In late May 2025, I took delivery of a new leased 2025 Rivian R1S equipped with the MaxPack battery. Since delivery, the vehicle has had intermittent electrical issues with the USB-C ports that I reported on June 12th (approx 3 weeks from taking delivery), but on July 28, 2025, it experienced a sudden and complete electrical sys…
Read full complaint
In late May 2025, I took delivery of a new leased 2025 Rivian R1S equipped with the MaxPack battery. Since delivery, the vehicle has had intermittent electrical issues with the USB-C ports that I reported on June 12th (approx 3 weeks from taking delivery), but on July 28, 2025, it experienced a sudden and complete electrical system failure while parked. Both the high-voltage and low-voltage systems shut down, leaving the vehicle entirely inoperable. Rivian Service has reported that the incident was caused by an isolation fault, which triggered the pyrotechnic safety fuses to blow, fully disconnecting the high-voltage battery. The vehicle required towing on dollies to a Rivian Service Center, where it remains out of service pending repairs. This failure occurred within just a few months of delivery, and I have been informed by the tow operator that similar failures have occurred with other 2025 Rivian MaxPack vehicles. This defect completely disables the vehicle without warning, creating a serious safety risk if it were to occur while driving.
NHTSA ODI #11679876
Mileage unknown · Feb 11, 2025
Engine
On November 16, 2024, while trying to use the vehicle's heating system, only cold air would come out of the vents and an error message, “thermal system fault” appeared on the screen. The service center instructed to not drive it and eventually picked it up via tow truck and made repairs. The vehicle was returned and hot air succ…
Read full complaint
On November 16, 2024, while trying to use the vehicle's heating system, only cold air would come out of the vents and an error message, “thermal system fault” appeared on the screen. The service center instructed to not drive it and eventually picked it up via tow truck and made repairs. The vehicle was returned and hot air successfully comes out of the vents but it is often accompanied by extremely loud noises (like a jet engine) as well as some pulsating and odd noises. Also, periodically only cold air comes out of all vents (even though the screen shows heat) if the defog is selected with temperature and fan speed regulated. The safety and performance of the battery has been impacted by the faulty thermal management system.
NHTSA ODI #11642032
Mileage unknown · Jan 13, 2025
Electrical SystemEnginePower Train
On January 9, I was driving my new 2025 Rivian R1S (approx. 2,400 miles) when it suddenly displayed “Drive stalk not working.” The vehicle jolted, made a loud noise from the front axle, and then fully stopped in the middle of a busy road with the battery still at 55%. Once it stopped, I had no hazard lights or power steering, an…
Read full complaint
On January 9, I was driving my new 2025 Rivian R1S (approx. 2,400 miles) when it suddenly displayed “Drive stalk not working.” The vehicle jolted, made a loud noise from the front axle, and then fully stopped in the middle of a busy road with the battery still at 55%. Once it stopped, I had no hazard lights or power steering, and the infotainment system locked up. After several attempts to reboot, the screen showed “Critical battery error” before shutting down completely. I was unable to move the vehicle or alert other drivers with flashing lights, creating a major safety hazard. It took about two hours for a tow truck to arrive. ## Component or System Failure: The vehicle’s propulsion system (drive controls) and electrical/hazard light systems appeared to fail simultaneously. The vehicle is currently at a service center for inspection and could be made available if needed. ## Safety Risk: Being stranded in the middle of the road without hazard lights or any way to move the car put myself and other drivers at serious risk. ## Reproduction/Confirmation: It has not been confirmed or reproduced yet by the service center. ## Inspection: The manufacturer’s service center is inspecting the vehicle. No other parties (police or insurance) have inspected it. ## Warning Lamps/Messages: There were no prior warnings. The “Drive stalk not working” error and subsequent “Critical battery error” appeared just moments before the vehicle stopped. I am reporting this because a sudden, total shutdown without hazard lights is a serious safety concern, especially on a busy road.
Rivian Automotive, LLC (Rivian) is recalling certain 2025-2026 R1S and R1T vehicles. One or both front turn signals may fail to illuminate and flash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Turn signals that do not function properly increase the risk of a crash.
Remedy: Rivian will inspect and replace the front turn signals as necessary, free of charge. Owner notification letters are expected to be mailed September 29, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1833. This is an expansion of Recall 25V387. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 31, 2026.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Seat Belts:critical Fasteners
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.
Consequence & remedy
Consequence: The toe link joint may separate, increasing the risk of a crash.
Remedy: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles operating a software version prior to 2025.18.30. The Hands-Free Highway Assist (HWA) software may fail to correctly identify a lead vehicle.
Consequence & remedy
Consequence: Failure to detect another vehicle increases the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1744.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. An improperly grounded connection inside the High Voltage Distribution Box (HVDB) may cause a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Rivian will inspect and repair the HVDB ground strap joint or replace the high voltage battery pack as necessary, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1723.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. One or both front turn signals may fail to illuminate and flash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Turn signals that do not function properly, failing to indicate the driver's intention to change direction, increase the risk of a crash.
Remedy: Rivian will inspect and replace the front turn signals as necessary, free of charge. Owner notification letters were mailed September 22, 2025. Owners will receive a second notice once the remedy becomes available. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1693.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.
Consequence & remedy
Consequence: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. The headlight low beams may fail to illuminate when starting the vehicle in cold weather. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Headlight failure can reduce visibility, increasing the risk of a crash.
Remedy: Rivian will replace the headlight control modules, free of charge. Owner notification letters were mailed September 22, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1612.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence & remedy
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Additional source detail variants (2)
Electrical System:software
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Exterior Lighting
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Additional source detail variants (2)
Steering:steering Control Module
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Vehicle Speed Control:cruise Control
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE26004 · Rear Toe Link May Separate
Opened May 26, 2026 · No close date supplied
Status: open (inferred from source dates) · Suspension:rear
The Office of Defects Investigation (ODI) has received two Vehicle Owner Questionnaires (VOQs) reporting left rear toe link separation in certain Model Year (MY) 2023-2024 Rivian R1S vehicles. Both VOQs report component separation while driving, causing the vehicles to swerve across multiple lanes of traffic. One incident resulted in a collision with an adjacent vehicle and roadside barrier. In both separations, the bolt that maintains the integrity of the toe link fractured. Evidence collected from the complaint vehicles included repair histories, onboard video, imagery of the damaged components, and a police accident report. The two vehicles with reported separation have different vehicle histories. One vehicle received prior service and the other was involved in a previous collision. In both instances, the vehicles operated for multiple months and thousands of miles of usage with no apparent problems between the previous service or the previous collision and the failures that prompted this investigation. Rivian recognized the subject toe link joint’s sensitivity to service procedures in March of 2025 in its updated service procedures. In January 2026 through recall 26V-003, Rivian extended the improved repair procedure to vehicles that received toe link service prior to the March 2025 improvement. ODI is opening a Preliminary Evaluation (PE) to (1) assess the sensitivity of the rear toe link joint to foreseeable road and service conditions, (2) compare the physical failure evidence from the two VOQs to identify apparent similarities and potential differences, (3) evaluate Rivian’s current toe link repair procedure, and (4) assess the in-field subject population’s toe links conditions. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov
2025 Rivian R1S Problems, Complaints & Recalls | Skip That Year
Illustration