Engine And Engine CoolingFuel System, GasolinePower Train
STALLS WHEN GETS WARM. ABS BRAKING LIGHT COMES ON EVERY NOW AND THEN. I WAS ROLLING UP WINDOW IT HAS ELECTRIC AND WINDOW SHATTERED IN SIDE DOOR. I HAVE PUT A NEW MODULE IN AND A NEWROTOR CAP AND THE NEW COIL. THE OLD COIL CAUGHT ON FIRE WHEN THE VAN STALLED ON ME. NOW IT HAS NO SPARK. I HAD IT IN SADLERS MOTORS AND THEY T…
Read full complaint
STALLS WHEN GETS WARM. ABS BRAKING LIGHT COMES ON EVERY NOW AND THEN. I WAS ROLLING UP WINDOW IT HAS ELECTRIC AND WINDOW SHATTERED IN SIDE DOOR. I HAVE PUT A NEW MODULE IN AND A NEWROTOR CAP AND THE NEW COIL. THE OLD COIL CAUGHT ON FIRE WHEN THE VAN STALLED ON ME. NOW IT HAS NO SPARK. I HAD IT IN SADLERS MOTORS AND THEY TOLD ME THE MODULE WAS BAD. I PUT IT IN. IT STUDDERS GOING DOWN THE ROAD WHEN IT GETS WARM GAS QUIT COMING OUT OF INJECTORS THEN WHEN I PUT MODULE ON INJECTORS WORK NOW I WAS WONDERING IF THERE WAS RECALLS ON ANY OF THAT STUFF I BAUGHT THE VAN USED. WARRANTY DOESN'T COVER ANY OF THIS. THEY SAID THE WARRANTY WAS IN WITH THE PRICE OF THE VAN BUT TO FIND OUT THEY CHARGED US FOR THE WARRANTY. SOMTIMES WHEN WE HIT A BUMP IT HAS A RATTLING NOISE FROM REAR; IT SOUNDS LIKE FROM FRONT SOMTIMES.
NHTSA ODI #10070293
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingPower TrainSeat Belts
TRANSMISSION - WHEN YOU START THE VAN, AND PUT INTO GEAR, IT TAKES AT LEAST 10-20 SECONDS BEFORE IT WILL ENGAGE INTO FORWARD AND REVERSE. DRIVERS SIDE SEATBELT- WOULD NOT RETRACT, HAD TO REPLACE, IT COST $100.00 REPLACED 2 ALTINATORS, 1 STARTER AND 4 BATTERIES. HAD TO RE-SEAL INTAKE TWICE. LIFTER TICK, DONUT SEAL REPLACED. VACUM…
Read full complaint
TRANSMISSION - WHEN YOU START THE VAN, AND PUT INTO GEAR, IT TAKES AT LEAST 10-20 SECONDS BEFORE IT WILL ENGAGE INTO FORWARD AND REVERSE. DRIVERS SIDE SEATBELT- WOULD NOT RETRACT, HAD TO REPLACE, IT COST $100.00 REPLACED 2 ALTINATORS, 1 STARTER AND 4 BATTERIES. HAD TO RE-SEAL INTAKE TWICE. LIFTER TICK, DONUT SEAL REPLACED. VACUMM LEAK REPAIRED. COOLANT LEAK, HAD TO REPLACE HEAD GASKET TWICE. COOLANT IS LEAKING AGAIN. DOOR HANDLE, DRIVERS SIDE BROKE TODAY.
NHTSA ODI #10069890
Mileage unknown · Dec 28, 2001
Power Train
WHILE DRIVING AT 55 MPH IN 20 DEGREE WEATHER, A TRANSMISSION LINE TO THE COOLER FAILED. LOTS OF OIL ON THE ROAD AND LOTS OF SMOKE. WE PULLED OVER AND STOPPED AVOIDING A FIRE. CAR WAS TOWED TO BE FIXED.BROKE. *AK
NHTSA ODI #756116
Mileage unknown · Jan 1, 2001
Engine And Engine CoolingPower TrainStructure
ALL THESE PROBLEMS OCCURED WITH LESS THAN 4 YEARS OF USE ON THIS VAN. WE HAVE REGULAR SERVICE RECORDS FOR IT AS WELL. IT WAS A VERY WELL TAKEN CARE OF VAN. WE JUST HAD TO REPLACE THE WHOLE TRANSMISSION WITH 90,000 MILES! WE'D LIKE TO BE RE-IMBURSED IF POSSIBLE BY PONTIAC.WE'VECALLED PONTIAC BUT HAVE RECEIVED NO HELP AS OF YET. W…
Read full complaint
ALL THESE PROBLEMS OCCURED WITH LESS THAN 4 YEARS OF USE ON THIS VAN. WE HAVE REGULAR SERVICE RECORDS FOR IT AS WELL. IT WAS A VERY WELL TAKEN CARE OF VAN. WE JUST HAD TO REPLACE THE WHOLE TRANSMISSION WITH 90,000 MILES! WE'D LIKE TO BE RE-IMBURSED IF POSSIBLE BY PONTIAC.WE'VECALLED PONTIAC BUT HAVE RECEIVED NO HELP AS OF YET. WE'D LIKE TO GET SOME HELP,WE HAVE ALL THE RECEIPTS OF ALL THE EXAUSTING WORK DONE TO THIS VAN. ITS NO WONDER THEY TOOK IT OUT OF PRODUCTION 3 YEARS LATER
NHTSA ODI #738586
Mileage unknown · Apr 11, 2000
Power TrainCrashInjury
CONSUMER'S 3-YEAR OLD SON WAS ABLE TO PUT TRANSMISSION GEAR INTO DRIVE WITHOUT TOUCHING PEDAL, VEHICLE MOVED, HITTING CONSUMER, AND PINNING HER AGAINST THE GARAGE. *AK
NHTSA ODI #860134
Mileage unknown · Jan 6, 2000
Electrical SystemPower TrainSeat Belts
TRANSMISSION SYSTEM DOESN'T WORK, DEALER SAID THE MODULE HAS FAILED BUT THEY SEE AS GM PROBLEM. THE CONTROLS BETWEEN THE STEERING WHEEL AND THE DASH ARE SHORTING OUT CHANGING EVERYTHING WHEN YOU DRIVE. SEAT BELTS HAVE BEEN REPLACED. THE DRIVER AND PASSENGER DOOR HANDLES HAVE BOTH BEEN REPLACED AS THEY BROKE RIGHT OFF. JUST S…
Read full complaint
TRANSMISSION SYSTEM DOESN'T WORK, DEALER SAID THE MODULE HAS FAILED BUT THEY SEE AS GM PROBLEM. THE CONTROLS BETWEEN THE STEERING WHEEL AND THE DASH ARE SHORTING OUT CHANGING EVERYTHING WHEN YOU DRIVE. SEAT BELTS HAVE BEEN REPLACED. THE DRIVER AND PASSENGER DOOR HANDLES HAVE BOTH BEEN REPLACED AS THEY BROKE RIGHT OFF. JUST SPENT $560.00 TO DEALER AND ALL I GOT WAS THE SEAT BELT FIXED. *AK
NHTSA ODI #717002
Mileage unknown · Mar 9, 1999
Power Train
TRANSMISSION SEALS FAILED.
NHTSA ODI #544275
Mileage unknown · Jan 14, 1997
Power Train
TRANSMISSION SLIPS DURING ACCELERATION.
NHTSA ODI #513920
Mileage unknown · Sep 6, 1996
Power TrainFire
TRANSMISSION DOWNSHIFTED SUDDENLY, CAUSING FIRE.
NHTSA ODI #508395
Mileage unknown · May 1, 1996
Power TrainFire
WHILE DRIVING, VEHICL SUDDENLY LURCHED, THEN NOTICED BURNING TRANS. FLUID SMELL AND SMOKE COMING FROM GRILL, OPENED HOOD FOUND ENGINE ENGULFED IN FLAMES. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Consequence & remedy
Consequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME POSITION.
Consequence & remedy
Consequence: IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.
Remedy: DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.
THE THIRD ROW SAFETY BELT RETRACTORS MAY BE INSTALLED INCORRECTLY AND MAY LOCK-UP WHEN THE VEHICLE IS ON SLOPES OF LESS THAN 15 DEGREES, WHICH DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: PASSENGERS SEATED IN THESE POSITON MAYBE UNABLE TO EXTRACT AND FASTEN THEIR SEAT BELTS UNTIL THE VEHICLE IS MOVED TO A MORE LEVEL SURFACE. UNBELTED OCCUPANTS ARE MORE AT RISK OF INJURY IN THE EVENT OF A COLLISION THAN THOSE USING SAFETY BELTS.
Remedy: DEALERS WILL REMOVE THIRD ROW SAFETY BELT RETRACTORS AND REINSTALL THEM PROPERLY.
THE SAFETY BELT RETRACTORS FOR THE REAR CENTER POSITION ARE MISSING A PAWL SPRING AND IN CASE OF AN ACCIDENT, WILL ALLOW THE SAFETY BELT WEBBING TO EXTEND BEYOND THE MINIMUM REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF AN ACCIDENT THE SAFETY BELT WOULD NOTRESTRAIN THE OCCUPANT, SUBJECTING THE OCCUPANT TO INCREASED RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT RETRACTOR ASSEMBLY AND REPLACE THE RETRACTOR IF THE PAWL SPRING IS MISSING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE95062 · Passenger Side Dash Fires
Opened Dec 9, 1995 · Closed Apr 10, 1996
Status: closed (inferred from source dates) · Electrical System:wiring
There is no summary currently available
PE94070 · Trnsaxl Oil Hose Separates
Opened Sep 15, 1994 · Closed Jan 18, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
1994 Pontiac Trans Sport Problems, Complaints & Recalls | Skip That Year
Illustration