NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
31 reportsClear category filterMileage unknown · May 30, 2014
Electrical SystemExterior LightingSteering
ON MAY 29, 2014 WHEN DRIVING FROM HOME TO WORK ON MY SATURN ION 2005. AT APPROXIMATELY 35 MILES PER HOUR THE ENGINE DID NOT TURN OFF, BUT THE STEERING GOT EXTREMELY HARD THAT I ACTUALLY DROVE ON THE OTHER LANE WITH INCOMING TRAFFIC GOING THE OPPOSITE WAY OF MY DIRECTION. THE DASHBOARD WENT BLANK, MY HEADLIGHTS TURNED OFF MENTION…
Read full complaint
ON MAY 29, 2014 WHEN DRIVING FROM HOME TO WORK ON MY SATURN ION 2005. AT APPROXIMATELY 35 MILES PER HOUR THE ENGINE DID NOT TURN OFF, BUT THE STEERING GOT EXTREMELY HARD THAT I ACTUALLY DROVE ON THE OTHER LANE WITH INCOMING TRAFFIC GOING THE OPPOSITE WAY OF MY DIRECTION. THE DASHBOARD WENT BLANK, MY HEADLIGHTS TURNED OFF MENTIONING THAT IT WAS APPROXIMATELY 0940 NIGHT TIME. *TR
NHTSA ODI #10595011
Mileage unknown · Mar 31, 2014
Electrical SystemEngineExterior Lighting
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WHILE TRAVELING VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE CONTROL ARMS AND BUSHINGS NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE STALLING ISSUE …
Read full complaint
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
NHTSA ODI #10575942
192,000 miles · Mar 30, 2014
Exterior Lighting
A FEW YEARS AGO MY LEFT TURN SIGNAL WENT OUT FOR THE FIRST TIME BUT I JUST REPLACED IT WHICH TOOK A FEW TRYS BEFORE IT ACTUALLY WORKED, OVER THE LAST COUPLE OF YEARS I HAVE HAD MORE PROBLEMS WITH THAT TURN SIGNAL WORKING. EVERYTIME I HAVE TO REPLACE IT, IT IS A HASSLE TRYING TO GET IT TO WORK FOR IT TO ONLY GO OUT AGAIN WITHIN …
Read full complaint
A FEW YEARS AGO MY LEFT TURN SIGNAL WENT OUT FOR THE FIRST TIME BUT I JUST REPLACED IT WHICH TOOK A FEW TRYS BEFORE IT ACTUALLY WORKED, OVER THE LAST COUPLE OF YEARS I HAVE HAD MORE PROBLEMS WITH THAT TURN SIGNAL WORKING. EVERYTIME I HAVE TO REPLACE IT, IT IS A HASSLE TRYING TO GET IT TO WORK FOR IT TO ONLY GO OUT AGAIN WITHIN A WEEK OR TWO. I AM OUT THERE AGAIN TODAY REPLACING THIS THING. I HAVE READ ABOUT RECALLS ON 2004 IONS, HAVE THERE NOT BEEN ANY FOR THIS PROBLEM FOR THE 2005? *TR
NHTSA ODI #10575683
Mileage unknown · Mar 18, 2014
Exterior Lighting
SINCE THE RECALL ON THE SATURN 2005 ION, I'M WONDERING IF THERE EVER WAS A RECALL BECAUSE OF THE LIGHTING SYSTEM IN THE SATURN 2005 ION? I FEEL LIKE I HAD TO HAVE ALLOT OF SERVICES DONE ON THE LIGHTING SYSTEM. ALL OF THIS STARTED AFTER I HAD RESTORATION PERFORMED TO THE HEADLIGHTS - 7/2/12 7/18/12 - RIGHT FRONT DIRECTIONAL SIGN…
Read full complaint
SINCE THE RECALL ON THE SATURN 2005 ION, I'M WONDERING IF THERE EVER WAS A RECALL BECAUSE OF THE LIGHTING SYSTEM IN THE SATURN 2005 ION? I FEEL LIKE I HAD TO HAVE ALLOT OF SERVICES DONE ON THE LIGHTING SYSTEM. ALL OF THIS STARTED AFTER I HAD RESTORATION PERFORMED TO THE HEADLIGHTS - 7/2/12 7/18/12 - RIGHT FRONT DIRECTIONAL SIGNAL OUT 9/4/12 - RIGHT FRONT TURN SIGNAL BURNT REPL SOCKET - BOTH TURN SIGNALS INOP 11/8/12 - LEFT HEADLAMP BULB REPL 11/13/13 - RIGHT BRAKE LAMP REPL. *TR
NHTSA ODI #10573074
60,000 miles · Mar 12, 2014
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
IGNITION SWITCH RECOGNITION BEGAN TO DETERIORATE. WHEN TRYING TO START THE CAR, THE ANTI-THEFT WOULD COME ON. I WOULD HAVE TO WAIT HOURS. THIS WOULD HAPPEN IN COLD AND RAINY WEATHER. KEY WOULD GET LOCKED IN IGNITION WITH ACCESSORIES ON AND NOT GO OFF. BATTERY WOULD DIE. WHEN JUMPING THE CAR THE KEY WOULD STILL BE LOCKED IN T…
Read full complaint
IGNITION SWITCH RECOGNITION BEGAN TO DETERIORATE. WHEN TRYING TO START THE CAR, THE ANTI-THEFT WOULD COME ON. I WOULD HAVE TO WAIT HOURS. THIS WOULD HAPPEN IN COLD AND RAINY WEATHER. KEY WOULD GET LOCKED IN IGNITION WITH ACCESSORIES ON AND NOT GO OFF. BATTERY WOULD DIE. WHEN JUMPING THE CAR THE KEY WOULD STILL BE LOCKED IN THE ON POSITION AND BEGIN TURNING ON AND OFF VIOLENTLY AND RAPIDLY UNTIL KEY WAS ABLE TO BE REMOVED. CAR BLEW FUSE WHILE DRIVING ON HIGHWAY. MAX SPEED REDUCED TO 30 MPH. WHEN TURNING ON KEY WOULD BE 1/2 RECOGNIZED AND LIGHTS/ELECTRIC WOULD FLICKER ON AND OFF VIOLENTLY AND FUSES/COMPUTER HAD TO BE REPLACED/RESET. CAR DID THE LIGHT/ELECTRICAL ISSUE WHILE ON AND DRIVING, KEY WOULD NOT COME OUT OF IGNITION. CAR WAS TOWED BY PALMETTO CHEVY IN CONWAY SC, WHO DESPITE RECALL AND VEHICLE HISTORY REFUSE TO FIX THE CAR OR GIVE LOANER AS STATED ON WEBSITE. I HAVE BEEN CALLING SINCE 2008 ABOUT THE ISSUE. GM SAYS TAKE IT TO A DEALERSHIP BUT I HAVE TO PAY FOR ISSUES. CAR HAS BEEN TOWED ON TUESDAY 3/11/14 TO PALMETTO CHEVY, AFTER THEY TOLD ME THEY WOULD PICK IT UP BUT WERE A NO SHOW ON MONDAY 3/10/14. AGAIN, THEY REFUSE TO DO THE RECALL. STATING THEY FIND NOTHING WRONG WITH THE IGNITION. *TR
NHTSA ODI #10568880
Mileage unknown · Feb 26, 2014
Exterior LightingSteering
ONE DAY I WAS DRIVING AND HAVE BEEN NOTICING THAT THE STEERING WHEEL WAS STARTING TO GET HARDER AND HARDER WHEN TURNING. I FEAR THIS BECAUSE IN NOT THAT STRONG AND FEAR I MIGHT CRASHED AND HURT MY THREE KIDS. THE STEERING COOLANT LIGHT COMES ON AND THAT MAKE ME WONDER ABOUT THAT TOO, WHEN I TURN I HAVE TO BE IN STRONG MODE OR I …
Read full complaint
ONE DAY I WAS DRIVING AND HAVE BEEN NOTICING THAT THE STEERING WHEEL WAS STARTING TO GET HARDER AND HARDER WHEN TURNING. I FEAR THIS BECAUSE IN NOT THAT STRONG AND FEAR I MIGHT CRASHED AND HURT MY THREE KIDS. THE STEERING COOLANT LIGHT COMES ON AND THAT MAKE ME WONDER ABOUT THAT TOO, WHEN I TURN I HAVE TO BE IN STRONG MODE OR I MIGHT BE IN AN ACCIDENT. CAN GM PLEASE FIX THIS PROBLEM. *TR
NHTSA ODI #10565967
54,000 miles · Nov 25, 2013
Exterior Lighting
MY RIGHT TURN SIGNAL FLASHES FAST AND WILL NOT WORK. I CHANGED THE BULB THE SAME PROBLEM NOBODY SEEM TO KNOW WHAT TO DO ABOUT THIS , FROM THE AMOUNT OF COMPLAINTS I THINK G M NEED TO FIX THIS PROBLEM. *TR
NHTSA ODI #10553712
99,000 miles · Apr 22, 2013
Exterior Lighting
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE FRONT TURN SIGNALS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED, WHICH LOCATED THE FAILURE AT THE BODY CONTROL MODULE. THE DEALER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V547000 (EXTERIOR LIGHTING). THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE FRONT TURN SIGNALS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED, WHICH LOCATED THE FAILURE AT THE BODY CONTROL MODULE. THE DEALER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V547000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 99,000 AND THE CURRENT MILEAGE WAS 111,000.
NHTSA ODI #10509154
Mileage unknown · Apr 25, 2012
Exterior Lighting
DRIVER SIDE DIRECTIONAL STOPPED WORKING. CHANGED BULB STILL DID NOT WORK. TOOK TO SATURN DEALER SAID THEY HAD TO ORDER A PART FOR $185 TO FIX THE PROBLEM. FIND THAT THE 2003 & 2004 IONS WERE RECALLED FOR THE SAME PROBLEM BUT NOT THE 2005. BELIEVE THE 2005 WAS MANUFACTURED IN 2004 SO SHOULD HAVE THE SAME PARTS AS THE 2004. W…
Read full complaint
DRIVER SIDE DIRECTIONAL STOPPED WORKING. CHANGED BULB STILL DID NOT WORK. TOOK TO SATURN DEALER SAID THEY HAD TO ORDER A PART FOR $185 TO FIX THE PROBLEM. FIND THAT THE 2003 & 2004 IONS WERE RECALLED FOR THE SAME PROBLEM BUT NOT THE 2005. BELIEVE THE 2005 WAS MANUFACTURED IN 2004 SO SHOULD HAVE THE SAME PARTS AS THE 2004. WHY WAS THE 2005 NOT RECALLED ALSO IF IT HAS THE SAME PROBLEM. *TR
NHTSA ODI #10456454
Mileage unknown · Feb 16, 2012
Electrical SystemExterior Lighting
THE CAR HAS ISSUES WITH LIGHTING MALFUNCTION. MY PASSENGER SIDE RUNNING LIGHT/TURN SIGNAL REQUIRED MANY BULB CHANGES, EVERY FEW WEEKS OR SO, SINCE THE SOCKET OVERHEATED AND ACCORDINGLY RECEIVED A SIGNAL FROM THE BODY MODULE TO SHUT OFF. THIS SEEMS LIKE THE SAME PROBLEM THAT LED TO A RECALL WITH THE 2003 AND 2004 IONS. I RECENTL…
Read full complaint
THE CAR HAS ISSUES WITH LIGHTING MALFUNCTION. MY PASSENGER SIDE RUNNING LIGHT/TURN SIGNAL REQUIRED MANY BULB CHANGES, EVERY FEW WEEKS OR SO, SINCE THE SOCKET OVERHEATED AND ACCORDINGLY RECEIVED A SIGNAL FROM THE BODY MODULE TO SHUT OFF. THIS SEEMS LIKE THE SAME PROBLEM THAT LED TO A RECALL WITH THE 2003 AND 2004 IONS. I RECENTLY WAS FINALLY ABLE TO GET THIS SAFETY-RELATED ASPECT OF THE VEHICLE REMEDIED, FOR A FEW HUNDRED DOLLARS. *TR
NHTSA ODI #10448252
Official recalls
3Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration