THE 2003 PONTIAC SUNFIRE IS AN INFERIOR CAR. MINE CURRENTLY HAS APPROX 57,000 MILES ON THE ODOMETER. THE DAY AFTER I PURCHASED IT BRAND NEW, IT WOULD NOT START. THE DEALER CAME OUT AND REPLACED THE BATTERY. THE CAR HAD WHITE PAINT OVERSPRAY ON IT. THE DEALER REPAINTED IT. THE SUNROOF MALFUNCTIONED AND THE DEALER FIXED IT. THE TU…
Read full complaint
THE 2003 PONTIAC SUNFIRE IS AN INFERIOR CAR. MINE CURRENTLY HAS APPROX 57,000 MILES ON THE ODOMETER. THE DAY AFTER I PURCHASED IT BRAND NEW, IT WOULD NOT START. THE DEALER CAME OUT AND REPLACED THE BATTERY. THE CAR HAD WHITE PAINT OVERSPRAY ON IT. THE DEALER REPAINTED IT. THE SUNROOF MALFUNCTIONED AND THE DEALER FIXED IT. THE TURN SIGNALS KEPT GOING OUT & IT WAS FIXED DUE TO THE RECALL. THE DASH HAD TO BE TAKEN OUT DUE TO THE FACT THAT THE AIR WAS NOT COMING OUT OF THE VENTS PROPERLY. THE POWER WINDOW DRIVER'S SIDE FAILED COMPLETELY AROUND 38,000 MILES & PASSENGER INTERMITTENTLY WOULD NOT WORK. THIS WAS FIXED AT MY EXPENSE. THE CAR HAS BEEN IN THE SHOP FOR BRAKE PROBLEMS NUMEROUS TIMES. I HAD THE DEALER CHECK THEM SEVERAL TIMES WHILE STILL UNDER WARRANTY AND THEY FINALLY REPLACED THEM AT THEIR COST BECAUSE THEY SAID IT SHOULD NOT BE NECESSARY GIVEN THE MILEAGE ON THE CAR. I'VE HAD BRAKES REPLACED TWO OTHER TIMES AT MY EXPENSE AND THEY ARE STILL SQUEAKING AND CREAKING VERY LOUDLY AND I'M TOLD THE BRAKE PADS ARE "CRACKED" BUT THAT IT WON'T HURT ANYTHING. NOW, THE NEW PROBLEM IS, THE RADIO QUIT PLAYING FOR 15 MINUTES AFTER THE CAR IS TURNED OFF AND YOU'RE IN IT. WHEN I COME TO A COMPLETE STOP, MY DOME LIGHT AND MAP LIGHTS COME ON AND STAY ON UNTIL I LET OFF THE BRAKE AND ACCELERATE. ALSO, THE HORN NO LONGER HONKS WHEN I LOCK THE CAR WITH THE REMOTE. I'VE HAD IT UP TO HERE WITH THIS CAR BUT CANNOT AFFORD TO GET RID OF IT SINCE I JUST PAID IT OFF IN JULY 2008. I WILL NEVER BUY ANOTHER PONTIAC! *TR
NHTSA ODI #10241013
Mileage unknown · Dec 1, 2004
Air BagsElectrical SystemEngine And Engine Cooling
NUMEROUS OF FAILURES;AIR BAG LIGHT CAME ON AND STAYED ON, CLUTCH STICKS TO FLOOR, CAR DOESN'T WANT TO START. *BF THE TURN SIGNALS AND LIGHTS HAD GONE OUT, IT WOULD TAKE A COUPLE OF ATTEMPTS TO START THE VEHICLE, THERE WERE TIMES WHERE THE VEHICLE WOULD START ON IT'S OWN WITHOUT THE TURN OF THE KEY, THE VEHICLE USED AN EXTREM…
Read full complaint
NUMEROUS OF FAILURES;AIR BAG LIGHT CAME ON AND STAYED ON, CLUTCH STICKS TO FLOOR, CAR DOESN'T WANT TO START. *BF THE TURN SIGNALS AND LIGHTS HAD GONE OUT, IT WOULD TAKE A COUPLE OF ATTEMPTS TO START THE VEHICLE, THERE WERE TIMES WHERE THE VEHICLE WOULD START ON IT'S OWN WITHOUT THE TURN OF THE KEY, THE VEHICLE USED AN EXTREME AMOUNT OF GAS, THE DASH WOULD RATTLE, THE ENGINE WOULD GROWL, THE DASH MADE A SOUND LIKE THE SPEAKER WAS BLOWN, THERE WAS A BURNING SMELL IN THE STEREO AND THERE WAS A THUMPING NOISE WHEN TURNING THE VEHICLE. (2003 PONTIAC SUNFIRE) *SC
NHTSA ODI #10109784
Mileage unknown · Jan 29, 2004
Electrical SystemEngine And Engine CoolingExterior Lighting
REAR SEAT IS BROKEN RUNK LATCH IS BROKEN. WARRANTY WAS NOT HONORED. *AK
ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA04028 · Turn Signal Malfunction
Opened Sep 14, 2004 · Closed Nov 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON MAY 14, 2004 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-043) BASED ON CONSUMER COMPLAINTS ALLEGING THAT THE BRAKE/TAIL TURN SIGNAL LAMPS WOULD NOT OPERATE PROPERLY WHEN EITHER THE TAIL LIGHTS WERE TURNED ON, THE BRAKE PEDAL WAS DEPRESSED, OR WHEN THE TURN SIGNAL SWITCH WAS ACTIVATED.ON SEPTEMBER 14, 2004 ODI UPGRADED PE 04-043 TO AN ENGINEERING ANALYSIS (EA04-028).GM STATES THAT SOME BRAKE/TAIL/TURN SIGNAL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO EXCESSIVE HEAT BUILDUP WITHIN THE BULB SOCKETS.THE CAUSE OF THE EXCESSIVE HEAT BUILD UP WAS DETERMINED TO BE A LACK OF THERMAL GREASE PLACED IN BETWEEN THE BULB AND THE SOCKET. BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V524) COVERING ALL MY 2003 VEHICLES.GM DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY THERMAL GREASE TO THEM OR REPLACE THEM WITH NEW ASSEMBLIES WITH THERMAL GREASE ALREADY ATTACHED.MODEL YEAR 2004 AND NEWER VEHICLES HAVE THE THERMAL GREASE INSTALLED FROM THE FACTORY. THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04043 · Turn Signal Malfunction
Opened May 14, 2004 · Closed Sep 14, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
COMPLAINANTS ALLEGE THAT THE REAR TURN SIGNALS FAIL TO ILLUMINATE AND DO NOT PROVIDE A SIGNAL TO DRIVERS IN FOLLOWING VEHICLES.ODI HAS RECEIVED ONE REPORT OF A CRASH WHERE THE COMPLAINANT BRAKED AND ATTEMPTED TO MAKE A LEFT TURN AND THE FOLLOWING VEHICLE IMPACTED THE COMPLAINANT'S VEHICLE IN THE DRIVER-SIDE DOOR.IN MAY 2002, GM'S SUPPLIER MADE CHANGES TO THE BULB SOCKET THAT INCLUDED STOPPING THE USE OF THERMAL-MASTIC GREASE IN THE BULB SOCKET.GM REPORTS THAT THE GREASE REDUCES ARCING AT THE CONTACTS AND DISSIPATES HEAT THUS PREVENTING MELTING OF THE SOCKET MATERIAL OR BURNING OF THE CONTACTS.MOST OF THE SUBJECT VEHICLES WERE PRODUCED WITHOUT GREASE APPLIED TO THE BULB SOCKET.IN JUNE 2003, GM DIRECTED THE SUPPLIER TO RESUME THE USE OF GREASE IN THE SOCKET.GM ISSUED TECHNICAL SERVICE BULLETIN (TSB) 04-08-42-004A ON JULY 15, 2004 ADVISING TECHNICIANS TO MAKE SURE THAT ADEQUATE AMOUNTS OF GREASE WERE ADDED TO THE BULB SOCKETS ON ALL SERVICE PARTS.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-028 TO FURTHER EXAMINE THE ISSUE.
2003 Pontiac Sunfire Problems, Complaints & Recalls | Skip That Year
Illustration