NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
34 reportsClear category filterMileage unknown · Apr 5, 2023
Air Bags
Hello I am reaching out to complain about Courtesy Chevrolet - San Diego. I’ve been trying to get my car serviced in order to fIx the recalls. Unfortunately I have not been successful. I called the dealer to make an appointment but the dealer told me that the car has been discontinued and they can’t find the parts. The suggested…
Read full complaint
Hello I am reaching out to complain about Courtesy Chevrolet - San Diego. I’ve been trying to get my car serviced in order to fIx the recalls. Unfortunately I have not been successful. I called the dealer to make an appointment but the dealer told me that the car has been discontinued and they can’t find the parts. The suggested to call somewhere else.
NHTSA ODI #11515552
175,000 miles · Nov 17, 2020
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. DURING THE CRASH THE PASSENGER SIDE OF THE VEHICLE WAS SEVERELY DAMAGED BUT NO AIR BAGS HAD DEPLOYED. THE DRIVER SUSTAINED AN INJURED NECK AND WAS TRANSPORTED TO THE…
Read full complaint
TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. DURING THE CRASH THE PASSENGER SIDE OF THE VEHICLE WAS SEVERELY DAMAGED BUT NO AIR BAGS HAD DEPLOYED. THE DRIVER SUSTAINED AN INJURED NECK AND WAS TRANSPORTED TO THE HOSIPITAL. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED AWAY. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 174,000.
NHTSA ODI #11374991
35,000 miles · Oct 26, 2015
Air BagsVehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING 10 MPH AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A BUILDING AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING 10 MPH AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A BUILDING AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.
NHTSA ODI #10786097
110,000 miles · May 6, 2015
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2005 SATURN ION. WHILE DRIVING AT 50 MPH, THE VEHICLE CRASHED INTO THE GUARD RAIL. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE W…
Read full complaint
TL* THE CONTACT OWNED A 2005 SATURN ION. WHILE DRIVING AT 50 MPH, THE VEHICLE CRASHED INTO THE GUARD RAIL. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10714956
105,000 miles · Mar 17, 2015
Air BagsVehicle Speed Control
AFTER OWNING THIS CAR FOR A FEW YEARS NOW AND BECOMING HIGHLY INVOLVED IN THE FORUMS. I'VE LEARNED THAT IT'S A COMMON ISSUE FOR THE CLOCK SPRING TO BREAK. WHEN IT DOES, IT CUTS POWER PERMANENTLY TO THE DRIVER AIR BAG, AND CRUISE CONTROL UNTIL REPAIRED. THIS IS A BIG SAFETY CONCERN AS NO POWER TO THE AIRBAG WOULD RESULT IN MORE S…
Read full complaint
AFTER OWNING THIS CAR FOR A FEW YEARS NOW AND BECOMING HIGHLY INVOLVED IN THE FORUMS. I'VE LEARNED THAT IT'S A COMMON ISSUE FOR THE CLOCK SPRING TO BREAK. WHEN IT DOES, IT CUTS POWER PERMANENTLY TO THE DRIVER AIR BAG, AND CRUISE CONTROL UNTIL REPAIRED. THIS IS A BIG SAFETY CONCERN AS NO POWER TO THE AIRBAG WOULD RESULT IN MORE SERIOUS INJURY OR POSSIBLY DEATH. *TR
NHTSA ODI #10694742
135,000 miles · Jan 7, 2015
Air BagsSeat BeltsSteeringCrash
I WAS DRIVING MY CAR AND A DEER RAN OUT IN FRONT OF ME, I WAS ABLE TO MISS THAT ONE BUT ANOTHER ONE CAME OUT AND I HIT IT. IT HIT SO HARD AND MY STEERING WAS HARD LIKE A CAR WITHOUT POWER STEERING AND THE BRAKES WERE LIKE THAT TOO. THE AIRBAGS DID NOT DEPLOY NOR DID THE SAFETY BELTS CATCH ME AND MY GRANDDAUGHTER. IT DID $3500.00…
Read full complaint
I WAS DRIVING MY CAR AND A DEER RAN OUT IN FRONT OF ME, I WAS ABLE TO MISS THAT ONE BUT ANOTHER ONE CAME OUT AND I HIT IT. IT HIT SO HARD AND MY STEERING WAS HARD LIKE A CAR WITHOUT POWER STEERING AND THE BRAKES WERE LIKE THAT TOO. THE AIRBAGS DID NOT DEPLOY NOR DID THE SAFETY BELTS CATCH ME AND MY GRANDDAUGHTER. IT DID $3500.00 WORTH OF DAMAGE TO MY CAR AND MY HEAD SLAMMED UP AGAINST THE DRIVER WINDOW, MY GRANDDAUGHTER WAS IN HER CARSEAT BUT I HAD IT IN THE FRONT SEAT SO IT RELEASED THE CARSEAT. SHE HAD BRUISES AND A BLACK EYE, AND NOW 3 YEARS LATER, THAT SAME EYE IS CAUSING HER PROBLEMS SEEING. EVERYDAY I FEEL SO BAD BECAUSE SHE WAS IN MY SATURN THAT NIGHT. PEOPLE ASKED ME OVER AND OVER WHAT ABOUT YOUR AIRBAGS, ETC. I NEVER KNEW WHAT TO SAY UNTIL I STARTED GETTING THE RECALLS AND REALIZED WHAT GM HAD KNOWN ALL ALONG ABOUT MY IGNITION. THIS YEAR MY CAR GOT STUCK IN THE RUN POSITION AND I CALLED THE DEALERSHIP AND WAS TOLD THEY WERE GONE FOR THE DAY. I UNHOOKED THE BATTERY CABLES AND THE CAR STILL WOULD NOT TURN OFF. FINALLY AFTER TOTAL DISGUST, ALL OF A SUDDEN THE ANTIFREEZE OVERFLOW TANK LID POPPED OFF AND SHOT ANTIFREEZE EVERYWHERE, IT JUST BARELY MISSED MY GRANDDAUGHTER AND MYSELF. THE DEALERSHIP COYLE CHEVROLET OF CLARSKVILLE IN CAME AND PICKED UP THE CAR, AND IN THE PROCESS RIPPED THE WIND SHIELD FOR THE SUNROOF OFF, AND CALLED ME TO TELL ME MY CAR NOW HAD A NOISE IN THE LOWER END OF THE ENGINE AND IT WOULD BE $600.00 AND UP. THEY TEST DROVE IT, AND TOLD ME THERE WAS NO ANTIFREEZE IN IT. I HAD ALREADY TOLD THEM WHAT HAPPENED. GM AND COYLE BOTH SAY SORRY THE IGNITION IS THE ORIGINAL REASON FOR THE ENGINE THAT IS NOW LOCKED UP AFTER I WAS TOLD I HAD TO COME GET IT OR I WOULD BE CHARGED A STORAGE FEE LOCKED UP ON ME ON THE EXPRESSWAY HOME. THAT WAS IN SEPTEMBER AND I STILL HAVE NOTHING AND THEY WON'T HELP. *TR
NHTSA ODI #10670847
Mileage unknown · Sep 10, 2014
Air BagsElectrical SystemCrash
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL. *SMD THE PART WAS NOT AVAILABLE TO COMPLETE THE RECALL. ALSO, THE CONSUMER WAS INVOLVED IN AN ACCIDENT, AND THE AIR BAG DID NOT DEPLOY. *JB
NHTSA ODI #10632841
90,000 miles · Aug 23, 2014
Air BagsService BrakesSteeringCrash
MY SON WAS DRIVING AND THE TRUCK IN FRONT OF HIM STOPPED SUDDENLY. HE HIT THE BRAKES AND FELT THE STEERING LOCK UP, BRAKES LOCKED AND HE COULDN'T STOP. HIT THE TRUCK HARD ENOUGH TO CRACK THE CORE SUPPORT IN THE SATURN BUT THE AIR BAG DO NOT EXPAND. HE WAS NOT INJURED BUT THIS IS DEFINITELY A SAFETY ISSUE IF YOU CAN HIT ANOTHE…
Read full complaint
MY SON WAS DRIVING AND THE TRUCK IN FRONT OF HIM STOPPED SUDDENLY. HE HIT THE BRAKES AND FELT THE STEERING LOCK UP, BRAKES LOCKED AND HE COULDN'T STOP. HIT THE TRUCK HARD ENOUGH TO CRACK THE CORE SUPPORT IN THE SATURN BUT THE AIR BAG DO NOT EXPAND. HE WAS NOT INJURED BUT THIS IS DEFINITELY A SAFETY ISSUE IF YOU CAN HIT ANOTHER CAR ENOUGH TO CRACK THE STEEL FRAME BUT NO AIRBAG WAS DEPLOYED. *TR
NHTSA ODI #10627670
Mileage unknown · Jul 7, 2014
Air BagsElectrical System
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE THEFT REMOTE FOR EACH KEY. *SMD THE DEALER INFORMED THE CONSUMER, THEY WOULD NOT REPLACE THE SECOND REMOTE FOR FREE, BECAUSE IT WAS NOT A PART OF THE RECALL.
NHTSA ODI #10607341
Mileage unknown · Jun 25, 2014
Air BagsElectrical System
2005 SATURN ION. CONSUMER WRITES IN REGARDS TO THE IGNITION SWITCH RECALL AND SEEKS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED AFTER THE RECALL WAS PERFORMED, THE SHIFTER HAD TO BE REPLACED, BECAUSE THE CONSUMER WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH. *JB
NHTSA ODI #10605274
Official recalls
3Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration