OFFICIAL NHTSA RECALL
08V305000
Exterior Lighting:headlights
Reported Jul 9, 2008 · PIAGGIO USA, INC.
Summary
PIAGGIO IS RECALLING 646 MY 2007-2008 MOTO GUZZI NORGE 1200 MOTORCYCLE MODELS EQUIPPED WITH TRIOM HEADLIGHTS, LOW BEAM BULB AND HEADLIGHT REFLECTORS. THE HEADLIGHT LOW BEAM BULB HAS A "PIGTAIL" WIRE ATTACHED TO IT. THIS WIRE CONNECTS THE LOW BEAM BULB TO THE MOTORCYCLE'S WIRING HARNESS. IT MAY TOUCH THE HARDWARE USED TO SECURE THE BULB IN THE REFLECTOR. OVER TIME AND VIBRATION THE INSULATION MAY WEAR THROUGH CAUSING THE DIRECT SHORT TO GROUND. THIS SHORT CAUSES THE MOTORCYCLE'S MAIN FUSE TO BLOW AND ALL ELECTRICAL POWER TO THE MOTORCYCLE TO STOP.
Consequence
ELECTRICAL POWER TO THE MOTORCYCLE IS CUT OFF AND AS A RESULT, THE ENGINE STALLS INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSTALL A NEW BULB WITH AN EXTRA PROTECTION AROUND THE POWER WIRE TO PROVIDE GREATER PROTECTION. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT PIAGGIO AT 212-380-4431.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
This campaign page uses the representative official campaign record. Applicability-specific source variants appear on the linked vehicle pages. Recall counts refer to campaigns, not affected vehicles.
Vehicle entries in this campaign
This is model-level recall history. It does not confirm whether a particular VIN is affected or has received the repair. Check with NHTSA ↗