Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports4 fire reports0 injury reports

Tires complaints

3 reports

Clear category filter

Mileage unknown · Dec 18, 2025

Tires

Read full complaint

I have had two tires separate in the past couple of months with less than 24000 miles and 5 years old. I filed a complaint with Nexen and they sent a partial payment for the first one but rejected the second claim that happened less than 500 miles of the first claim. They claim the tires are separated because of the low miles on the truck and it is not driven enough. Less than a year ago my brother had the same issue with the same tires and truck with similar mileage and was sent a check for 6 new tires. I have additional photos and photos of the other tire as well as emails with Nexen and XXX Sr. Quality Analyst © [XXX] [XXX] ® [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11705984

Mileage unknown · Jun 21, 2025

Tires

Read full complaint

Nexen Roadian HTX RH5 LT235 / 80 R 17. While driving down interstate and pulling a 21,000 lb GVWR fifth wheel trailer, the truck began vibrate. After stopping it appeared that the front passenger tire was out of round. This was confirmed after jacking up the vehicle. Suspect internal damage to the radials. The tire had a total of 16,600 miles on it. Tire had cold pressure of 80 psi and was just checked 4 days prior to the incident. Luckily, the issue was discovered prior to a catastrophic failure, so no damage or accident occured for this particular failure.

NHTSA ODI #11668364

Mileage unknown · May 19, 2025

Tires

Read full complaint

Nexen LT235/80R17 2 blow out's and one tire failure. factory installed tires. I have had 2 blowouts on the right front of my Ram 3500. I had discount tire unmount and re mount my spare on the blown-out tire wheel (for appearance purpose) so my spare is now another brand, the spare Nexen that replaced the blow out also blew out within ~2000 miles. I took the vehicle to Walts Live Oak Ram to inspect the vehicle for a cause of 2 tires blowing in the same position on the vehicle, they also checked the alignment and found nothing. yesterday [XXX] pulling a trailer to Jacksonville I noticed about 50 miles into the trip a slight shudder in the steering wheel and I pressed on. On the return trip the shudder in the steering was substantially profound and the driver side view mirror was bouncing up and down, the passenger side was not, and my hands were getting numb, I slowed to 50 from 70mph and continued, the shuddering eased but was clearly still there. today I took the truck to discount tire Lake city Fla. and asked them to replace the Nexen as I felt it was failing from looking at the tire and running my hand along the tread it didnt feel normal and the tire was hot compared to the passenger side. I asked discount to spin the Nexen on the balancer and they did, it confirmed the tire was failing and was unable to be balanced. the new tire cured the problem. the truck today clocked 37k miles to give you some perspective on mileage and primary use is for towing trailers, 42' 5th wheel, 16' box or flatbed trailer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

NHTSA ODI #11661886

Official recalls

25V765000 · Air Bags:frontal; Steering:steering Control Module

Nov 6, 2025

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.

Additional source detail variants (2)

Steering:steering Control Module

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.

Air Bags:frontal

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

23V060000 · Electrical System:wiring:relays/solenoids

Feb 9, 2023

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.

Consequence & remedy

Consequence: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.

22V904000 · Structure:body:tailgate:hinge And Attachments

Dec 8, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Consequence & remedy

Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

22V835000 · Power Train:automatic Transmission

Nov 10, 2022

FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

Consequence & remedy

Consequence: Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.

Remedy: Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.

22V140000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Mar 10, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.

Additional source detail variants (2)

Electronic Stability Control (esc)

Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.

21V925000 · Air Bags:side/window:curtain

Nov 24, 2021

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 2500, Ram 3500, and 2021 Ram 1500 Classic pickup trucks. The side air bag inflatable curtain (SABIC) assemblies may have been manufactured with the incorrect amount of compressed gas, which can result in an improper air bag deployment.

Consequence & remedy

Consequence: An air bag that deploys improperly can increase the risk of injury in a crash.

Remedy: Dealers will replace the SABIC assemblies, free of charge. Owner notification letters were mailed January 17, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y99.

21V798000 · Electrical System:wiring:relays/solenoids

Oct 14, 2021

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.

Consequence & remedy

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.

21V398000 · Wheels:lugs/nuts/bolts/studs

May 27, 2021

Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.

Consequence & remedy

Consequence: Wheel separation can cause a vehicle crash.

Remedy: Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.

21V163000 · Electrical System

Mar 11, 2021

Chrysler (FCA US, LLC) is recalling certain 2021 Ram 2500, 3500, and 3500, 4500, and 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the Solid State Intake Heater Grid Relay, which could result in a vehicle fire.

Consequence & remedy

Consequence: A vehicle fire increases the risk of injury.

Remedy: Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Customers are advised to not park these vehicles inside of buildings or structures, or near other vehicles until the vehicle has the final repair completed. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Y08. This recall has been superseded by recall number 21V-798.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA23001 · High Pressure Fuel Pump Failure

Opened Mar 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337