NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
235 reports135,600 miles · Nov 18, 2016
SteeringSuspensionWheels
THE REAR PASSENGER SUSPENSION SYSTEM HAS FAILED AND THE TIRE IS SITTING ON THE TIRE-WELL. THE FRAME APPEARS TO BE LOOSE DUE TO RUST AND HAS CAUSED THE SPRING COIL TO POP OUT AND WOBBLE UNCONTROLLABLY. I WAS DRIVING WHEN THIS INCIDENT OCCURRED AND IT WOULD BEGIN TO "FISH TAIL" AROUND 40MPH OR WHEN I WOULD HIT BUMPS, MAKE TURNS…
Read full complaint
THE REAR PASSENGER SUSPENSION SYSTEM HAS FAILED AND THE TIRE IS SITTING ON THE TIRE-WELL. THE FRAME APPEARS TO BE LOOSE DUE TO RUST AND HAS CAUSED THE SPRING COIL TO POP OUT AND WOBBLE UNCONTROLLABLY. I WAS DRIVING WHEN THIS INCIDENT OCCURRED AND IT WOULD BEGIN TO "FISH TAIL" AROUND 40MPH OR WHEN I WOULD HIT BUMPS, MAKE TURNS OR SWITCH LANES.
NHTSA ODI #10926987
96,700 miles · Apr 8, 2014
Air BagsPower Train
AIRBAG LIGHT CAME ON AND TRANSMISSION SHIFT LEVER MOVES BUT DOES NOT ENGAGE TRANSMISSION. *TR
NHTSA ODI #10578368
260,375 miles · Feb 4, 2013
Air BagsCrash
I HAD AN ACCIDENT WHERE A CAR FISH TAILED IN FRONT OF ME SLID DIRECTLY IN FRONT OF MINE. I HIT THE OTHER CAR WHILE GOING 40 MPH, IT WAS A T*BONE COLLISION. MY FRONT AIR BAGS DEPLOYED AT THE TIME OF COLLISION. AFTER GETTING OUT OF THE VEHICLE I NOTICED THAT THE PASSENGER SIDE AIR BAG WAS LAYING IN THE FRONT PASSENGER SEAT WITH TH…
Read full complaint
I HAD AN ACCIDENT WHERE A CAR FISH TAILED IN FRONT OF ME SLID DIRECTLY IN FRONT OF MINE. I HIT THE OTHER CAR WHILE GOING 40 MPH, IT WAS A T*BONE COLLISION. MY FRONT AIR BAGS DEPLOYED AT THE TIME OF COLLISION. AFTER GETTING OUT OF THE VEHICLE I NOTICED THAT THE PASSENGER SIDE AIR BAG WAS LAYING IN THE FRONT PASSENGER SEAT WITH THE AIR BAG STILL INFLATED. I DO REMEMBER THAT FOR A LONG TIME BEFORE TODAY THE RED AIRBAG LIGHT WAS ON. I THOUGHT THIS WOULD CAUSE THE AIR BAGS NOT TO WORK. I DO HAVE PICTURES OF THE DAMAGE, AND THE DEFECT WITH THE AIR BAG. *TR
NHTSA ODI #10496406
168,000 miles · Jun 4, 2012
Engine And Engine Cooling
IT SEEMS THAT THE THIS PARTICULAR MAKE AND MODEL HAS KNOWN PROBLEMS WITH THE COOLING SYSTEM. ON A FAMILY TRIP TO VIRGINIA THE CAR STARTED TO OVERHEAT AND I STOPPED THE VEHICLE. WHEN PARKED RED FLUID WAS VISIBLE UNDER THE CAR AND UPON TESTING WAS FOUND OUT TO BE COOLANT LEAK. CAR WAS TOWED TO PA AND MECHANIC REPORTED LOSS AND REP…
Read full complaint
IT SEEMS THAT THE THIS PARTICULAR MAKE AND MODEL HAS KNOWN PROBLEMS WITH THE COOLING SYSTEM. ON A FAMILY TRIP TO VIRGINIA THE CAR STARTED TO OVERHEAT AND I STOPPED THE VEHICLE. WHEN PARKED RED FLUID WAS VISIBLE UNDER THE CAR AND UPON TESTING WAS FOUND OUT TO BE COOLANT LEAK. CAR WAS TOWED TO PA AND MECHANIC REPORTED LOSS AND REPLACEMENT OF RADIATOR/HOSES AND LOWER INTAKE MANIFOLD (GASKET) A LABOR INTENSIVE WORK COSTING ABOUT 1700 TO FIX ALL THE ISSUE WITH THIS OVER HEATING. *TR
NHTSA ODI #10460448
Mileage unknown · Feb 16, 2011
Electrical SystemExterior Lighting
ELECTRICAL COMPONENTS AND REAR LIGHT FAILURE INCLUDING BREAKS AN TURN SIGNALS.*TR
NHTSA ODI #10383023
160,000 miles · Jan 22, 2011
Engine And Engine Cooling
1. EVENTS UNKNOWN 2. COOLING SYSTEM FAILURE, ALL THE TIME, UNDRIVEABLE 3. UNABLE TO CORRECT FAILURE. *TR
NHTSA ODI #10378277
178,280 miles · Jul 28, 2010
Electrical SystemExterior LightingService Brakes, Electric
FIRST THE DRIVER'S SIDE WINDOW STOPPED WORKING, THEN THE TAIL LIGHTS JUST WENT OUT ON THE 99 PONTIAC MONTANA. THEY WERE JUST WORKING AND THEN ON MY WAY HOME THEY JUST STOPPED WORKING. I REPLACED ALL BULBS AND THEY STILL AREN'T WORKING. WENT TO SEE A TECHNICIAN AND HE SAYS IT IS AN ELECTRICAL PROBLEM. AFTER THAT THE RADIO DISPLAY…
Read full complaint
FIRST THE DRIVER'S SIDE WINDOW STOPPED WORKING, THEN THE TAIL LIGHTS JUST WENT OUT ON THE 99 PONTIAC MONTANA. THEY WERE JUST WORKING AND THEN ON MY WAY HOME THEY JUST STOPPED WORKING. I REPLACED ALL BULBS AND THEY STILL AREN'T WORKING. WENT TO SEE A TECHNICIAN AND HE SAYS IT IS AN ELECTRICAL PROBLEM. AFTER THAT THE RADIO DISPLAY FLICKERS IN AND OUT WHEN THE BRAKE IS PUSHED ON. I'VE SEARCHED TO SEE IF I COULD FIND AN ANSWER AS TO WHY THIS HAPPENED AND THERE ARE MANY WEBSITES WITH THE SAME COMPLAINTS AS I HAVE STATED HERE WITH THE SAME PROBLEMS. *TR
NHTSA ODI #10345982
113,000 miles · Dec 21, 2008
Engine And Engine CoolingFire
VEHICLE SPONTANEOUSLY CAUGHT FIRE WHILE STUCK IN SNOW DRIFT. FIRE WAS ALL CONSUMING - FIRE TRUCK HAD TO COME OUT IT OUT - JUST SHELL OF VAN WAS LEFT. WE WERE ABLE TO GET OUT AS FIRE WAS SLOW TO TAKE OFF. FIRE STARTED IN ENGINE COMPARTMENT. FIRE CHIEF SAID WE WOULD NEVER KNOW CAUSE AS NO ENGINE COMPARTMENT REMAINS. *TR
NHTSA ODI #10252473
105,455 miles · Aug 10, 2008
Electrical SystemCrash
DEALER SOLD ME A PONTIAC MONTANA MINIVAN AND I ONLY HAD IT FOR 2 WEEKS, AND IT WON'T START, IT HAD A CARFAX REPORT THAT SAID IT WAS IN A CAR ACCIDENT, THIS WAS NOT TOLD OR REVEALED TO ME BY THE DEALER. NOW I AM STRANDED WITHOUT A CAR TO GET AROUND AND NO WARRANTY WAS GIVEN. I ASK FOR A WARRANTY THE SALESMAN SAID IT ONLY COMES WI…
Read full complaint
DEALER SOLD ME A PONTIAC MONTANA MINIVAN AND I ONLY HAD IT FOR 2 WEEKS, AND IT WON'T START, IT HAD A CARFAX REPORT THAT SAID IT WAS IN A CAR ACCIDENT, THIS WAS NOT TOLD OR REVEALED TO ME BY THE DEALER. NOW I AM STRANDED WITHOUT A CAR TO GET AROUND AND NO WARRANTY WAS GIVEN. I ASK FOR A WARRANTY THE SALESMAN SAID IT ONLY COMES WITH FINANCING. *TR
NHTSA ODI #10237574
81,718 miles · Aug 8, 2008
Engine And Engine Cooling
TWO SEPARATE GASKET PROBLEMS ON MY 1999 PONTIAC MONTANA MINI VAN. THE MOST RECENT WAS TODAY IN AUG. OF 2008 THE LOCAL GARAGE TOLD ME THAT MY VANS LOWER INTAKE MANIFOLD GASKET NEEDED REPLACED FOR ABOUT $700. THE PROBLEM WAS NOTICED WHEN MY TEMPERATURE LIGHT CAME ON AND AFTER FILLING RADIATOR I SAW WATER LEAKING UNDERNEATH VEHICLE…
Read full complaint
TWO SEPARATE GASKET PROBLEMS ON MY 1999 PONTIAC MONTANA MINI VAN. THE MOST RECENT WAS TODAY IN AUG. OF 2008 THE LOCAL GARAGE TOLD ME THAT MY VANS LOWER INTAKE MANIFOLD GASKET NEEDED REPLACED FOR ABOUT $700. THE PROBLEM WAS NOTICED WHEN MY TEMPERATURE LIGHT CAME ON AND AFTER FILLING RADIATOR I SAW WATER LEAKING UNDERNEATH VEHICLE. *TR
NHTSA ODI #10237492
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jan 25, 2002
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE DRIVER'S AIR BAG INFLATOR MODULES COULD PRODUCE EXCESSIVE INTERNAL PRESSURE. IN THE EVENT OF A CRASH THAT WOULD TRIGGER A DRIVER'S AIR BAG DEPLOYMENT, THE INCREASED INTERNAL PRESSURE CAN CAUSE THE INFLATOR MODULE TO EXPLODE.
Consequence & remedy
Consequence: METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN FEBRUARY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
RQ00006 · Traction Control
Opened Feb 16, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration