IllustrationCAR WILL NOT START WHEN IT IS COLD OUTSIDE. THE CAR USES THE GM PASSLOCK SYSTEM. OFTEN AFTER SEVERAL INSTANCES OF WAITING 10 MINUTES, AND TRYING AGAIN, THE CAR WILL START. *TR
2004 Saturn Ion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Saturn Ion do not stand out strongly from the model-year median of 816.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1040–25K
12725–50K
14850–75K
12775–100K
151100–150K
56150K+
713 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 345 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports4 fire reports29 injury reports
Electrical System complaints
331 reportsWONT START DUE TO PASSLOCK/IGNITION PROBLEMS IN COLD WEATHER. HAVE NOT REPLACED ANY PARTS YET AS FUNDS ARE LIMITED. *TR
BOUGHT THE CAR UNDER WARRANTY, NO CRANK/NO START BECAUSE OF FAULTY PASSLOCK SYSTEM. SATURN "REBOOTED THE COMPUTER" (SATURNS WORDS). THIS WAS IN MAY OF 06. STRANGELY, THE CAR HAS "DIED" IN AT LEAST 3 DRIVEWAYS AS THOUGH THE BATTERY WAS DEAD. I HAVE TAKEN THE CAR TO A GARAGE AND HAD THE BATTERY TESTED AND IT WAS FINE. RECENT…
Read full complaint
BOUGHT THE CAR UNDER WARRANTY, NO CRANK/NO START BECAUSE OF FAULTY PASSLOCK SYSTEM. SATURN "REBOOTED THE COMPUTER" (SATURNS WORDS). THIS WAS IN MAY OF 06. STRANGELY, THE CAR HAS "DIED" IN AT LEAST 3 DRIVEWAYS AS THOUGH THE BATTERY WAS DEAD. I HAVE TAKEN THE CAR TO A GARAGE AND HAD THE BATTERY TESTED AND IT WAS FINE. RECENTLY, WHEN THE WEATHER IS COLD, THE CAR WILL NO CRANK/NO START AND THROW THE PASSLOCK CODE. ON THE DASH, SOMETIMES IT SAYS SERVICE ENGINE IT MAY OR MAY NOT RESET AFTER 10 MINUTES. THE VEHICLE HAS BECOME UNRELIABLE AS I AM NEVER SURE IF I AM GOING TO GET TO WORK ON TIME OR NOT. I CALLED SATURN LAST WEEK. APPARENTLY SATURN IS AWARE OF THE PROBLEM, BUT SINCE THEY ARE GOING TO INCONVENIENCE ME TO DRIVE 200 MILES TO THE DEALERSHIP AND THEN CHARGE ME $100 TO WALK THROUGH THE DOOR LAND THEN ANOTHER $1000 ON TOP OF THAT TO "FIX" THE CAR' THEY KNOW THEY ARE MAKING MONEY OFF THEIR FAULTY EQUIPMENT. I REFUSE TO PAY FOR IT, BUT IN THE MEANTIME MY CAR CONTINUES TO NOT START IF IT IS ZERO DEGREES. *TR
MY 2004 SATURN ION WILL NOT START WHEN IT IS COLD. THIS FIRST HAPPENED LAST YEAR, AND I THOUGHT THAT THE GAS LINES WERE FREEZING. I HAVE PUT SEVERAL BOTTLES OF DRY GAS IN MY TANK THINKING THAT THIS RESOLVES THE PROBLEM. APPARENTLY IT IS A PASSLOCK SECURITY ISSUE AND MY EFFORTS OF DRY GAS DID NOTHING. I HAVE BEEN STRANDED COU…
Read full complaint
MY 2004 SATURN ION WILL NOT START WHEN IT IS COLD. THIS FIRST HAPPENED LAST YEAR, AND I THOUGHT THAT THE GAS LINES WERE FREEZING. I HAVE PUT SEVERAL BOTTLES OF DRY GAS IN MY TANK THINKING THAT THIS RESOLVES THE PROBLEM. APPARENTLY IT IS A PASSLOCK SECURITY ISSUE AND MY EFFORTS OF DRY GAS DID NOTHING. I HAVE BEEN STRANDED COUNTLESS TIMES DUE TO THE ERROR. THIS PROBLEMS RENDERS THE CAR USELESS. THE MOST RECENT OCCURRENCE WAS YESTERDAY, BUT THIS HAPPENS WAY TOO OFTEN. *TR
AFTER OWNING MY 2004 SATURN ION FOR 8 MONTHS, IT DEVELOPED A RANDOM STARTING PROBLEM. SOMETIMES THE CAR WOULD START NORMALLY AND OTHERS NOT AT ALL. I REPLACED THE BATTERY, STARTER, AND IGNITION SWITCH. THE DEALERSHIP WHERE I BOUGHT THE IGNITION SWITCH SAID IT IS COMMON TO NEED TO REPLACE THE SWITCH WHEN THE WEATHER GETS COLD.…
Read full complaint
AFTER OWNING MY 2004 SATURN ION FOR 8 MONTHS, IT DEVELOPED A RANDOM STARTING PROBLEM. SOMETIMES THE CAR WOULD START NORMALLY AND OTHERS NOT AT ALL. I REPLACED THE BATTERY, STARTER, AND IGNITION SWITCH. THE DEALERSHIP WHERE I BOUGHT THE IGNITION SWITCH SAID IT IS COMMON TO NEED TO REPLACE THE SWITCH WHEN THE WEATHER GETS COLD. AFTER ALL OF THOSE NEW PARTS THE PROBLEM PERSISTED. I RESEARCHED ON THE INTERNET AND FOUND A FORUM WHERE DOZENS OF OTHER ION OWNERS WHERE HAVING SIMILAR PROBLEMS. THE ONLY REMEDY THAT SEEMED TO "FIX" THE PROBLEM WAS TO DISABLE THE VEHICLES ANTI-THEFT SYSTEM BY CUTTING THE PROPER WIRE FROM THE IGNITION SWITCH WHILE THE CAR IS RUNNING. THIS ALLOWS THE CAR TO START EVERY TIME, BUT ALSO GIVES AN ERROR MESSAGE ABOUT THE DISABLED SYSTEM. THIS IS CLEARLY A COMMON PROBLEM THAT OCCURS FOR ION OWNERS IN COLD WEATHER. *TR
DURING THE COLDER DAYS MY PASSLOCK SYSTEM DENY MY CAR TO START. I OR MY WIFE WILL HAVE TO SIT IN THE CAR FOR 10 MINUTES TO BE ABLE TO TRY IT AGAIN. IF IT DOESN'T START ATE THE 10 MINUTE MARK WE HAVE TO WAIT ANOTHER 10 MINUTES. WE HAVE WAITED A 1/2 AN HOUR FOR IT TO START BEFORE. I HAVE NO TRUST IT WILL START AT ANY POINT. W…
Read full complaint
DURING THE COLDER DAYS MY PASSLOCK SYSTEM DENY MY CAR TO START. I OR MY WIFE WILL HAVE TO SIT IN THE CAR FOR 10 MINUTES TO BE ABLE TO TRY IT AGAIN. IF IT DOESN'T START ATE THE 10 MINUTE MARK WE HAVE TO WAIT ANOTHER 10 MINUTES. WE HAVE WAITED A 1/2 AN HOUR FOR IT TO START BEFORE. I HAVE NO TRUST IT WILL START AT ANY POINT. WE NEED TO WAIT THE 10 MINUTES NEARLY EVERYTIME FROM END OF NOV TO FEB. *TR
I OWN A 2004 SATURN ION. IT DOES NOT START IN THE COLD WEATHER (AROUND 36 DEGREES F AND BELOW). I HAVE REPLACED THE STARTER AND TWO MONTHS AGO I BOUGHT A NEW BATTERY. MY MECHANIC ASSURED ME THE BATTERY IS TOP OF THE LINE AND GUARANTEED TO START IN COLD WEATHER. HOWEVER, IT DID NOT START YESTERDAY IN 30 DEGREE WEATHER. ALL LIGHTS…
Read full complaint
I OWN A 2004 SATURN ION. IT DOES NOT START IN THE COLD WEATHER (AROUND 36 DEGREES F AND BELOW). I HAVE REPLACED THE STARTER AND TWO MONTHS AGO I BOUGHT A NEW BATTERY. MY MECHANIC ASSURED ME THE BATTERY IS TOP OF THE LINE AND GUARANTEED TO START IN COLD WEATHER. HOWEVER, IT DID NOT START YESTERDAY IN 30 DEGREE WEATHER. ALL LIGHTS TURN ON BUT CAR DOES NOT CRANK. DOES NOT EVEN MAKE NOISE. I HAVE RESEARCHED THIS THROUGH VARIOUS DISCUSSION BOARDS AND MOST OF THEM AGREE THAT THERE IS A FAULTY SWITCH IN THE IGNITION THAT LEAKS LUBRICANT. WHEN THE LUBRICANT FREEZES, THE PASSLOCK ANTI THEFT ALARM DOES NOT GET IT'S ELECTRICAL SIGNAL SO IT ACTIVATES AND PROHIBITS FUEL FROM BEING USED SO THE CAR DOES NOT START. I TAKE VERY GOOD CARE OF MY CAR, BUT I HAVE SPENT A LOT OF TIME AND MONEY TRYING TO FIGURE OUT WHAT IS WRONG IN THIS SITUATION. IF THIS IS THE CASE OF A FAULTY SWITCH, SATURN / GM SHOULD BE HELD LIABLE AND FORCED TO DO A RECALL WITH AN UPDATED SWITCH DESIGN. FOR THE AMOUNT THAT CARS COST TODAY MANUFACTURERS SHOULD NOT BE ALLOWED TO PUT OUT JUNK PARTS AND EXPECT CONSUMERS TO SIT BACK AND TAKE IT. *TR
I HAVE A 2004 SATURN ION WHICH THIS MORNING WOULD NOT START AFTER I LEFT A CONVENIENCE STORE. IT WAS A LITTLE HESITANT IN STARTING ABOUT A WEEK AGO. BOTH TIMES WERE EXTREMELY COLD COMPARED TO NORMAL THIS TIME OF YEAR. THIS MORNING I FIGURED IT WAS A BATTERY PROBLEM. WELL AFTER SOME INTERNET RESEARCH IT WOULD SEEM THAT THESE VEHI…
Read full complaint
I HAVE A 2004 SATURN ION WHICH THIS MORNING WOULD NOT START AFTER I LEFT A CONVENIENCE STORE. IT WAS A LITTLE HESITANT IN STARTING ABOUT A WEEK AGO. BOTH TIMES WERE EXTREMELY COLD COMPARED TO NORMAL THIS TIME OF YEAR. THIS MORNING I FIGURED IT WAS A BATTERY PROBLEM. WELL AFTER SOME INTERNET RESEARCH IT WOULD SEEM THAT THESE VEHICLES HAVE PROBLEMS STARTING IN THE COLD AND EVERYONE ELSE'S DESCRIPTION ONLINE DESCRIBES WHAT HAPPENED ME TO ME PERFECTLY. WOULDN'T START, WALKED THE MILE HOME, CALLED FOR A TOW TRUCK, GOT BACK, STARTED RIGHT UP WITH NOT PROBLEMS. *TR
MY SATURN 2004 ION HAS BEEN BREAKING DOWN SINCE I PURCHASED IT USED IN 2005. THEY HAVE PUT IN 2-3 TRANSMISSIONS AND EVERYTIME IT IS COLD IT WON'T START. A COUPLE TIMES THE WOULD START BUT NOT SHIFT INTO GEAR! THE TECH'S COULD NOT FIGURE OUT WHAT WAS WRONG SO MY DAD (WHO DOES NOT WORK ON CARS ) FIGURED OUT IT WAS A LOOSE WIRE! …
Read full complaint
MY SATURN 2004 ION HAS BEEN BREAKING DOWN SINCE I PURCHASED IT USED IN 2005. THEY HAVE PUT IN 2-3 TRANSMISSIONS AND EVERYTIME IT IS COLD IT WON'T START. A COUPLE TIMES THE WOULD START BUT NOT SHIFT INTO GEAR! THE TECH'S COULD NOT FIGURE OUT WHAT WAS WRONG SO MY DAD (WHO DOES NOT WORK ON CARS ) FIGURED OUT IT WAS A LOOSE WIRE! THEY HAVE REPLACED THE STABILIZER BAR BUSHINGS AT LEAST 3 TIMES! THE CARS HEAT AND RADIO WOULD JUST SHUT OFF AND TURN BACK ON THEY ALSO FIXED THAT A COUPLE TIMES. MY CAR WILL BE PAID OFF SHORTLY BUT I WILL NOT BE ABLE TO KNOW WHAT IT IS LIKE TO NOT HAVE A CAR PAYMENT BECAUSE AT ANY MOMENTS NOTICE MY 2004 SATURN ION MIGHT FALL APART!!!!! *TR
MY SATURN ION 2004, BOUGHT SEPT. 2007 FROM CARMAX, FREQUENTLY DOES NOT START WHEN IT IS COLD OUTSIDE. FOR EXAMPLE, IT WAS ABOUT 33 DEGREES THIS MORNING AND EVEN WHEN I JUMPED IT, THE CAR WOULD NOT START. I HAD THE SAME PROBLEM LAST WINTER- MY FIRST WINTER HAVING THIS CAR. WHEN THE WEATHER IS WARM, I DO NOT HAVE ANY PROBLEMS WITH…
Read full complaint
MY SATURN ION 2004, BOUGHT SEPT. 2007 FROM CARMAX, FREQUENTLY DOES NOT START WHEN IT IS COLD OUTSIDE. FOR EXAMPLE, IT WAS ABOUT 33 DEGREES THIS MORNING AND EVEN WHEN I JUMPED IT, THE CAR WOULD NOT START. I HAD THE SAME PROBLEM LAST WINTER- MY FIRST WINTER HAVING THIS CAR. WHEN THE WEATHER IS WARM, I DO NOT HAVE ANY PROBLEMS WITH MY CAR STARTING. I HAVE HAD THE BATTERY CHECKED AND THERE WAS NOTHING WRONG WITH IT BUT I AM GOING TO GET THE STARTER CHECKED TODAY. I HAVE BEEN READING ABOUT THIS PARTICULAR PROBLEM ON VARIOUS ONLINE FORUMS. APPARENTLY THERE ARE MANY OTHER PEOPLE WHO HAVE THE SAME PROBLEM BUT THERE HAS BEEN NO RECALL. AS AN EDUCATOR, I CANNOT AFFORD TO PAY FOR REPAIRS THAT ARE NOT GOING TO FIX THE PROBLEM, AS I HAVE READ PEOPLE ONLINE HAVE ALREADY DONE. I CANNOT AFFORD TO BUY A NEW CAR, AND MOST IMPORTANTLY, AS A TEACHER, I CANNOT AFFORD TO BE LATE TO SCHOOL WHENEVER IT IS COLD. I AM VERY HOPEFUL THAT MY EFFORTS IN MAKING THIS COMPLAINT WILL RESULT IN A RECALL FOR THE CAUSE FOR THIS PROBLEM. READING THE ONLINE FORUMS, IT SEEMS LIKE THE PROBLEM IS WITH THE IGNITION/STARTER. THANK YOU FOR YOUR TIME AND PATIENCE. HAVE A WONDERFUL DAY! *TR
Official recalls
814V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
04V547000 · Exterior Lighting:turn Signal
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
04V281000 · Fuel System, Other:delivery:fuel Pump
Jun 8, 2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
04V002000 · Structure:body:bumpers
Jan 6, 2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence & remedy
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
04V003000 · Fuel System, Gasoline
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
04V004000 · Visibility:power Window Devices And Controls
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.