NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
23 reportsClear category filterMileage unknown · May 15, 2017
EngineSteering
VIN: [XXX] , SALESPERSON:[XXX] DATE OF PURCHASE: MARCH 27, 2017 , DEALERS NUMBER: 47243...$2000 IN REPAIRS PAID IN CASH.PURCHASE VEHICLE IN CASH FOR $3000.FALSE ADVERTISEMENT THAT THE VEHICLE WAS IN GOOD CONDITION@TIME OF PURCHASE&SEVERAL DEFECTIVE& MALFUNCTIONING PARTS&I WAS SOLD A LEMON CAR THAT HAS BEEN RECALLED SEVERAL TIMES…
Read full complaint
VIN: [XXX] , SALESPERSON:[XXX] DATE OF PURCHASE: MARCH 27, 2017 , DEALERS NUMBER: 47243...$2000 IN REPAIRS PAID IN CASH.PURCHASE VEHICLE IN CASH FOR $3000.FALSE ADVERTISEMENT THAT THE VEHICLE WAS IN GOOD CONDITION@TIME OF PURCHASE&SEVERAL DEFECTIVE& MALFUNCTIONING PARTS&I WAS SOLD A LEMON CAR THAT HAS BEEN RECALLED SEVERAL TIMES. SEAT BELTS DON'T WORK.WIND SHIELD WIPERS WERE BROKE@ TIME OF PURCHASE. MUFFLER PROBLEMS, RATTLES TOO..EMERGENCY BRAKE WAS NO GOOD&FIXED.BRAKE FAULTY,I PURCHASED NEW BRAKE PADS.TRANSMISSION IS FAULTY.CAR CONTINUOUSLY SHAKES.IT'S BEEN IN AND OUT OF SHOP SINCE I PURCHASED IT. TRANSMISSION ACCELERATION&GEAR SHIFT DOES NOT WORK PROPERLY OR SHIFT IN TIME. WINDOW IS OFF THE TRAP&WILL BRAKE IF I PUT IT ALL THE WAY DOWN..GAS LEAK. GAS LEAK=$30 A DAY SINCE PURCHASE. IGNITION LOCKS THE STEERING WHEEL&WON'T TURN WHILE DRIVING. KEY WILL NOT TURN.CAR WILL NOT START&NEEDS A NEW IGNITION. THE POWER STEERING WENT OUT WITH/IN 2WEEKS OF BUYING IT. I WAS ON THE ROAD&THE WHEEL LOCKED. I WAS BARELY ABLE TO TURN IT WITH ALL MY STRENGTH. I HAD TO REPLACE IT& IT'S AN ELECTRIC POWER STEERING WHEEL. BRAKE FLUID WAS SOLD DIRTY. OVERHEATING CONSTANTLY. FAN OVER RUNNING.TIMING BELT NEEDS CHECKED. BRAKES ARE SQUEAKING& SQUEALING&WHEN PUMPED SHOOT AIR, BRAKE PADS WERE CHANGED& BRAKE FLUID WAS CHANGED& IS CLEAR INSTEAD OF BLACK. ALL THESE PROBLEMS EXISTED@TIME OF PURCHASE.IT WAS SOLD AS IS.I'VE LOST TIME FROM WORK. I DID NOT KNOW IT'S BEEN RECALLED SEVERAL TIMES. GM &DEALER IS@FAULT. IT IS A LEMON. PUTS MY FAMILIES LIFE IN DANGER, ESPECIALLY WHEN THE WHEEL LOCKS UP ON THE ROAD.DEALER GAVE ME A DUMMY KEY. THAT'S ANOTHER PROBLEM. I HAVE RIGHTS UNDER THE SONG-BEVERLY WARRANTY RIGHTS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10985885
190,710 miles · Aug 24, 2016
Electrical SystemEngineVisibility/wiper
WAS GUARANTEED THAT NOTHING WAS WRONG WITH IT. I ORIGINALLY GOT A 2007 FORD ESCAPE BY TRADING IN MY VEHICLE AND 500 CASH. THEY WANTED ME TO PUT DOWN AN ADDITIONAL 900 DOWN WHICH I ENDED UP NOT BEING ABLE TO DO. SO THEY OFFERED TO PUT ME IN ANOTHER VEHICLE THAT WAS CHEAPER AND I WOULD NOT HAVE TO PUT ANY MORE MONEY ON. THE 2004 S…
Read full complaint
WAS GUARANTEED THAT NOTHING WAS WRONG WITH IT. I ORIGINALLY GOT A 2007 FORD ESCAPE BY TRADING IN MY VEHICLE AND 500 CASH. THEY WANTED ME TO PUT DOWN AN ADDITIONAL 900 DOWN WHICH I ENDED UP NOT BEING ABLE TO DO. SO THEY OFFERED TO PUT ME IN ANOTHER VEHICLE THAT WAS CHEAPER AND I WOULD NOT HAVE TO PUT ANY MORE MONEY ON. THE 2004 SATURN ION I RECEIVED ON 08/23/2016 NOT ONLY HAD CLUTCH ISSUES WHICH I SAID I WOULD FIX, BUT THE BATTERY LIGHT KEPT COMING ON AND THEY ASSURED ME THAT NOTHING WAS WRONG WITH THE CAR MECHANICALLY. WE DID NOT EVEN MAKE IT DOWN THE ROAD BEFORE THE VEHICLE BROKE DOWN AND HAD TO HAVE IT TOWED. SO NOW THE CAR SITS IN MY YARD AND I AM OUT MY ORIGINAL VEHICLE AND THE 500 CASH I USED ORIGINALLY PLUS TOWING CHARGES AND A VEHICLE I HAVE TO PAY ON THAT I CANNOT DRIVE. I WANT THEM TO COME GET THE CAR AND GIVE BACK THE 500 I WASTED ON TWO JUNK VEHICLES. I ALSO HAD ISSUES WITH THE 2007 FORD ESCAPE. I WAS PRETTY MUCH STUCK TAKING THIS VEHICLE SINCE I LIVE TWO HOURS AWAY AND HAD NO OTHER WAY HOME.
NHTSA ODI #10898150
Mileage unknown · Nov 24, 2015
Air BagsElectrical SystemEngine
CAR WENT FOR RECALL 7/7/14 ABOUT 3 TIMES AFTER THE FIRST RECALL I CONTACT GENERAL MOTOR TO ASK WHAT HAVE HAPPEND WHY TYHE CAR NEED TO GO BACK IN AGAIN FOR THE SECOND RECALL CHEVROLET SAYD THAT THEY DID NOT PERFOM THE JOB RIGHT ONCE AGAIN I CONTACT GENERAL MOTOR IN DECEBER THEY SEND ME A LETTER TELLING ME AND COMES BACK WI…
Read full complaint
CAR WENT FOR RECALL 7/7/14 ABOUT 3 TIMES AFTER THE FIRST RECALL I CONTACT GENERAL MOTOR TO ASK WHAT HAVE HAPPEND WHY TYHE CAR NEED TO GO BACK IN AGAIN FOR THE SECOND RECALL CHEVROLET SAYD THAT THEY DID NOT PERFOM THE JOB RIGHT ONCE AGAIN I CONTACT GENERAL MOTOR IN DECEBER THEY SEND ME A LETTER TELLING ME AND COMES BACK WITH THE SAME PROBLEMS DRIVING THE CAR IN THE FREEWAY CAR STOP COULD NOT GET OUT BECAUSE CAR LOCK ME INSIDE THE KEY DID NOT WANT TO COME OUT AFTER THE RECALLS THE CAR STILL HAVE PROBLEMS WITH THE IGNITION
NHTSA ODI #10806571
180,000 miles · Jun 1, 2015
Electrical SystemEngine
WHILE DRIVING HOME FROM WORK MY CAR DIED IN THE MIDDLE OF AN INTERSECTION. THE A/C WENT OFF FIRST THEN EVERYTHING WENT OFF. I PUT CAR IN PARK AND AFTER SEVERAL TRIES THE CAR STARTED AGAIN. MY IGNITION ALSO GETS STUCK IN THE ACC POSITION(EVEN AFTER TWO IGNITION RECALLS) ON A REGULAR BASIS SO GLAD I WASN'T FIGHTING THAT AT THAT PR…
Read full complaint
WHILE DRIVING HOME FROM WORK MY CAR DIED IN THE MIDDLE OF AN INTERSECTION. THE A/C WENT OFF FIRST THEN EVERYTHING WENT OFF. I PUT CAR IN PARK AND AFTER SEVERAL TRIES THE CAR STARTED AGAIN. MY IGNITION ALSO GETS STUCK IN THE ACC POSITION(EVEN AFTER TWO IGNITION RECALLS) ON A REGULAR BASIS SO GLAD I WASN'T FIGHTING THAT AT THAT PROBLEM AT THE SAME TIME. CALLED GM DEALER THEY SAID THERE IS NO RECALL BUT BRING IT IN, THEY WON'T PROVIDE A LOANER CAR BUT WILL GIVE ME A RIDE HOME BECAUSE I LIVE WITHIN 10 MILES.
NHTSA ODI #10722683
100,000 miles · Mar 22, 2015
EngineService Brakes
THE SATURN ION RECALLED IGNITION WAS REPLACED, BUT THE PROBLEM CONTINUES TO HAPPEN. ON 3/20/15, I WAS DRIVING ON THE FREEWAY IN RUSH HOUR TRAFFIC. THE CAR TURNED ITSELF OFF, AND THE BRAKES WENT OUT. I STEERED THE CAR TO THE SHOULDER, AND MANAGED TO BRING IT A STOP EVENTUALLY WITH THE EMERGENCY BRAKE AND CHANGING GEARS. I TOOK TH…
Read full complaint
THE SATURN ION RECALLED IGNITION WAS REPLACED, BUT THE PROBLEM CONTINUES TO HAPPEN. ON 3/20/15, I WAS DRIVING ON THE FREEWAY IN RUSH HOUR TRAFFIC. THE CAR TURNED ITSELF OFF, AND THE BRAKES WENT OUT. I STEERED THE CAR TO THE SHOULDER, AND MANAGED TO BRING IT A STOP EVENTUALLY WITH THE EMERGENCY BRAKE AND CHANGING GEARS. I TOOK THE CAR STRAIGHT TO THE DEALERSHIP, PER INSTRUCTIONS FROM GM CUSTOMER SERVICE, BUT HAVEN'T BEEN ABLE TO GET SATISFACTORY INFORMATION FROM EITHER THE SERVICE CENTER AT THE DEALERSHIP OR GM CUSTOMER SERVICE SO FAR. THE NEW IGNITION FAILED, CAUSING THE CAR TO TURN OFF WHILE DRIVING AND MY BRAKES TO FAIL. THIS CAUSED A SERIOUS SAFETY RISK. THE RECALL FAILED TO CORRECT THE IGNITION PROBLEM FOR MY VEHICLE. *TR
NHTSA ODI #10700923
151,000 miles · Jan 13, 2015
Electrical SystemEngine
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.
NHTSA ODI #10672147
133,000 miles · Jul 9, 2014
Electrical SystemEngine
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE NHTSA CAMPAIGN ID NUMBER: 14E021000 (IGNITION SWITCH). THE CONTACT STATED THE REPAIR DID NOT REMEDY THE FAILURE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE MANUFACTURER …
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE NHTSA CAMPAIGN ID NUMBER: 14E021000 (IGNITION SWITCH). THE CONTACT STATED THE REPAIR DID NOT REMEDY THE FAILURE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
NHTSA ODI #10609205
115,000 miles · Jun 5, 2014
EngineVehicle Speed Control
TURNED VEHICLE ON AFTER SITTING FOR ABOUT 8 HOURS IN PARKING LOT, THE CAR REVVED UP TO ABOUT 4,000RPM WHICH IS UNUSUALLY HIGH. I WAITED FOR THE CAR TO CALM DOWN AND WHEN IT DID, I PUT THE CAR INTO GEAR TO DRIVE. MY CAR LUNGED FORWARD AND WITHOUT PUSHING THE GAS PEDAL, MY CAR ACCELERATED AND EVENTUALLY MADE IT TO 40MPG THROUGH …
Read full complaint
TURNED VEHICLE ON AFTER SITTING FOR ABOUT 8 HOURS IN PARKING LOT, THE CAR REVVED UP TO ABOUT 4,000RPM WHICH IS UNUSUALLY HIGH. I WAITED FOR THE CAR TO CALM DOWN AND WHEN IT DID, I PUT THE CAR INTO GEAR TO DRIVE. MY CAR LUNGED FORWARD AND WITHOUT PUSHING THE GAS PEDAL, MY CAR ACCELERATED AND EVENTUALLY MADE IT TO 40MPG THROUGH THE PARKING LOT BEFORE I HAD TO HIT MY BRAKE TO AVOID A COLLISION. THIS AS OCCURRED INTERMITTENTLY OVER THE PAST YEAR; APPROXIMATELY 3 OR 4 TIMES A MONTH. *TR
NHTSA ODI #10596406
111,000 miles · May 10, 2014
Electrical SystemEngine
DRIVING ON THE FLORIDA TURNPIKE NORTHBOUND ON MY WAY TO WORK ON MAY 6, 2014, GOING ABOUT 55 MPH, WHEN THE CAR TURNED OFF WHILE IN THE CENTER LANE. I HAD FOLLOWED ALL THE PROCEDURES THAT GM INSTRUCTED FOR RECALL #14V-047 USING THE KEY WITHOUT RING OUR ADDITIONAL KEYS. I HAVE BEEN DEALING WITH THIS ISSUE SINCE THE DAY OF PURCHASE …
Read full complaint
DRIVING ON THE FLORIDA TURNPIKE NORTHBOUND ON MY WAY TO WORK ON MAY 6, 2014, GOING ABOUT 55 MPH, WHEN THE CAR TURNED OFF WHILE IN THE CENTER LANE. I HAD FOLLOWED ALL THE PROCEDURES THAT GM INSTRUCTED FOR RECALL #14V-047 USING THE KEY WITHOUT RING OUR ADDITIONAL KEYS. I HAVE BEEN DEALING WITH THIS ISSUE SINCE THE DAY OF PURCHASE BACK IN 2007. I HAVE PRESENTED THIS ISSUE TO THE DEALER NUMEROUS TIMES. FORTUNATELY, I WAS ABLE TO STOP THE CAR SAFELY, REMOVE THE KEY, PLACED IT BACK IN THE IGNITION AND THE CAR STARTED.
NHTSA ODI #10587589
82,000 miles · May 7, 2014
Engine
I HAVE TAKEN THIS CAR IN SEVERAL TIMES FOR THE SAME REASON... IDLE STICKS THEN IT SHUTS DOWN COMPLETELY OR IT WILL JUST CUT OFF WHILE I'M DRIVING IT. THE SATURN REPAIR SHOP COULDN'T FIND ANYTHING WRONG. I PAID FOR THIS 3 TIMES AND GAVE UP. I'VE ALSO HAD MY IGNITION REPAIRED ALREADY SO THIS RECALL DOES ME NO GOOD. I'VE ALREADY…
Read full complaint
I HAVE TAKEN THIS CAR IN SEVERAL TIMES FOR THE SAME REASON... IDLE STICKS THEN IT SHUTS DOWN COMPLETELY OR IT WILL JUST CUT OFF WHILE I'M DRIVING IT. THE SATURN REPAIR SHOP COULDN'T FIND ANYTHING WRONG. I PAID FOR THIS 3 TIMES AND GAVE UP. I'VE ALSO HAD MY IGNITION REPAIRED ALREADY SO THIS RECALL DOES ME NO GOOD. I'VE ALREADY PAID FOR IT. NOW MY TIMING CHAIN BROKE AND I HAVE A CRACKED SEAL IN MY ENGINE. THERE WAS A RECALL FOR THIS TOO BUT THE YEAR OF MY CAR WAS NOT INCLUDED IN THAT RECALL.... I SPOKE WITH GM AND THEY'RE TELLING ME THAT MY 100,000 MILE OR 10 YR WARR. STOPPED NOVEMBER 2013. I BOUGHT THIS MAY, 2004 SO I THINK 10 YEARS WOULD BE MAY OF 2014. IS THERE ANYWAY TO GET MY MONEY BACK AND THEM PAY FOR THE TIMING CHAIN? SIGNED: ANGRY CONSUMER. *TR
NHTSA ODI #10587070
Official recalls
8Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jun 8, 2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 6, 2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence & remedy
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration