OFFICIAL NHTSA RECALL
08V283000
Electrical System:alternator/generator/regulator
Reported Jun 27, 2008 · WHEELED COACH INDUSTRIES
Summary
WHEELED COACH IS RECALLING 215 MY 2008 F-350, F-450, AND F-550 RESCUE VEHICLES BUILT ON FORD CHASSIS AND EQUIPPED WITH 6.4L DIESEL ENGINES. IT HAS BEEN DETERMINED THAT THE CONNECTION OF THE MASTER SWITCH YELLOW 16GA WIRE TO THE OEM PTO ENABLE CIRCUIT DISRUPTS THE REGENERATION MODE WHEN THE MASTER SWITCH IS IN THE "ON" POSITION. THE REGENERATION MODE FAILURE WILL EVENTUALLY CAUSE THE 6.4L DIESEL ENGINE TO REDUCE POWER AND ENTER IN TO A LIMP HOME MODE.
Consequence
THE REGENERATION MODE FAILURE WILL CAUSE THE 6.4L DIESEL ENGINE TO REDUCE POWER INCREASING THE RISK OF A CRASH.
Remedy
WHEELED COACH WILL MAIL OUT RELAY KITS ALONG WITH INSTALLATION INSTRUCTIONS. CUSTOMERS CAN ALSO TAKE THEIR VEHICLE TO A SERVICE CENTER TO HAVE THE RELAY INSTALLED IF THEY SO DESIRE. THE RECALL BEGAN ON JUNE 12, 2008. OWNERS MAY CONTACT WHEELED COACH AT 1-800-932-7077.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
This campaign page uses the representative official campaign record. Applicability-specific source variants appear on the linked vehicle pages. Recall counts refer to campaigns, not affected vehicles.
Vehicle entries in this campaign
This is model-level recall history. It does not confirm whether a particular VIN is affected or has received the repair. Check with NHTSA ↗