Engine. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Diesel. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Engine complaints

2 reports

Clear category filter

15,000 miles · Feb 22, 2021

Engine

AT ONLY 15000 MILES AND 6 MONTHS OF LIFE, MY TRUCK IS LEAKING OIL/FUEL FROM THE CP4 FUEL PUMP. THE OIL/DIESEL IS LEAKING ON THE ENGINE BLOCK AND OTHER NEARBY HOT COMPONENTS WHICH I ASSUME COULD BE A FIRE HAZARD OR A FUEL SYSTEM DISASTER FAILURE. THE SYSTEM IS LEAKING ALL THE TIME WHILE ENGINE IS WORKING

NHTSA ODI #11397469

29,000 miles · Nov 28, 2020

Engine

Read full complaint

IST TIME, APPROX. 29,000 MILES, WITH NO WARNING, VEHICLE RAN POORLY, ROUGH AND DIED. STRANDED ON SIDE OF ROAD FOR 4 HOURS UNTIL A TOW TRUCK CAME. DIAGNOSED AS HIGH PRESSURE FUEL PUMP FAILURE. SECOND TIME, APPROX 39,000 MILES, SAME ISSUE OF STALLING, EXCEPT THIS TIME I WAS STUCK IN THE MIDDLE OF THE DESERT WITH 114 DEGREE TEMP FOR 8 HRS. BEFORE A TOW. SAME DIAGNOSIS, HIGH PRESSURE PUMP FAILURE. ALL DOCUMENTATION AVAILABLE THROUGH FCA CUSTOMER CARE CASE 76826889 AND ALSO [XXX] | CASE 76201975 REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11376793

Official recalls

22V759000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Oct 11, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 4500 and 5500 Cab Chassis vehicles. The rear brake hose inside diameter may be too small, which could cause the hose to rupture. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 106, "Brake Hoses."

Consequence & remedy

Consequence: A brake hose rupture can cause a loss of braking ability, increasing the risk of a crash.

Remedy: Dealers will replace the rear brake hoses, free of charge. Owner notification letters were mailed April 27, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZA5.

22V035000 · Visibility:windshield Wiper/washer:linkages

Jan 27, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500 and Ram 3500 vehicles, Ram 3500 Cab Chassis, 4500 Cab Chassis, 5500 Cab Chassis and 3500 Cab Chassis with a gross vehicle weight rating (GVWR) of less than 10,000 lbs. The windshield wiper arms may loosen, possibly causing the wipers to function improperly and reduce the driver's visibility in certain weather conditions.

Consequence & remedy

Consequence: Reduced visibility increases the risk of a crash.

Remedy: Dealers will tighten the wiper nuts, free of charge. Owner notification letters were mailed February 15, 2022. This recall is an expansion of recall number 20V-208. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z08.

21V880000 · Fuel System, Diesel:delivery:fuel Pump

Nov 12, 2021

Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500, 3500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. The High Pressure Fuel Pump (HPFP) may fail, resulting in a sudden engine stall without warning.

Consequence & remedy

Consequence: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the HPFP, update the Powertrain Control Module (PCM) software, and inspect and replace additional fuel system components as necessary, free of charge. Interim owner notification letters to inform owners of the safety recall were mailed on January 4, 2022. Owner notification letters were mailed on May 17, 2022. Phase 2 owner notification letters are expected to be mailed on March 2, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y78.

21V439000 · Engine And Engine Cooling:engine:oil/lubrication

Jun 10, 2021

Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 3500, 4500, and 5500 cab chassis vehicles equipped with a Cummins 6.7L High Output engine. The engine calibration software may not warn about low oil volume.

Consequence & remedy

Consequence: Low oil can damage the engine, causing an oil leak or a punctured engine block, increasing the risk of a fire.

Remedy: Dealers will update the engine calibration software, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Y21.

21V398000 · Wheels:lugs/nuts/bolts/studs

May 27, 2021

Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.

Consequence & remedy

Consequence: Wheel separation can cause a vehicle crash.

Remedy: Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.

21V023000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Jan 26, 2021

Excellance, Inc (Excellance) is recalling certain 2019-2020 Excellance-modified RAM 4500/5500 vehicles to be equipped with CLASS Suspension Systems. In the affected suspension systems, the rear brake caliper flexible line may have been routed so that it contacts a suspension component, possibly causing excessive wear and a loss of rear brakes.

Consequence & remedy

Consequence: A worn rear brake caliper flexible line may cause brake fluid leakage which may result in a partial or complete loss of the rear brakes, increasing the risk of a crash.

Remedy: Excellance will notify owners, and dealers will install a kit to remedy any damage and to prevent any future damage, free of charge. The manufacturer has not yet provided a schedule for recall notification. Owners may contact Excellance customer service at 1-800-882-9799.

21V008000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings

Jan 13, 2021

Braun Northwest (Braun Northwest) is recalling certain 2019-2020 RAM 4500/5500 vehicles equipped with Liquid Spring rear suspension systems. In the affected suspension systems, the rear brake caliper flexible line may have been routed so that it contacts a suspension component, possibly causing excessive wear and a loss of rear brakes.

Consequence & remedy

Consequence: A worn rear brake line may leak fluid, resulting in a partial or complete loss of the rear brakes, increasing the risk of a crash.

Remedy: Braun Northwest will notify owners, and dealers will install a repair kit to each rear caliper and modify the rear brake caliper flexible line mounting. Any worn rear brake caliper flexible lines will be replaced as needed, free of charge. The recall began June 8, 2020. Owners may contact Braun Northwest customer service at 1-360-748-0195.

20V511000 · Electrical System:software; Engine And Engine Cooling:engine:oil/lubrication

Aug 27, 2020

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 3500, 4500 and 5500 cab chassis built with a Cummins 6.7L High Output engine. Inadequate warmup protection can cause a lack of oil film on the engine connecting rod bearings while the engine is reaching operating temperature. This can result in engine damage and connecting rod failure, which could potentially puncture the engine block.

Consequence & remedy

Consequence: A damaged engine block may leak oil, which can contact hot engine or exhaust components, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will flash the engine calibration software to enhance the engine warm up protection, free of charge. The recall began September 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W57.

Additional source detail variants (2)

Engine And Engine Cooling:engine:oil/lubrication

Consequence: A damaged engine block may leak oil, which can contact hot engine or exhaust components, increasing the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will flash the engine calibration software to enhance the engine warm up protection, free of charge. The recall began September 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W57.

Electrical System:software

Consequence: A damaged engine block may leak oil, which can contact hot engine or exhaust components, increasing the risk of a fire.

19V498000 · Fuel System, Diesel

Jun 27, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 2500 and 3500 trucks, and 3500, 4500, and 5500 Cab Chassis vehicles equipped with diesel engines. The fuel lines may leak fuel into the engine compartment.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the fuel lines, replacing them if necessary, free of charge. The recall began July 18, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V76.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA23001 · High Pressure Fuel Pump Failure

Opened Mar 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337

PE21021 · High Pressure Fuel Pump Failure

Opened Oct 14, 2021 · Closed Apr 14, 2023

Status: closed (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021 to investigate allegations of stall/loss of motive power as a result of high pressure fuel pump failures in certain model year (MY) 2019-2020 RAM 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines.On November 12, 2021, FCA filed vehicle recall 21V-880 and equipment recall 21E-094 on the subject population, identifying an `internally failed component? of the high pressure fuel pump equipped on the 6.7L Cummins Turbodiesel engine that introduced debris into the fuel system potentially causing fuel starvation and consequently an unexpected loss of motive power. Discussions with FCA identified the high pressure fuel pump equipped on these vehicles as the Bosch-supplied CP4. On December 16, 2021, Bosch filed recall 21E-101, stating the pump failure was a consequence of a manufacturer application-specific fuel system design.NHTSA subsequently identified recall 21V-586 involving loss of motive power due to failed CP4 fuel pumps on certain BMW vehicles.As a result of having received multiple recalls related to a common component, from two separate vehicle manufacturers, NHTSA?s focus shifted to determine if the related defect allegation was limited in scope to the recalled population. In early 2022, information request letters were sent to FCA and BMW to determine the root cause and consequentially identify the proper scope of potentially defective vehicles. After ODI received their information request response, FCA filed recalls 22V-406, 22E-048, 22V-767, and 22E-087. During review of information request response materials, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA or BMW. On March 17, 2023, this Preliminary Evaluation was upgraded to an Engineering Analysis (EA23-001), expanding the scope to include the Tier-one supplier and any manufacturer who equipped or installed similar high pressure fuel pumps subject to the failures observed in the recall population.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11448163, 11458918, 11460558