2019 RAM Promaster

My van is subject to NHTSA recall 25V-720 (manufacturer recall 67C): a cooling fan module susceptible to premature bearing wear combined with inadequate fuse protection on the 400W fan circuit, which the manufacturer states may lead to a engiine fire. I rent this vehicle out on Outdoorsy, my van is used commercially as a rental and part of their terms and conditions state this vehicle cannot go out if there is a recall notice. I thought for sure lithia would have this solved by this summer. Since August 26, 2025 and also remains incomplete TODAY. Two open safety recalls have run concurrently on this vehicle for nearly a year. It is still a HUGE safety risk and I have now lost all of my summer rentals schedule due to no solves being available. I had to cancel ten confirmed bookings covering June through September 2026 totaling $11,041.20 in lost income. The Outdoosy platform independently reviewed the situation and categorized all ten cancellations as caused by the manufacturer safety recall. The manufacturer's customer care department documented the loss in writing, then stated it was unable to determine or authorize compensation and could not provide any timeline for review or schedule the fix, as no parts were available 2026-05-27 when I could not get a fix scheduled after trying for 2 weeks to find a solution. This complaint concerns the manufacturer's failure to remedy an announced fire-risk safety recall in a timely manner, causing me loss of income totally $11,041.20 and who know how many other bookings that would have continued to come in throughout the summer. The parts JUST became available, but I have yet to be called back by lithia to have my service scheduled, they don't know when the parts will arrive. I am still loosing income.

The oil pan for the van was damaged due to debris pick up on the road resulting in a hole, which in turn drained the engine oil and jammed the engine preventing from operation. The lack of protection to the oil pan which is exposed, caused the debris to damage the oil pan. Ford Transit vans have a protection under the oil pan which prevents these type of incidents to happen. This vehicle was taken to the repair shop and they want $18527.10 to fix this problem. A small fix of few hundred should have solved the problem, if the manufacturer had the trouble to think through the design phase.

There is a known defect of the windshield cowl and compartment not being water tight. The defective cowl and compartment cause water to leak into the engine bay, which saturates the engine and various components. The defect resulted in the crankshaft position sensor getting wet. The wet sensor caused the engine to stall WHILE DRIVING, which resulted in loss of power steering and power brakes.

When it rains water runs into the engine compartment and all of my wiring is dripping water. The service manager told me that they see this problem a lot and that they don't know how to fix it. I have looked online and there are many people complaining about this. Most people think it is the cowl leaking on the bottom of the windshield. I feel like if my wiring gets wet enough that I will have a malfunction.

The coolant system has been repaired by a Ram certified dealership for the same issue 3 times with current mileage at 17,000. The coolant continues to leak out. We have a fleet of 30 Promaster 1500 and 2500 vans and all of them have coolant leaking issues with 4 requiring engine replacements because of overheating. Sometimes there are warning lamps to let us know to pull over, sometimes not and then it's too late. Please address this asap!

AROUND 4,000 MILES MY BRAND NEW VAN DIED ON ME GOING UP A SMALL INCLINE ROUND AROUND A SMALL CURVE. I LOST ALL POWER AND A HEAD ON VEHICLE ALMOST HIT ME HEAD ON BECAUSE I LIST ALL POWER, I LOST POWER STEERING, I LOST BRAKING POWER AND I AND MY DAD ALMOST DIED BECAUSE I WAS VEERING OFF A CLIFF. I RESTARTED THE VEHICLE AND WAS ABLE TO RETURN THE VEHICLE TO THE ROAD. AT AROUND 5,000 MILES MY AIR BAG LIGHT CAME ON FOR A HALF OF A DAY DRIVING. I HAVE HAD RADIATOR FLUID SMELL AND LEAKING. AT 5,600 MILES THE RAM DEALER SAID I HAVE A HOLE IN MY RADIATOR AND MY VEHICLE HAS TO WAIT IN THEIR SHP FOR 30 DAYS UNTIL THEY CAN GET THE NEW RADIATOR. THEY DON'T KNOW WHY IT DIED ON ME.

WHEN I TAKE MY FOOT OFF THE ACCELERATOR AND PUT IT ON THE BRAKE THE CAR SLOWS DOWN BUT THEN STARTS TO ACCELERATE AGAIN. ON A CITY STREET AT A STOP SIGN/LIGHT. A LIGHT WILL BRIEFLY FLASH ON DASH THAT SAYS "HILL HOLDER - SEE SERVICE". I'VE TAKEN IT TO BE CHECKED. THEY DROVE IT AND COULD NOT DUPLICATE. THIS ONLY HAPPENS INTERMITTENTLY SO THAT DIAGNOSTIC IS NOT GOING TO TELL ANYTHING.