NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
331 reportsClear category filterMileage unknown · Apr 15, 2009
Electrical System
MY CAR HAS PROBLEMS STARTING WHEN THE TEMP. GETS BELOW 30 DEGREES. I HAVE HAD THIS "FIXED" TWICE, AND I WAS TOLD THIS WAS BECAUSE I NEEDED A NEW IGNITION SWITCH. I HAVE FOUND SEVERAL SITES WHERE OTHERS HAVE HAD THE SAME ISSUE. I HAVE CONCLUDED THAT THERE IS SOMETHING WRONG WITH THE SENSOR IN THE PASSLOCK PART OF THE IGNITION SWI…
Read full complaint
MY CAR HAS PROBLEMS STARTING WHEN THE TEMP. GETS BELOW 30 DEGREES. I HAVE HAD THIS "FIXED" TWICE, AND I WAS TOLD THIS WAS BECAUSE I NEEDED A NEW IGNITION SWITCH. I HAVE FOUND SEVERAL SITES WHERE OTHERS HAVE HAD THE SAME ISSUE. I HAVE CONCLUDED THAT THERE IS SOMETHING WRONG WITH THE SENSOR IN THE PASSLOCK PART OF THE IGNITION SWITCH THAT CAUSES IT TO NOT WORK PROPERLY WHEN TEMP. GETS BELOW 30 DEGREES. SATURN IS WELL AWARE OF THIS I BELIEVE AND THEY HAVE YET TO DO ANYTHING ABOUT IT. IT IS VERY DANGEROUS BECAUSE IT CAN CAUSE SOMEONE TO BE STRANDED SOMEWHERE IN THE COLD WEATHER. IT HAS ALSO CAUSED ME TO BE LATE FOR WORK SEVERAL TIMES AND HAS ALMOST COST ME MY JOB. *TR
NHTSA ODI #10265398
Mileage unknown · Apr 14, 2009
Electrical SystemEquipmentSteering
I HAVE SO MANY THINGS WRONG WITH MY 2004 SATURN OF COURSE I HAVE THE COLD START PROBLEM WHICH I HAVE HAD SINCE I PURCHASED THE CAR(WITH ONLY 7 MILES ON IT). ANYTIME I DRIVE MY CAR OVER 30 MILES AN HOUR IT SHAKES HAD THAT PROBLEM FIX 2 YEARS AGO AND NOW IT IS DOING IT AGAIN. MY DRIVER SIDE WINDOW SEAL LEAKS WHEN IT RAINS. NEW PRO…
Read full complaint
I HAVE SO MANY THINGS WRONG WITH MY 2004 SATURN OF COURSE I HAVE THE COLD START PROBLEM WHICH I HAVE HAD SINCE I PURCHASED THE CAR(WITH ONLY 7 MILES ON IT). ANYTIME I DRIVE MY CAR OVER 30 MILES AN HOUR IT SHAKES HAD THAT PROBLEM FIX 2 YEARS AGO AND NOW IT IS DOING IT AGAIN. MY DRIVER SIDE WINDOW SEAL LEAKS WHEN IT RAINS. NEW PROBLEM DON'T THINK I'VE SINCE THIS ONE YET THE TRANSMISSION IN THE WINDSHIELD WIPER GOES OUT ND GUESS WHAT FOR ONLY $275 SATURN WILL REPLACE THAT FOR YOU. THIS CAR IS SUCH A LEMON. CLEARLY AS I READ OVER COMPLAINTS OF THE SINGLE MOTHERS LIKE MYSELF, THE TEACHER OR JUST SOMEONE WHO WANT A RELIABLE CAR. THIS EXPERIENCE HAS TAUGHT ME NEVER BY AMERICAN AGAIN AND DO MY RESEARCH BEFORE BUYING ANOTHER CAR. THE THING I HATE THE MOST IS THAT THEY SEEM TO HAVE TO TAKE NO RESPONSIBILITY FOR THIS CAR. *TR
NHTSA ODI #10265203
35,000 miles · Apr 3, 2009
Electrical System
I PURCHASED MY CAR NEW IN 2004 AND I HAVE HAD AN ONGOING PROBLEM WITH IT STARTING. IT HAPPENS AT RANDOM TIMES AND GENERALLY AFTER 10 MINUTES TO 30 MINUTES IT WILL START UP. I M NOT SURE IF THE FACT THAT I CAN REMOVE MY KEYS FROM THE IGNITION WHILE IM DRIVING DOWN THE ROAD HAS SOMETHING TO DO WITH IT OR NOT. IT DOES SEEM LIKE I…
Read full complaint
I PURCHASED MY CAR NEW IN 2004 AND I HAVE HAD AN ONGOING PROBLEM WITH IT STARTING. IT HAPPENS AT RANDOM TIMES AND GENERALLY AFTER 10 MINUTES TO 30 MINUTES IT WILL START UP. I M NOT SURE IF THE FACT THAT I CAN REMOVE MY KEYS FROM THE IGNITION WHILE IM DRIVING DOWN THE ROAD HAS SOMETHING TO DO WITH IT OR NOT. IT DOES SEEM LIKE IT DOES IT MORE IN COLD/RAINY WEATHER THAN OTHER TIMES. THERE ARE STILL SEVERAL INCIDENTS WHERE IT HAS BEEN WARM AND SUNNY AND IT WONT START. I AM A SINGLE MOM WITH TWO KIDS AND I HATE THE THOUGHT OF BEING STUCK IN MY CAR W/ MY KIDS AND UNABLE TO GO ANYWHERE. I HAVE BEEN STUCK IN PARKING LOTS LATE AT NIGHT AFTER I GET OFF WORK AND ONE TIME IT WOULDN'T START ON MY WAY TO THE HOSPITAL. NO ONE SEEMS TO KNOW HOW TO FIX IT AND EVERYONE PRETTY MUCH AGREES IT HAS SOMETHING TO DO W/ THE ANTITHEFT DEVICE PUT ON THE CAR. SO HOW DO WE FIX IT AND WHY WONT SATURN DO ANYTHING ABOUT . TODAY'S ECONOMY IS TO BAD TO BE LOOSING CUSTOMERS AND MY CHILDREN ARE TOO IMPORTANT TO ME TO BE STUCK IN A CAR (AT ANY GIVEN TIME) WITH NO WAY TO MOVE. IN THE FUTURE I WILL BE LOOKING FOR A MORE DEPENDABLE SAFE CAR. *TR
NHTSA ODI #10264096
50,000 miles · Mar 30, 2009
Electrical System
THE PROBLEM BEGAN WITHIN THE FIRST MONTH OF THE CAR'S PURCHASE. IT WAS COLD OUTSIDE, AND THE CAR WOULDN'T START. AFTER ABOUT 30 MINUTES, IT STARTED RIGHT UP. AFTER VISITING SEVERAL MECHANICS, I WAS ADVISED TO REPLACE THE ALTERNATOR. SINCE THEN, I CANNOT COUNT THE NUMBER OF TIMES THAT I GO OUT TO THE CAR AND IT WON'T START.NO…
Read full complaint
THE PROBLEM BEGAN WITHIN THE FIRST MONTH OF THE CAR'S PURCHASE. IT WAS COLD OUTSIDE, AND THE CAR WOULDN'T START. AFTER ABOUT 30 MINUTES, IT STARTED RIGHT UP. AFTER VISITING SEVERAL MECHANICS, I WAS ADVISED TO REPLACE THE ALTERNATOR. SINCE THEN, I CANNOT COUNT THE NUMBER OF TIMES THAT I GO OUT TO THE CAR AND IT WON'T START.NOW, I AM TOLD THAT IT 'MAY BE' A FAULTY IGNITION SWITCH. I AM A TEACHER, AND CANNOT BE LATE FOR CLASS. I HAVE 34 STUDENTS WAITING FOR ME EVERY MORNING. NOW, I HAVE TO GO OUT TO MY CAR, 30 MINUTES EARLY, AND START IT. IF IT STARTS, I RUN OUT 30 MINUTES WORTH OF GAS FOR FEAR THAT IT WON'T START IF I TURN IT OFF. IF IT DOESN'T START, I WASTE 20 TO 25 MINUTES IN THE MORNING GETTING IT TO START. THIS WINTER, IT HAS NOT STARTED NO LESS THAN 15 TIMES. THIS CAR IS NOT DEPENDABLE. *TR
NHTSA ODI #10263651
66,000 miles · Mar 28, 2009
Electrical System
MY 2004 SATURN ION DOES NOT START IN COLD WEATHER. IT HAS A BRAND NEW BATTERY AND STARTER, YET IT IS STILL HAVING THIS PROBLEM. IT WILL GENERALLY START AFTER WAITING ABOUT 15 MINUTES TO TRY AGAIN. THE CONSEQUENCES ARE BEING DELAYED 15-20 MINUTES EACH TIME I WANT/NEED TO GO SOMEWHERE. *TR
NHTSA ODI #10263525
48,000 miles · Mar 23, 2009
Electrical System
CAR WILL NOT START AT TIMES , AFTER LETTING IT SIT FOR ABOUT 10 MINS AFTER CRANKING THE KEY A FEW TIMES, IT WILL START RIGHT UP. SEEMS TO BE A COMMON ISSUE WITH THIS YEAR MAKE AND MODEL, SOMETHING TO DO WITH A WHITE WIRE THAT IS PART OF A PLUG CONTAINING A BUNCH OF WIRES THAT PLUG IN UNDERNEATH THE STEERING COLUMN. THE PROBLEM S…
Read full complaint
CAR WILL NOT START AT TIMES , AFTER LETTING IT SIT FOR ABOUT 10 MINS AFTER CRANKING THE KEY A FEW TIMES, IT WILL START RIGHT UP. SEEMS TO BE A COMMON ISSUE WITH THIS YEAR MAKE AND MODEL, SOMETHING TO DO WITH A WHITE WIRE THAT IS PART OF A PLUG CONTAINING A BUNCH OF WIRES THAT PLUG IN UNDERNEATH THE STEERING COLUMN. THE PROBLEM SEEMS TO BE MORE LIKELY TO HAPPEN WHEN ITS DAMP OR RAINING OUTSIDE. AND WILL ALWAYS FIX ITSELF IF YOU LET THE CAR SIT FOR ABOUT 10 MINS BEFORE TRYING TO CRANK IT AGAIN. CAR HAS A NEW BATTERY, SEEMS TO BE A LOT OF POSTS ABOUT THIS ISSUE ON BULLETIN BOARDS ON LINE. SEEMS LIKE CUTTING THE WHITE WIRE SEEMS TO FIX THE ISSUE EVERY TIME. *TR
NHTSA ODI #10262770
66,000 miles · Mar 22, 2009
Electrical System
I AM HAVING A CONSISTENT PROBLEM W/ MY 2004 SATURN ION 4 DOOR 3.3 ENGINE. THE PROBLEM BEING IS NO CRANK WITH POWER ON. AFTER WAITING 10 - 15 MINUTES THE CAR WILL CRANK & START. THIS HAPPENS INTHE MORNING TRYING TO GET TO WORK, AT THE GAS STATION TRYING TO LEAVE AFTER A FILL UP, AT THE RED LIGHT IF I PUMP THE IGNITION JUST …
Read full complaint
I AM HAVING A CONSISTENT PROBLEM W/ MY 2004 SATURN ION 4 DOOR 3.3 ENGINE. THE PROBLEM BEING IS NO CRANK WITH POWER ON. AFTER WAITING 10 - 15 MINUTES THE CAR WILL CRANK & START. THIS HAPPENS INTHE MORNING TRYING TO GET TO WORK, AT THE GAS STATION TRYING TO LEAVE AFTER A FILL UP, AT THE RED LIGHT IF I PUMP THE IGNITION JUST SO. AFTER READING SEVERAL ION FORUMS THERE IS A VERY LARGE PROBLEM HERE. A RECALL SHOULD BE ISSUED AT LEAST INVESTIGATED. I AM TAKING THE VEHICLE INTO SATURN MONDAY THE 3.23.09 TO HAVE OIL CHANGE & NO CRANK W/ POWER EVALUATED. I WILL KEEP YOU INFORMED. *TR
NHTSA ODI #10262712
466,700 miles · Mar 13, 2009
Electrical System
I OWN A 04 SATURN ION. I HAVE BEEN HAVING A CONSTANT PROBLEM STARTING THE CAR. WHEN THE TEMPERATURE IS BELOW 40 DEGREES, THE CAR WON'T START. ALL THE DASH LIGHTS ARE ILLUMINATED. SO I KNOW THE BATTERY ISN'T THE PROBLEM. I HAVE TO WAIT 20 MINUTES BEFORE THE CAR STARTS UP. AFTER DOING SOME RESEARCH. IT LOOKS LIKE THE PROBLEM IS TH…
Read full complaint
I OWN A 04 SATURN ION. I HAVE BEEN HAVING A CONSTANT PROBLEM STARTING THE CAR. WHEN THE TEMPERATURE IS BELOW 40 DEGREES, THE CAR WON'T START. ALL THE DASH LIGHTS ARE ILLUMINATED. SO I KNOW THE BATTERY ISN'T THE PROBLEM. I HAVE TO WAIT 20 MINUTES BEFORE THE CAR STARTS UP. AFTER DOING SOME RESEARCH. IT LOOKS LIKE THE PROBLEM IS THE STARTER SWITCH. THE GREASE HARDENS UP IN THE COLD, THEN THE SECURITY SYSTEM LOCKS OUT THE STARTER SWITCH. I HAVE READ HUNDREDS OF COMPLAINTS ON MESSAGE BOARDS REGARDING THIS PROBLEM. I KNOW GM AND SATURN KNOW OF THIS PROBLEM ALSO. THEY ARE SAYING THIS ISN'T A SAFETY PROBLEM. I THINK IT IS. MANY PEOPLE ARE HAVING TO SIT IN THEIR CARS WHEN IT'S BELOW FREEZING, WAITING TWENTY MINUTES TO START THEIR ION'S. WHAT ABOUT PARENTS WITH KIDS? WHAT ABOUT IF SOMEONE IS TRYING TO CARJACK MYSELF? I DON'T HAVE AWAY TO ESCAPE BY DRIVING OFF. *TR
NHTSA ODI #10261787
Mileage unknown · Mar 13, 2009
Electrical System
MY 2004 SATURN ION HAS BEEN GIVING ME TROUBLE FOR AROUND 2 YEARS NOW. IT'S OFF AND ON. I'LL DRIVE MY CAR TO WALMART OR WHERE EVER AND GO IN THE STORE, COME OUT AND IT WON'T START. IF I GIVE IT 15-20 MINS IT FINALLY STARTS. MY DAD THOUGHT IT MIGHT BE MY BATTERY, BUT THAT WAS NEW. WE ARE GOING TO TRY AND GET AN IGNITION SWI…
Read full complaint
MY 2004 SATURN ION HAS BEEN GIVING ME TROUBLE FOR AROUND 2 YEARS NOW. IT'S OFF AND ON. I'LL DRIVE MY CAR TO WALMART OR WHERE EVER AND GO IN THE STORE, COME OUT AND IT WON'T START. IF I GIVE IT 15-20 MINS IT FINALLY STARTS. MY DAD THOUGHT IT MIGHT BE MY BATTERY, BUT THAT WAS NEW. WE ARE GOING TO TRY AND GET AN IGNITION SWITCH NOW. HOPEFULLY THAT WILL FIX IT! *TR
NHTSA ODI #10261785
38,000 miles · Mar 13, 2009
Electrical System
WE HAVE A 2004 SATURN ION THAT WHEN IT COLDS DOES NOT START. AT FIRST WE THOUGHT IT WAS THE BATTERY, BUT THE BATTERY IS FINE. THEN WE NOTICED THAT IT ONLY HAPPENED ON COLD DAYS. IF THE TEMP WAS BELOW 40 DEGREES F. AND THE CAR SAT FOR SEVERAL HOURS (MOSTLY MORNINGS), WHEN YOU ATTEMPTED TO CRANK, THE CAR WOULD NOT START. IF S…
Read full complaint
WE HAVE A 2004 SATURN ION THAT WHEN IT COLDS DOES NOT START. AT FIRST WE THOUGHT IT WAS THE BATTERY, BUT THE BATTERY IS FINE. THEN WE NOTICED THAT IT ONLY HAPPENED ON COLD DAYS. IF THE TEMP WAS BELOW 40 DEGREES F. AND THE CAR SAT FOR SEVERAL HOURS (MOSTLY MORNINGS), WHEN YOU ATTEMPTED TO CRANK, THE CAR WOULD NOT START. IF SEEMS IF YOU HAVE A DEAD BATTERY. MOST OF THE TIME IT WOULD START AFTER ABOUT 10 TO 15 MINUTES. THIS IS VERY DANGEROUS, BEING STRANDED DUE TO MILDLY COLD WEATHER. THANK GOD NOTHING BAD HAS HAPPENED WHILE WAITING FOR CAR TO CRANK. I HAVE TALKED TO SEVERAL SATURN OWNERS, AND THEY TO HAVE THE SAME PROBLEM. AT LEAST I LIVE IN FLORIDA AND IT DOES NOT STAY COLD LONG. SATURN NEEDS TO FIX THIS PROBLEM. ALSO, WAS TOLD BY A SERVICE PERSON AT SATURN TO TAKE A BLOW DRYER TO WARM THE STEERING COLUMN. THIS HAS BEEN HAPPENING FOR A FEW YEARS NOW. *TR
NHTSA ODI #10261699
Official recalls
8Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jun 8, 2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 6, 2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence & remedy
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration