Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 76 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seat Belts. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports2 fire reports1 injury reports
What owners actually said
76 reports
120,000 miles · Mar 16, 2008
EquipmentPower TrainService Brakes, Hydraulic
I AM ASE CERTIFIED IN BRAKES STEERING AND SUSPENSION. MY 1992 PONTIAC TRANSPORT HAS DEVELOPED NUMEROUS PROBLEMS. ONE ( BRAKES WILL FAIL TO ENGAGE FOR NO APPARENT REASON WITH VIBRATION IN THE PEDAL. DOES NOT DO THIS ALL THE TIME ONLY FREQUENTLY. AND TWO. IT ALSO WILL VIOLENTLY START SHUTTERING AT SPEEDS OF 40 TO 60 MPH. I HAVE R…
Read full complaint
I AM ASE CERTIFIED IN BRAKES STEERING AND SUSPENSION. MY 1992 PONTIAC TRANSPORT HAS DEVELOPED NUMEROUS PROBLEMS. ONE ( BRAKES WILL FAIL TO ENGAGE FOR NO APPARENT REASON WITH VIBRATION IN THE PEDAL. DOES NOT DO THIS ALL THE TIME ONLY FREQUENTLY. AND TWO. IT ALSO WILL VIOLENTLY START SHUTTERING AT SPEEDS OF 40 TO 60 MPH. I HAVE REPLACED BOTH BALL JOINTS, BOTH TIE RODS(INNER AND OUTER), BOTH WHEEL BEARINGS, ALL 4 STRUTS AND MOUNTS, BOTH ROTORS, TRANS VACUUM SHIFT MODULE, TRANS COOLER LINES, ENTIRE REAR BRAKE SYSTEM, ALL LINES (STEEL AND RUBBER) RADIATOR AND BOTH CV SHAFTS. I AM TIRE OF PUTTING MONEY INTO THIS PIT AND IT DIDN'T EVEN HAVE 100,000 MILES ON IT WHEN IT STARTED AND I HAVE INVESTED OVER $3,000.00 IN REPAIRS. THIS IS RIDICULOUS WHEN THIS VERY SAME REPORT HAS BEEN MADE IN NUMEROUS OCCASIONS AND PONTIAC WILL NOT FIX THE PROBLEM THAT IS A COMMON OCCURRENCE AND SHOULD BE A RECALL OF WHAT EVER IS CAUSING THE PROBLEM. *TR
NHTSA ODI #10221360
Mileage unknown · Jan 26, 2004
Electrical System
THE WIRING HARNESS THAT FEEDS THE WINDSHIELD WIPERS, HVAC BLOWER MOTOR AND OTHER THINGS IS MELTING & SHORTING OUT. I FIND WHEN I LOOK IN SALVAGE YARDS FOR THIS ITEM, ALL THE ONES THAT WOULD FIT THIS VEHICLE ARE MELTED IN THE SAME WAY. THEREFORE, THIS MUST BE A MANUFACTURERS DEFECT AND SHOULD BE REPLACED. *LA
NHTSA ODI #10054944
80,000 miles · Jan 15, 2004
Seat Belts
I HAVE HAD TO REPLACE 4 OF THE 6 SEAT BELT RETRACTORS SINCE JULY OF 2000. THE FAILURE MODE IS THE RETRACTOR SPRING BREAKING OR PULLING OUT OF SEATBELT MOUNTING SHAFT. EACH REPLACEMENT RETRACTOR COSTS $130. REPLACEMENT PARTS LOOK LIKE THEY WILL FAIL IN THE SAME MANNER, VERY POOR DESIGN.
NHTSA ODI #10069296
Mileage unknown · Oct 23, 2003
Steering
WHILE DRIVING AT APPROXIMATELY 40 MPH STEERING BROKE. THE STEERING WHEEL WOULD MOVE FREELY BUT WOULD NOT CONTROL THE MOVEMENT OR DIRECTION OF THE VEHICLE.*AK
NHTSA ODI #10044635
15,000 miles · Sep 23, 2003
SteeringStructureCrash
WHILE PULLING OUT OF THE DRIVEWAY STEERING UNIT FAILED, CAUSING THE CONSUMER TO LOSE STEERING POWER, AND VEHICLE FELL INTO A DITCH. TWO MAJOR BOLTS HOLDING THE FRONT END OF THE CHASSIS BROKE LOOSE, CAUSING THE STEERING TO COLLAPSE. VEHICLE WAS TOTALED. MANUFACTURER AND THE DEALER WERE NOTIFIED. *AK
NHTSA ODI #10040447
150,000 miles · Sep 10, 2003
Visibility
WINDSHIELD WIPERS WORK INTERMITTENTLY. WINDSHIELD WIPERS WORK MOSTLY WHEN WEATHER IS WARM, PER CONSUMER.*AK
NHTSA ODI #10039700
Mileage unknown · Sep 3, 2002
Wheels
WHILE DRIVING, THE STUDS ON THE RIGHT FRONT TIRE BROKE, CAUSING THE TIRE AND RIM TO COME OFF.(OHIO TRAFFIC CRASH REPORT)*JB
NHTSA ODI #567271
Mileage unknown · Jun 17, 2002
Engine And Engine Cooling
ENGINE MOUNT BOLTS RUSTED, AND BROKE CAUSING LOSS OF STEERING WHILE DRIVING.*AK *YH
NHTSA ODI #8011965
Mileage unknown · May 17, 2002
Visibility
SAME SYMPTOMS & CAUSE AS 98V150001. INTERMITTENT, RANDOM FAILURES EXTREMELY DANGEROUS - ALMOST CAUSED AN ACCIDENT. SOLDER JOINTS AT CONNECTOR CRACKED. RETENTION TABS ON CONNECTOR ARE SMOOTH TAPER & DO NOT CLIP TO THE PCB. LEADS ARE INSERTED STRAIT - SHOULD BE CRIMPED OVER. NO MECHANICAL SUPPORT PROVIDED AGAINST UP & DOWN FO…
Read full complaint
SAME SYMPTOMS & CAUSE AS 98V150001. INTERMITTENT, RANDOM FAILURES EXTREMELY DANGEROUS - ALMOST CAUSED AN ACCIDENT. SOLDER JOINTS AT CONNECTOR CRACKED. RETENTION TABS ON CONNECTOR ARE SMOOTH TAPER & DO NOT CLIP TO THE PCB. LEADS ARE INSERTED STRAIT - SHOULD BE CRIMPED OVER. NO MECHANICAL SUPPORT PROVIDED AGAINST UP & DOWN FORCES ON SOLDER JOINTS. 1994 CHEVROLET LUMINA APV ALSO SHOWING SYMPTOMS. WIPER CIRCUIT BOARD: ASM 22101626 PCB 22122142 REV.A MFG=DELCO PRODUCTS. *AK
NHTSA ODI #762020
Mileage unknown · Sep 5, 2001
Tires
WHILE DRIVING ON INTERSTATE, THE LEFT FRONT TIRE BLEW OUT, CAUSING DAMAGE TO THE UNDERCARRIAGE OF VEHICLE.*JB(OHIO TRAFFIC CRASH REPORT #10-91-392) NO TIRE INFO GIVEN.
VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Consequence & remedy
Consequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
VEHICLE FAILS TO CONFORM TO FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE SAFETY BELT OF THE LEFT THIRD ROW SEAT ON THE SIX PASSENGER VAN AND THE CENTER SECOND ROW SEAT OF THE SEVEN PASSENGER VAN MAY LOCK UP AND CANNOT BE WITHDRAWN FROM THE RETRACTOR.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANTS OF THESE SEATS WILL NOT BE ABLE TO USE THE AFFECTED BELT. IN THE EVENT OF A VEHICLE CRASH, UNBELTED OCCUPANTS ARE AT INCREASED RISK OF INJURY.
Remedy: OWNERS ARE BEING ASKED TO INSPECT THEIR VEHICLES TO DETERMINE IF THE SUSPECT RETRACTOR EXHIBITS A LOCKUP CONDITION. BASED ON THIS INSPECTION, DEALERS WILL REPLACE THE SAFETY BELTS IF THE BELT LOCKS UP. REPLACEMENT OF THE SUSPECT SAFETY BELT WILL BE AVAILABLE TO CONSUMERS FOR THE LIFE OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
RQ03003 · Engine Cradle Separation
Opened Jan 8, 2003 · Closed Apr 10, 2003
Status: closed (inferred from source dates) · Structure:frame And Members
IN APRIL 1997, GM NOTIFIED ODI OF A REAR ENGINE CRADLE BOLT DEFECT IN CERTAIN MODEL YEAR (MY) 1990-91 U VANS AND MY 1988-91 W CARS THAT COULD RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR.GM IDENTIFIED THE PROBLEM AS EXCESSIVE CREVICE CORROSION OF THE ENGINE CRADLE RETAINER AFTER YEARS OF EXPOSURE IN A SEVERE CORROSIVE ENVIRONMENT.THE RECALL COVERED APPROXIMATELY 680,000 VEHICLES REGISTERED IN 14 RUST BELT STATES; INCLUDING ALMOST 70,000 MY 1990-91 U VANS.THE RECALLED VEHICLES RECEIVED NEW REAR CRADLE BOLTS AND RETAINERS. GM CHANGED THE MATERIAL COMPOSITION OF THE RETAINERS IN THE MY 1992 U VANS TO PROVIDE IMPROVED CORROSION RESISTANCE.THE MY 1992 RETAINERS ARE ALUMINIZED STEEL WITH A 2.5 MM PROTECTIVE COATING OF ZINC/CHROMATE ORGANIC.THERE HAVE BEEN ONLY FIVE (5) FAILURES IDENTIFIED IN THE SUBJECT VEHICLES AFTER MORE THAN 10 YEARS OF EXPOSURE.BASED ON THE LOW FAILURE RATE AND THE AGE OF THE VEHICLES, THERE IS NO EVIDENCE OF A SAFETY DEFECT TREND IN THE SUBJECT VEHICLES. THIS RECALL QUERY IS CLOSED.
PE96002 · Front Brake Hose Failure
Opened Jan 5, 1996 · Closed Apr 16, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94070 · Trnsaxl Oil Hose Separates
Opened Sep 15, 1994 · Closed Jan 18, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA92035 · Apv Fuel Line Fires
Opened Oct 30, 1992 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES
PE92052 · Apv Fuel Line Fires
Opened Jun 4, 1992 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1992 Pontiac Trans Sport Problems, Complaints & Recalls | Skip That Year
Illustration