← New search

2004 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2004 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

713 reports with mileage · 185 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 345 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

51 crash reports4 fire reports29 injury reports

Steering complaints

345 reports
Clear category filter
21,000 miles · Jun 21, 2008
Steering

MY MOTHER OWNS A 2004 SATURN ION. SHE COMPLAINED THAT THE POWER STEERING WENT OUT ON HER A COUPLE OF TIMES AND THAT SHE TOOK IT TO THE DEALER. THEY DIDN'T SEE ANYTHING WRONG. I DROVE THE CAR FROM VIRGINIA TO NEW JERSEY AND THE POWER STEERING WENT OUT APPROX EVERY 50 MILES. WHEN I TURNED THE CAR OFF AND BACK ON IT WAS FINE FOR A…

Read full complaint

MY MOTHER OWNS A 2004 SATURN ION. SHE COMPLAINED THAT THE POWER STEERING WENT OUT ON HER A COUPLE OF TIMES AND THAT SHE TOOK IT TO THE DEALER. THEY DIDN'T SEE ANYTHING WRONG. I DROVE THE CAR FROM VIRGINIA TO NEW JERSEY AND THE POWER STEERING WENT OUT APPROX EVERY 50 MILES. WHEN I TURNED THE CAR OFF AND BACK ON IT WAS FINE FOR ANOTHER 50 MILES OR LESS. WE CALLED THE DEALER - THEY ASKED IF WE WERE MAKING A LOT OF TURNS - WE WEREN'T. IT WAS A STRAIGHT DRIVE DOWN 95. WHEN WE RETURNED HOME, THE CAR WAS AGAIN TAKEN TO THE DEALER . BECAUSE MY MOM HAD AN AUTOMATIC STARTER PUT IN, THEY SAID IT WAS THE WAY THE 3RD PARTY HOOKED IT UP THAT WAS INTERFERING WITH THE STEERING. THEY SAID THE FIXED THE PROBLEM. 2 WEEKS LATER THE POWER STEERING WENT OUT AGAIN. *TR

NHTSA ODI #10231929

40,000 miles · Apr 24, 2008
Steering

FAILURE OF THE ELECTRIC POWER STEERING SYSTEM: I HAVE OWNED MY 2004 SATURN ION SINCE NEW AND IT HAS APPROXIMATELY 52,000 MILES ON IT. I NOTICED ABOUT 2 MONTHS AGO, THE POWER STEERING SYSTEM WILL TURN OFF RANDOMLY. IT STARTED TO HAPPEN VERY INFREQUENTLY, LESS THAN ONCE A DAY. NOW IT HAPPENS MANY TIMES IN ONE TRIP. IF I TUR…

Read full complaint

FAILURE OF THE ELECTRIC POWER STEERING SYSTEM: I HAVE OWNED MY 2004 SATURN ION SINCE NEW AND IT HAS APPROXIMATELY 52,000 MILES ON IT. I NOTICED ABOUT 2 MONTHS AGO, THE POWER STEERING SYSTEM WILL TURN OFF RANDOMLY. IT STARTED TO HAPPEN VERY INFREQUENTLY, LESS THAN ONCE A DAY. NOW IT HAPPENS MANY TIMES IN ONE TRIP. IF I TURN THE IGNITION OFF AND RESTART THE CAR, IT WILL WORK AGAIN, NOTWITHSTANDING ANOTHER FAILURE. THE DEALER HAS QUOTED ME 700 DOLLARS TO DO THE REPAIR WORK. CONSIDERING THE CAR ONLY HAS 52,000 MILES ON IT AND MANY OTHERS HAVE EXPERIENCED THIS SAME PROBLEM ON THE ION AND OTHER SATURN MODELS (FROM SEARCHES OF VARIOUS SATURN FORUMS), I FIND THIS TO BE UNCONSCIONABLE THAT SATURN WILL NOT RECALL THE ITEM. THIS COULD CAUSE A MAJOR PROBLEM FOR AN UNSUSPECTING PERSON IF IT TURNS OFF IN THE MIDDLE OF A CORNERING TURN. THE FORCES REQUIRED TO TURN THE WHEELS AND THE FAILED STEERING ASSIST MOTOR ARE MORE THAN EXPECTED. *TR

NHTSA ODI #10225620

45,000 miles · Mar 22, 2008
Steering

SINCE 45,000 MILES THE CARS POWER STEERING WILL STOP WHEN DRIVING AND WHEN THE CAR IS TURNED OFF AND BACK ON AGAIN THE STEERING WILL WORK FOR A FEW MILES. TROUBLE CODE C0475 MEANS TO REPLACE THE STEERING COLUMN ACCORDING TO THE TSB. CAR HAS 67,000 MILES AND I REFUSE TO PAY $1000 FOR A POORLY DESIGNED GM PART JUST ASK THEY CHEVY…

Read full complaint

SINCE 45,000 MILES THE CARS POWER STEERING WILL STOP WHEN DRIVING AND WHEN THE CAR IS TURNED OFF AND BACK ON AGAIN THE STEERING WILL WORK FOR A FEW MILES. TROUBLE CODE C0475 MEANS TO REPLACE THE STEERING COLUMN ACCORDING TO THE TSB. CAR HAS 67,000 MILES AND I REFUSE TO PAY $1000 FOR A POORLY DESIGNED GM PART JUST ASK THEY CHEVY MALIBU OWNERS THEY ARE SUFFERING FROM THE SAME PROBLEM. *TR

NHTSA ODI #10222011

Mileage unknown · Jan 10, 2008
Steering

POWER STEERING TURNS OFF WHILE DRIVING. COMES BACK ON IF CAR IS TURNED OFF AND RESTARTED. DEALERSHIP CHARGING @ $920.00 TO REPLACE STEERING COLUMN. NUMEROUS REPORTS ONLINE OF SAME ISSUE. *TR

NHTSA ODI #10214428

53,500 miles · Jan 2, 2008
Steering

WHILE DRIVING ON THE HIGHWAY, THE POWER STEERING LIGHT WOULD COME ON AND I COULD BARELY STEER THE VEHICLE AND I HAD TO GET OFF THE HIGHWAY IMMEDIATELY. AFTER I PULLED OFF THE HIGHWAY, I WOULD TURN THE VEHICLE OFF AND THEN TURN IT BACK ON AND I WOULD PROCEED TO MY DESTINATION.*CN

NHTSA ODI #10213446

65,120 miles · Dec 10, 2007
Steering

MY 16 YEAR OLD DAUGHTER WAS DRIVING WHEN ALL OF A SUDDEN THE POWER STEERING WENT OUT. SHE HAD TO PULL OVER BECAUSE SHE COULD NOT TURN THE STEERING WHEEL. THIS IS A SERIOUS SAFETY PROBLEM AND SHOULD BE ADDRESSES IMMEDIATELY BY THE MANUFACTURER. *TR

NHTSA ODI #10211388

76,780 miles · Nov 14, 2007
Steering

INTERMITTENTLY POWER STEERING WARNING LIGHT WOULD APPEAR ON DASH AND POWER STEERING WOULD STOP WORKING. THIS HAPPENED ONCE ONE DAY AND TWICE THE SECOND DAY WHEN I CALLED FOR AN APPOINTMENT WITH THE SERVICE DEPARTMENT OF THE DEALER. THE CAR IS 4 YEARS OLD AND IS NO LONGER UNDER WARRANTY. THE DEALER REPLACED THE ELECTRIC POWER STE…

Read full complaint

INTERMITTENTLY POWER STEERING WARNING LIGHT WOULD APPEAR ON DASH AND POWER STEERING WOULD STOP WORKING. THIS HAPPENED ONCE ONE DAY AND TWICE THE SECOND DAY WHEN I CALLED FOR AN APPOINTMENT WITH THE SERVICE DEPARTMENT OF THE DEALER. THE CAR IS 4 YEARS OLD AND IS NO LONGER UNDER WARRANTY. THE DEALER REPLACED THE ELECTRIC POWER STEERING ASSEMBLY AT A COST OF APPROXIMATELY $1200. WHEN I WAS TOLD THAT THIS JUST "SOMETIMES HAPPENS" BY THE DEALERSHIP, I COULD NOT UNDERSTAND WHY IT WAS NOT CONSIDERED A SERIOUS DEFECT AND RECALLED. I DECIDED TO LOOK ON THE INTERNET AND FOUND THAT IT HAPPENS TO SATURN IONS AS WELL AS OTHER GENERAL MOTORS VEHICLES. IN MY OPINION, A 4 YEAR OLD CAR SHOULD NOT JUST SUDDENLY LOSE POWER STEERING. THIS COULD HAVE RESULTED IN TRAGEDY. SUPPOSE A DRIVER HAS TO SWERVE TO AVOID AN OBSTACLE AND THE POWER STEERING FAILS AT THAT MOMENT. THIS IS SOMETHING WHICH I BELIEVE GM IS AWARE OF AND IS CHOOSING NOT TO WARN PEOPLE ABOUT. I INTEND TO MAKE MY VOICE HEARD IN AS MANY FORUMS AS POSSIBLE. THIS IS A VERY SERIOUS PROBLEM AND I SINCERELY HOPE IT CAN BE ADDRESSED BEFORE EVEN ONE PERSON LOSES THEIR LIFE. *TR

NHTSA ODI #10208953

43,300 miles · Aug 9, 2007
Steering

POWER STEERING FAILED ON MY 2004 SATURN ION WHILE THE CAR WAS IN MOTION ON A WINDING STREET. I WAS ABLE TO MAINTAIN CONTROL BUT A PERSON OF LESSER STRENGTH WOULD LIKELY HAVE CRASHED AS THE STEERING WAS EXTREMELY STIFF. TOOK CAR TO DEALERSHIP AND THE WHOLE STEERING ASSEMBLY REQUIRED REPLACEMENT AT A COST OF $1,079 PLUS #111 FOR…

Read full complaint

POWER STEERING FAILED ON MY 2004 SATURN ION WHILE THE CAR WAS IN MOTION ON A WINDING STREET. I WAS ABLE TO MAINTAIN CONTROL BUT A PERSON OF LESSER STRENGTH WOULD LIKELY HAVE CRASHED AS THE STEERING WAS EXTREMELY STIFF. TOOK CAR TO DEALERSHIP AND THE WHOLE STEERING ASSEMBLY REQUIRED REPLACEMENT AT A COST OF $1,079 PLUS #111 FOR A 2 DAY CAR RENTAL. THE AUTO WAS JUST OUT OF THE WARRANTY PERIOD. DEALER KEPT OLD PARTS. *TR

NHTSA ODI #10199026

45,326 miles · May 22, 2007
Service Brakes, HydraulicSteeringCrashInjury

TL*THE CONTACT OWNS A 2004 SATURN ION 2. WHILE DRIVING 25 MPH, THE CONTACT ATTEMPTED TO TURN THE WHEEL AND IT LOCKED. THE BRAKES FAILED AND THE VEHICLE CRASHED INTO A POLE. THE AIR BAG DEPLOYED, BUT THE DRIVER WAS INJURED. SATURN STATED THAT THE VEHICLE IS NOT A DEFECT. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MI…

Read full complaint

TL*THE CONTACT OWNS A 2004 SATURN ION 2. WHILE DRIVING 25 MPH, THE CONTACT ATTEMPTED TO TURN THE WHEEL AND IT LOCKED. THE BRAKES FAILED AND THE VEHICLE CRASHED INTO A POLE. THE AIR BAG DEPLOYED, BUT THE DRIVER WAS INJURED. SATURN STATED THAT THE VEHICLE IS NOT A DEFECT. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE 45,326.

NHTSA ODI #10191451

49,000 miles · Feb 11, 2007
Steering

MY 2004 SATURN ION LEVEL 2 WILL NOT START WHEN THE TEMPERATURE IS COLD. IT DOES NOT HAPPEN EVERY TIME BUT WITHIN THE LAST 4 DAYS IT HAS HAPPENED 6 TIMES. IT IS THE PASSLOCK SECURITY SYSTEM THAT WILL NOT ALLOW FUEL TO GO TO THE ENGINE WHEN THE CAR DOES NOT SEND THE CORRECT MESSAGE TO THE BODY CONTROL MODULE. I HAVE TO WAIT 8-20 …

Read full complaint

MY 2004 SATURN ION LEVEL 2 WILL NOT START WHEN THE TEMPERATURE IS COLD. IT DOES NOT HAPPEN EVERY TIME BUT WITHIN THE LAST 4 DAYS IT HAS HAPPENED 6 TIMES. IT IS THE PASSLOCK SECURITY SYSTEM THAT WILL NOT ALLOW FUEL TO GO TO THE ENGINE WHEN THE CAR DOES NOT SEND THE CORRECT MESSAGE TO THE BODY CONTROL MODULE. I HAVE TO WAIT 8-20 MINUTES FOR THE CARS SECURITY SYSTEM TO RESET. HOPEFULLY, IT WILL START AFTER THAT TIME PERIOD. THIS PROBLEM IS NOT BEING ACKNOWLEDGE BY SATURN BECAUSE THIS IS NOT A NATIONWIDE PROBLEM. IT HAPPENS IN THE COLDER REGIONS OF AMERICA BECAUSE OF THE IGNITION SWITCH. I HAVE BEEN LATE SEVERAL TIMES TO WORK BECAUSE OF THIS PROBLEM. I HAVE NOT GONE TO HAVE THIS PROBLEM FIXED BECAUSE I HAVE READ THAT IT RECURS EVEN AFTER PARTS AND THE IGNITION SWITCH HAS BEEN REPLACED. MANY PEOPLE HAVE BEEN AFFECTED BY THIS BECAUSE OF THE COLDER TEMPERATURES THAT HAVE COME ACROSS AMERICA. THIS PROBLEM DOESN'T ONLY EFFECT 04 IONS BUT ALSO 03 AND 05. SATURN HAS CHANGED THE DESIGN OF THE SYSTEM IN NEWER MODELS WHICH IS A SIGN THAT IT IS A PROBLEM. I HAVE ALSO HEARD THAT THIS PROBLEM IS HAPPENING IN MANY GM MODELS. THIS SHOULD BE LOOKED INTO TO PROTECT CONSUMERS. FINALLY, THIS PROBLEM HAS BEEN OCCURRING SINCE OCTOBER OF 2006 FOR MY CAR AND IT HAS HAPPENED OVER 30 TIMES. *NM

NHTSA ODI #10182261

Official recalls

8

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

04V547000 · Exterior Lighting:turn Signal

Nov 16, 2004

CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.

Consequence & remedy

Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

04V281000 · Fuel System, Other:delivery:fuel Pump

Jun 8, 2004

CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

04V002000 · Structure:body:bumpers

Jan 6, 2004

ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.

Consequence & remedy

Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.

Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.

04V003000 · Fuel System, Gasoline

Jan 5, 2004

CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.

Consequence & remedy

Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

04V004000 · Visibility:power Window Devices And Controls

Jan 5, 2004

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.

Consequence & remedy

Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.

Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

EA04035 · Front Turn Signal/drl Failure

Opened Dec 22, 2004 · Closed Oct 20, 2005

Status: closed (inferred from source dates) · Exterior Lighting:turn Signal

THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.

PE04061 · Front Turn Signal/drl Failure

Opened Aug 17, 2004 · Closed Dec 22, 2004

Status: closed (inferred from source dates) · Exterior Lighting:turn Signal

ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.