IllustrationLEAKING PLASTIC COOLING PIPES, VEHICLE IN MOTION, CITY STREET BOCA RAYON FL
2004 Porsche Cayenne Turbo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cayenne Turbo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 15 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Engine complaints
2 reportsOWNER OPERATES A 2004 PORSCHE CAYENNE TURBO, 4.5L V8 ENGINE. THIS VEHICLE, WITH JUST OVER 61,000 MILES BEGAN TO OVERHEAT FOUR DAYS PRIOR TO THE INCIDENT (DETECTED BY FLUCTUATING TEMPERATURE GAUGE). THE ENGINE COOLANT WAS FOUND TO BE LOW IN THE SERVICE BOTTLE BY APPX. 2 QUARTS WHEN CHECKED AND WAS REFILLED. THE EVENING BEFORE THE…
Read full complaint
OWNER OPERATES A 2004 PORSCHE CAYENNE TURBO, 4.5L V8 ENGINE. THIS VEHICLE, WITH JUST OVER 61,000 MILES BEGAN TO OVERHEAT FOUR DAYS PRIOR TO THE INCIDENT (DETECTED BY FLUCTUATING TEMPERATURE GAUGE). THE ENGINE COOLANT WAS FOUND TO BE LOW IN THE SERVICE BOTTLE BY APPX. 2 QUARTS WHEN CHECKED AND WAS REFILLED. THE EVENING BEFORE THE INCIDENT OWNER'S SPOUSE REPORTED A LOW COOLANT ALARM MESSAGE HAD DISPLAYED ON THE INSTRUMENT PANEL, COOLANT WAS ABOUT 2 QUARTS LOW IN THE SERVICE BOTTLE AND WAS REFILLED. THE NEXT DAY THE VEHICLE WAS BEING RUN AT 1500 RPM (FAST IDLE) IN A PARKED POSITION IN THE OWNER'S DRIVEWAY FOR A TEST WHEN A FLOOD OF ENGINE COOLANT WAS OBSERVED COMING FROM THE UNDERSIDE OF THE VEHICLE. VEHICLE ENGINE WAS IMMEDIATELY SECURED TO AVOID DAMAGE. AT THIS POINT THE VEHICLE WOULD NOT BE CONSIDERED DRIVABLE AND WOULD NEED TO BE TOWED TO A SERVICE FACILITY. AN INVESTIGATIVE TEARDOWN REVEALED A RUPTURED PLASTIC COOLING PIPE INSIDE THE VALLEY OF THE ENGINE, THIS FAILURE REQUIRED REMOVAL OF THE INTAKE MANIFOLD TO DIAGNOSE AND IS NOT A ROADSIDE-REPAIRABLE EVENT. THE EVENT CAUSED LOSS OF MORE THEN 50% OF TOTAL COOLANT VOLUME AS ONLY APPX. 1 GALLON WAS RECOVERED FROM THE VEHICLE PRIOR TO TEARDOWN. A PRESCRIBED REPAIR KIT FOR THIS FAILURE (REPLACEMENT COOLING PIPES KIT) WAS OBTAINED FROM SONNEN PORSCHE, SAN FRANCISCO CA AND INSTALLED BY VEHICLE OWNER. AFTER FILLING OF COOLANT AND TEST DRIVING, NO FURTHER PROBLEM WAS NOTED. *TR
Official recalls
819V446000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Jun 12, 2019
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S, Cayenne Turbo, 2004-2010 Cayenne, 2006 Cayenne Turbo S, 2010-2016 Panamera S, Panamera 4 S, Panamera Turbo, 2011-2016 Panamera, Panamera 4, 2012-2013 Panamera Turbo S, 2013-2016 Panamera 4 GTS, 2014-2016 Panamera 4 S Executive, Panamera Turbo Executive, Panamera Turbo S G1 II, Panamera Turbo S Executive, 2013 Panamera 4 Platinum Edition, Panamera Platinum Edition, 2016 Panamera 4 Edition, Panamera Edition, Panamera Turbo S Executive Luxury Sports vehicles. The bushing that attaches the gear selector lever to the gearbox may degrade over time, causing the bushing to detach. This condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
Consequence & remedy
Consequence: If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Remedy: Porsche will notify owners, and dealers will replace the shifter cable bushing, free of charge. Owners are instructed to use the parking brake until their vehicle is repaired. The recall began August 9, 2019. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AKB1.
17V576000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 20, 2017
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S and Cayenne Turbo vehicles, 2004-2006 Cayenne vehicles, and 2006 Cayenne S "Titanium" Edition vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Porsche will notify owners, and dealers will replace the fuel filter flanges with new filter flanges that have a protective film, free of charge. The recall began July 6, 2018. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AH10.
04V593000 · Seat Belts
Dec 15, 2004
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED INCREASING THE RISK OF INJURY OR DEATH TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL PERMANENTLY INSTALL A CLIP IN EITHER OF THE AFFECTED REAR OUTBOARD SEAT BELTS AND PROVIDE AN OWNER'S MANUAL INSERT. THE CLIPS WILL PREVENT UNWARRANTED CONVERSION FROM ALR TO ELR MODE WITH CHILD SEAT INSTALLATION. THE RECALL BEGAN MAY 17, 2005. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
04V231000 · Seat Belts:rear/other
May 17, 2004
ON CERTAIN PASSENGER VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT IS INSUFFICIENT RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BELT BUCKLE LATCH AND, IF NECESSARY, REPLACE THE LATCH. OWNER NOTIFICATION BEGAN ON JUNE 1, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
04V069000 · Electrical System:wiring:front Underhood
Feb 18, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE MAIN WIRING HARNESS WAS INCORRECTLY ROUTED. DAMAGE TO THE MAIN WIRING HARNESS CAN LEAD TO THE FAILURE OF VARIOUS ELECTRICAL SYSTEMS.
Consequence & remedy
Consequence: IN EXTREME CASES, TO A CABLE FIRE BENEATH THE INSTRUMENT PANEL IN THE PASSENGER COMPARTMENT.
Remedy: DEALERS WILL RE-ROUTE THE WIRING HARNESS. OWNER NOTIFICATION SCHEDULE BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
04V071000 · Power Train:automatic Transmission
Feb 18, 2004
CERTAIN SPORT UTILITY VEHICLES MAY HAVE HAD A TRANSFER CASE INSTALLED THAT COULD, DUE TO CHANGES IN THE HOUSING CASTING, RESULT IN THE OIL PUMP ROTATION. SHOULD THIS OCCUR, OIL STARVATION OF THE INTERNAL GEARS MIGHT RESULT.
Consequence & remedy
Consequence: CONTINUED OPERATION OF THE VEHICLE COULD RESULT IN A FRACTURE OF THE TRANSFER CASE HOUSING. INCORRECT TORQUE WOULD THEN BE APPLIED TO THE DRIVEN WHEELS OR OIL COULD LEAK AND CONTACT THE TIRES.
Remedy: DEALERS WILL INSPECT THE TRANSFER CASE HOUSING AND, IF NECESSARY, REPLACE THE TRANSFER CASE. OWNER NOTIFICATION BEGAN ON MAY 3, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
04V072000 · Seats
Feb 18, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER'S SIDE SEAT FRAMES WERE NOT ADEQUATELY WELDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT FRAME COULD BREAK, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT FRAME. OWNER NOTIFICATION BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
03V351000 · Equipment:other:labels
Sep 24, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE AFFECTED VEHICLES MAY BE MISSING THE GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATINGS (GAWR) ON THE CERTIFICATION LABEL AS REQUIRED BY PART 567.4(G)(3) AND (G)(4).
Consequence & remedy
Consequence: THE VEHICLE OPERATOR WILL NOT BE INFORMED OF THE VEHICLE'S GVWR AND GAWR.
Remedy: DEALERS WILL APPLY THE CORRECTED LABEL. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA06005 · Srs Warning Light Illumination
Opened Mar 15, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05060 · Srs Warning Light Illumination
Opened Nov 10, 2005 · Closed Mar 15, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.