NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
331 reportsClear category filter87,000 miles · Apr 24, 2014
Air BagsElectrical SystemCrash
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE ENTERING A PARKING LOT AT 3 MPH, THE VEHICLE SUDDENLY STALLED AND THE CONTACT CRASHED INTO A CEMENT PILLAR. THERE WERE NO INJURIES. THE VEHICLE WAS TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) BUT WAS INFORMED THAT THE PAR…
Read full complaint
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
NHTSA ODI #10584682
65,000 miles · Apr 24, 2014
Electrical SystemSteering
I WAS DRIVING ON DRY ROADS DURING THE DAYTIME BELOW THE SPEED LIMIT, WHEN THE POWER STEERING LIGHT CAME ON. THE WHEEL LOCKED, AND I WAS UNABLE TO STEER THE CAR. I PULLED TO THE SIDE OF THE ROAD AND TURNED THE CAR OFF AND BACK ON. IT RESTARTED WITHOUT INCIDENT. 3 YEARS LATER, THE SAME EVENT OCCURRED WITHOUT CAUSING AN ACCIDENT. …
Read full complaint
I WAS DRIVING ON DRY ROADS DURING THE DAYTIME BELOW THE SPEED LIMIT, WHEN THE POWER STEERING LIGHT CAME ON. THE WHEEL LOCKED, AND I WAS UNABLE TO STEER THE CAR. I PULLED TO THE SIDE OF THE ROAD AND TURNED THE CAR OFF AND BACK ON. IT RESTARTED WITHOUT INCIDENT. 3 YEARS LATER, THE SAME EVENT OCCURRED WITHOUT CAUSING AN ACCIDENT. *TR
NHTSA ODI #10584592
Mileage unknown · Apr 23, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBERS: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AND14V171000 (ELECTRICAL SYSTEM) BUT WAS ADVISED BY THE DEALER THAT THE PART NEEDED TO COMPLETE THE REPAIR WAS NOT AVAILABLE. THE CONTACT RECEIVED TWO SEPARATE RECALL NOTICES AND HAD ST…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBERS: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AND14V171000 (ELECTRICAL SYSTEM) BUT WAS ADVISED BY THE DEALER THAT THE PART NEEDED TO COMPLETE THE REPAIR WAS NOT AVAILABLE. THE CONTACT RECEIVED TWO SEPARATE RECALL NOTICES AND HAD STILL BEEN WAITING FOR THE RECALL REPAIRS. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE A REASONABLE TIME FRAME FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10584491
Mileage unknown · Apr 17, 2014
Air BagsElectrical SystemSteeringCrashInjury
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES, AIR BAG MALFUNCTION AND SEVERAL OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED HER DAUGHTER WAS INVOLVED IN 3 ACCIDENTS. HER DAUGHTER LOST POWER AND THE VEHICLE STALLED. WHEN HER DAUGHTER HIT THE OTHER VEHICLE, THE AIR BAGS DID NOT DEPLOY. …
Read full complaint
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES, AIR BAG MALFUNCTION AND SEVERAL OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED HER DAUGHTER WAS INVOLVED IN 3 ACCIDENTS. HER DAUGHTER LOST POWER AND THE VEHICLE STALLED. WHEN HER DAUGHTER HIT THE OTHER VEHICLE, THE AIR BAGS DID NOT DEPLOY. HER DAUGHTER WAS INJURED. ALSO, THE CONSUMER HAD DIFFICULTY STEERING THE VEHICLE. *JB
NHTSA ODI #10582779
38,996 miles · Apr 16, 2014
Electrical System
CAR WILL NOT START BECAUSE THE IGNITION WILL NOT READ THE KEY. IT TAKES 15 MINUTES JUST WAITING, WITH THE KEY OUT, THEN WHEN TRYING AGAIN IT DOES READ THE KEY AND THE CAR STARTS. THIS IS NOT THE FIRST TIME AS IT HAS BEEN GOING ON FOR THE LAST EIGHT (8) YEARS FOR ME WITH HUNDREDS OF OTHERS WITH THE SAME PROBLEM! I HAVE TAKEN …
Read full complaint
CAR WILL NOT START BECAUSE THE IGNITION WILL NOT READ THE KEY. IT TAKES 15 MINUTES JUST WAITING, WITH THE KEY OUT, THEN WHEN TRYING AGAIN IT DOES READ THE KEY AND THE CAR STARTS. THIS IS NOT THE FIRST TIME AS IT HAS BEEN GOING ON FOR THE LAST EIGHT (8) YEARS FOR ME WITH HUNDREDS OF OTHERS WITH THE SAME PROBLEM! I HAVE TAKEN THE CAR TO DEALERSHIPS AND GARAGE WORKERS. EACH PLACE SAYS THE CAR IS FINE, NOTHING WRONG. IT SEEMS THAT GM KNEW SOMETHING WAS WRONG SINCE 2003 AND GM LATER TOLD DEALERSHIPS SO DEALERSHIPS KNEW AND NO ONE DID ANYTHING. WELL, GM HAS FINALLY MADE THE STATEMENT THAT SOMETHING IS WRONG WITH THE IGNITION SYSTEM AND KEYS - FINALLY. ONE BIG QUESTION IS WHY DID IT TAKE SO LONG FROM NHTSA TOO! NHTSA IS TO MAKE SURE PEOPLE ARE SAFE BUT YOU HAVE BEEN VERY "LATE" TOO. I BLAME BOTH GM AND NHTSA THAT IT HAS TAKEN TOO LONG. GM CAN BE FINED BECAUSE OF BEING LATE CORRECTING THE ERRORS. CAN NHTSA BE FINED FOR THE SAME REASON - LATE MAKING A COMPANY CORRECTING ERRORS! IT SEEMS THAT NO ONE WOULD LESSON TO THE DRIVERS AND/OR OWNERS WITH THE SAME PROBLEMS - NOT GM AND NOT NHTSA. YOU ARE ASKING GM WHY IT HAS TAKEN SO LONG. CAN YOU LET US KNOW WHY NHTSA WAS LATE TOO?
NHTSA ODI #10583021
Mileage unknown · Apr 10, 2014
Air BagsElectrical System
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO FAULTY IGNITION PROBLEMS. *SMD THE CONSUMER STATED HE EXPERIENCED NUMEROUS PROBLEMS WITH THE IGNITION, IN THE 3 YEARS HE HAS OWNED THE VEHICLE. ON SEVERAL OCCASIONS, THE VEHICLE WOULD NOT START. THE DEALER WOULD ALWAYS CLAIM, THERE WAS NOTHING WRONG WITH THE PASSLOCK SYSTEM. *JB
NHTSA ODI #10578703
Mileage unknown · Apr 8, 2014
Air BagsElectrical System
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WOULD NOT START. THE PROBLEM HAS BEEN GOING ON FOR YEARS. ACCORDING TO THE LATEST INVOICE, THE TECHNICIAN FOUND THE KEY BINDING IN THE HOUSING. THE IGNITION CYLINDER WAS REPLACED. THE BATTERY WAS REPLACED…
Read full complaint
2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WOULD NOT START. THE PROBLEM HAS BEEN GOING ON FOR YEARS. ACCORDING TO THE LATEST INVOICE, THE TECHNICIAN FOUND THE KEY BINDING IN THE HOUSING. THE IGNITION CYLINDER WAS REPLACED. THE BATTERY WAS REPLACED 3 TIMES. *JB
NHTSA ODI #10577668
103,328 miles · Apr 1, 2014
Electrical System
IN DEC. 2011, THE CAR WOULD NOT TURN ON AND I PAID $280 FOR A REPLACEMENT IGNITION SWITCH. I HAVE NO IDEA IF THEY USED ANOTHER FAULTY SWITCH THAT IS NOW THE SUBJECT OF THE CURRENT RECALL. IN CONCERN FOR MY SAFETY, I AM USING A SINGLE KEY, AS GM INSTRUCTED, AND WAITING FOR THE DEALER TO GET THE PART TO REPLACE THE IGNITION SWIT…
Read full complaint
IN DEC. 2011, THE CAR WOULD NOT TURN ON AND I PAID $280 FOR A REPLACEMENT IGNITION SWITCH. I HAVE NO IDEA IF THEY USED ANOTHER FAULTY SWITCH THAT IS NOW THE SUBJECT OF THE CURRENT RECALL. IN CONCERN FOR MY SAFETY, I AM USING A SINGLE KEY, AS GM INSTRUCTED, AND WAITING FOR THE DEALER TO GET THE PART TO REPLACE THE IGNITION SWITCH. SUPPOSEDLY, IT WILL HAPPEN THIS MONTH - APRIL. ALSO IN 2011 (OR MAYBE THE BEGINNING OF 2012) I EXPERIENCED THE INTERMITTENT LOSS OF THE POWER STEERING. THAT WAS PAID FOR BY GM BUT, AGAIN, NOW I HAVE NO IDEA IF THEY PUT IN ANOTHER FAULTY POWER STEERING COLUMN THAT IS THE SUBJECT OF TODAY'S RECALL. WHEN I CALLED GM TODAY, THEY SAID THAT LAST POWER STEERING REPLACEMENT WAS NOT A RECALL, IT WAS A SPECIAL SAFETY ISSUE #10187. I ASKED IF THE INCENTIVE TO TRADE IN THE CAR WOULD BE EXTENDED DUE TO ANOTHER RECALL AND THEY COULD NOT ANSWER THE QUESTION BECAUSE THAT IS A SALES ISSUE, NOT A REPAIR ISSUE. I THINK IT'S TIME TO REPLACE THIS CAR, MAYBE WITH A FORD! *TR
NHTSA ODI #10576286
48,000 miles · Mar 31, 2014
Electrical System
MY CAR STARTED NOT STARTING UP AT ALL. IT WOULD TAKE ABOUT 20 MINUTES TO START MY CAR AND THE IGNITION WOULD BE HARD TO TURN, AND A JUMP WOULD NOT WORK. I WOULD HAVE TO GO OUT AND START MY CAR 30 MINUTES BEFORE I HAD TO LEAVE FOR WORK AND LET IT RUN. I TOOK MY CAR TO A MECHANIC TO CHANGE MY OIL AND IT WOULD NOT START. THEY TRIED…
Read full complaint
MY CAR STARTED NOT STARTING UP AT ALL. IT WOULD TAKE ABOUT 20 MINUTES TO START MY CAR AND THE IGNITION WOULD BE HARD TO TURN, AND A JUMP WOULD NOT WORK. I WOULD HAVE TO GO OUT AND START MY CAR 30 MINUTES BEFORE I HAD TO LEAVE FOR WORK AND LET IT RUN. I TOOK MY CAR TO A MECHANIC TO CHANGE MY OIL AND IT WOULD NOT START. THEY TRIED TO GIVE ME A JUMP AND I TOLD THEM THAT DO NOT WORK AND EXPLAIN WHAT IT DOES ALL THE TIME AND THE OWNER CHECK HIS COMPUTER UNDER THE SAFETY RECALLS AND HE TOLD ME THAT IT WAS A RECALL ON MY IGNITION, SO I TOOK MY CAR TO A SATURN DEALER "THIS WAS IN 2010" AND I TOLD THEM WHAT WAS TOLD TO ME AND THEY TOLD ME THAT THERE WAS NOT ANY RECALLS FOR MY CAR. I WROTE A LETTER ABOUT THIS ISSUE AND NEVER GOT A RESPONSE. NOW IN 2013 MY CAR CUT OFF WHILE DRIVING DOWN THE STREET FOR NO REASON. I WAS JUST GOING TO GET MY IGNITION FIXED WHEN I GOT THIS LETTER ABOUT THE RECALL. THIS CAR WAS GIVEN TO MY SON FOR A GRADUATION PRESENT AND I WOULD LIKE IT TO BE FIXED SOON. *TR
NHTSA ODI #10576047
182,560 miles · Mar 24, 2014
Electrical System
THEY KEY GETS STUCK IN THE IGNITION AND SOMETIMES I CANT PUT THE KEY IN THE IGNITION. MANY TIMES IF I CAN GET THE KEY IN AND TRY TO START IT THEN IT DOES NOTHING. I HAD THE CAR TOWED HOME AND THAT IS WHERE IT IS STILL SITTING IN MY DRIVEWAY UNABLE TO START?? I WOULD LIKE TO KNOW WHERE TO TAKE MY CAR FOR THE RECALL REPAIRS, IS T…
Read full complaint
THEY KEY GETS STUCK IN THE IGNITION AND SOMETIMES I CANT PUT THE KEY IN THE IGNITION. MANY TIMES IF I CAN GET THE KEY IN AND TRY TO START IT THEN IT DOES NOTHING. I HAD THE CAR TOWED HOME AND THAT IS WHERE IT IS STILL SITTING IN MY DRIVEWAY UNABLE TO START?? I WOULD LIKE TO KNOW WHERE TO TAKE MY CAR FOR THE RECALL REPAIRS, IS TOWING ALSO INCLUDED I DON'T HAVE THE MONEY TO KEEP PAYING TO HAVE THE CAR TOWED. *TR
NHTSA ODI #10574594
Official recalls
8Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jun 8, 2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 6, 2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence & remedy
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration