE WARRANTY EXPIRED. I TRIED TO HAVE IT FIXED, BUT IT'S A NEW TECHNOLOGY SATURN IMPLEMENTED, (STATE OF THE ART ELECTRONIC POWER STEERING SYSTEM), AND IT WILL COST $1100 TO FIX IT. MY CAR IS FAIRLY NEW STILL, AND SATURN CORP. R…
Read full complaint
THE POWER STEERING ON MY 2005 SATURN ION COMPLETELY STOPPED WORKING RIGHT AT ABOUT 37000, RIGHT AFTER THE WARRANTY EXPIRED. I TRIED TO HAVE IT FIXED, BUT IT'S A NEW TECHNOLOGY SATURN IMPLEMENTED, (STATE OF THE ART ELECTRONIC POWER STEERING SYSTEM), AND IT WILL COST $1100 TO FIX IT. MY CAR IS FAIRLY NEW STILL, AND SATURN CORP. REFUSES TO MEET WITH ME IN THE MIDDLE ON THE COST. WITHOUT POWER STEERING, MY CAR IS UNSAFE TO DRIVE, AND DRIVING TO WORK AND BACK IS A REAL CHALLENGE, AND A DANGEROUS CHALLENGE, BUT I CANNOT AFFORD THE COST OF FIXING IT. ***SATURN SERVICE ADVISOR ADMITTED TO ME THAT LOTS OF THE IONS ARE HAVING THIS PROBLEM.*** *TR
Official recalls
314V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.