DT: THE CONTACT WAS SLOWING DOWN TO MAKE A TURN WHEN THE ENGINE CRADLE MALFUNCTIONED DUE TO RUST. THE ENGINE AND TRANSMISSION NEARLY FELL OUT OF THE VEHICLE. WHEN THIS HAPPENED THE STEERING LINKAGE DISCONNECTED AND THE STEERING WHEEL KEPT TURNING AROUND. THE VEHICLE HAS NOT BEEN REPAIRED. HE CONTACTED GM, AND THEY OFFERED NO FR…
Read full complaint
DT: THE CONTACT WAS SLOWING DOWN TO MAKE A TURN WHEN THE ENGINE CRADLE MALFUNCTIONED DUE TO RUST. THE ENGINE AND TRANSMISSION NEARLY FELL OUT OF THE VEHICLE. WHEN THIS HAPPENED THE STEERING LINKAGE DISCONNECTED AND THE STEERING WHEEL KEPT TURNING AROUND. THE VEHICLE HAS NOT BEEN REPAIRED. HE CONTACTED GM, AND THEY OFFERED NO FREE REMEDY TO THE PROBLEM. THERE WAS A RECALL ON THIS PROBLEM PREVIOUSLY. HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
NHTSA ODI #10141270
Mileage unknown · Dec 18, 1998
Engine And Engine CoolingSteering
WHILE MECHANIC WAS TEST DRIVING VEHICLE HE STEPPED ON THE BRAKES AND HEARD A BIG NOISE BEFORE THE CRADLE BOLT CAME APART AND ENGINE COLLAPSED. DEALER WAS CONTACTED. *AK
NHTSA ODI #832492
Mileage unknown · Jul 25, 1997
Steering
RECEIVED NOTICE (#97V058000) & CALLED DEALER FOR APPOINTMENT, INFORMED BY MECHANIC PARTS ON BACK ORDER. DEALER SAID MANUFACTURER ONLY SENDING 2 PARTS TO EACH DEALER. DOES NOT KNOW WHEN CONSUMER'S VEHICLE WILL BE FIXED. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
THE GLOVE COMPARTMENT DOOR WILL NOT REMAIN CLOSED DURING CERTAIN LOAD FORCES ASSOCIATED WITH A VEHICLE CRASH. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 201.
Consequence & remedy
Consequence: IN THE EVENT OF AN ACCIDENT, THE GLOVE COMPARTMENT DOORMAY OPEN AND RESULT IN OCCUPANT(S) INJURIES FROM CONTACT WITH THE GLOVECOMPARTMENT DOOR.
Remedy: REPLACE THE CURRENT UPPER GLOVE COMPARTMENT DOOR WITH A REDESIGNED UPPER GLOVE COMPARTMENT DOOR WHICH INCORPORATES A POSITIVE LATCH TO KEEP THE DOOR CLOSED SHOULD A VEHICLE CRASH OCCUR.
A RIGHT HAND SEAT/SHOULDER BELT RETRACTOR MAY HAVE BEEN INSTALLED IN THE SECOND ROW LEFT HAND SEAT POSITION (DIRECTLY BEHIND DRIVER).
Consequence & remedy
Consequence: THE INCORRECT RETRACTOR MAY CAUSE THE BELTS TO LOCK UPIF THE VAN IS PARKED ON A STEEP GRADE. AS A RESULT OF THIS, THE OCCUPANT COULDNOT EXTEND THE BELT FOR USE.
THE REAR MODULAR SEAT FRAME HOLD-DOWN HOOKS MAY NOT MEET THE REQUIRED PULL FORCE AT THE REAR SET ANCHORAGE.
Consequence & remedy
Consequence: VEHICLES WOULD NOT CONFORM TO FMVSS 207.
Remedy: REPLACE REAR HOLD DOWN HOOKS AND PIVOT RIVETS WITH HEAT TREATED HARDWARE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ99002 · Engine Cradle Separation
Opened Mar 4, 1999 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine
ON APRIL 1, 1997, GENERAL MOTORS CORPORATION FILED A DEFECT INFORMATION REPORT TO RECALL THE SUBJECT VEHICLES, REGISTERED IN 14 HIGH CORROSION STATES, TO REPLACE THE REAR ENGINE CRADLE BOLTS AND RETAINERS.THE REAR ENGINE CRADLE BOLTS WOULD EITHER FRACTURER OR PULL THROUGH THE RETIANERS DUE TO CORROSION.AS OF SEPTEMBER 1998, THE SIXTH QUARTER, 59.3% OF THE SUBJECT VEHICLES HAD BEEN REPAIRED.IN ADDITION TO THE COMPLAINTS OF FRONT ENGINE CRADLE BOLT FAILURES IN THE ABOVE FAILURE REPORT SUMMARY, ODI HAS RECEIVED SIX REPORTS OF POSSIBLE FRONT ENGINE CRADLE BOLT FAILURES, INCLUDING TWO CRASHES.AN RQ IS WARRANTED TO DETERMINE THE EXTENT OF FAILURES OF THE FRONT ENGINE CRADLE BOLTS AND RETAINERS ON THE SUBJECT VEHICLES.
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
EA97019 · Front Seat Back Collapse
Opened Sep 30, 1997 · Closed Jun 8, 1999
Status: closed (inferred from source dates) · Seats
ALLEGED FRONT SEAT BACK COLLAPSE DUE TO RECLINER BOLT
PE97016 · Front Seat Back Collapse
Opened Apr 7, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Seats
SUBJECT VEHICLES ARE ALLEGED TO EXPERIENCE INADVERTENT FRONT SEAT BACK COLLAPSE DUE TO FRACTURE OF FRONT SEAT RECLINER MOUNTING BOLTS.
PE96065 · Alleged Engine Subframe Mount/insulator
Opened Nov 15, 1996 · Closed Apr 8, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
ALLEGED FAILURES OF ENGINE FRAME INSULATORS/MOUNTS TO UNIBODY FRAME MAY ALLOW SEPARATION OF ENGINE SUBFRAME, RESULTING IN COMPROMISE OR LOSS OF STEERING CONTROL WITH THE VEHICLE IN MOTION.
EA92035 · Apv Fuel Line Fires
Opened Oct 30, 1992 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES
PE92052 · Apv Fuel Line Fires
Opened Jun 4, 1992 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1990 Pontiac Trans Sport Problems, Complaints & Recalls | Skip That Year
Illustration