NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
216 reportsClear category filter210,500 miles · Feb 10, 2021
Electrical SystemEngineSteeringFire
NOTE: I HAVE FILED A SAFELY COMPLAINT BEFORE WITH THE NHTSA ABOUT THIS SAFETY ISSUE ON NOV 9, 2020 REFERENCE NUMBER: 11373799. AND NOW DUE TO SAFETY NEGLIGENCE FROM THE INVESTIGATION DEPARTMENT OF THE NHTSA ..EXCESSIVE HEAT COMING FROM THE EXTREMELY HOT OIL THAT'S DRIPPING OFF THE EXTREMELY HOT EXHAUST MANIFOLD THAT'S LEAKING F…
Read full complaint
NOTE: I HAVE FILED A SAFELY COMPLAINT BEFORE WITH THE NHTSA ABOUT THIS SAFETY ISSUE ON NOV 9, 2020 REFERENCE NUMBER: 11373799. AND NOW DUE TO SAFETY NEGLIGENCE FROM THE INVESTIGATION DEPARTMENT OF THE NHTSA ..EXCESSIVE HEAT COMING FROM THE EXTREMELY HOT OIL THAT'S DRIPPING OFF THE EXTREMELY HOT EXHAUST MANIFOLD THAT'S LEAKING FROM THE VALVE COVER STARTED A FIRE UNDER THE HOOD AND ALSO LEAKED INTO THE CYLINDER CAUSING THE PISTON TO SLIT INTO NUMEROUS PIECES THEN VIOLENTLY BEING SHOT BACK AND FORTH STRIKING THE CYLINDER WALLS VIOLENTLY THEN BREAKING THROUGH THE ENGINE BLOCK AND OIL PAN, THEN SPILLING HOT OIL ON THE I-105 HIGHWAY AT HIGH WAY SPEED COMING UP ON A FORK, LOST OIL COMPRESSION AND STALLING OUT WITH HEAVY THICK CAN'T SEE IN MORE THEN 5 FEET IN FRONT OF YOU GREY/BLACK SMOKE COMING FROM BOTH ENDS OF THE VEHICLE. ALMOST COSTED ME MY LIFE
NHTSA ODI #11395511
100,000 miles · Aug 11, 2017
EngineFuel/propulsion SystemSteering
FUEL GAGE DOESNT WORK ALWAYS READS FULL- SHOWS OVER FULL WHEN ITS HOT OUT-OIL AND RADIATOR LEAK- FOLLOWED LAST ENGINE RECALL-NEW RADIATOR HOSES ETC 1250$-AIR BAG? I GOT RECALL WORK DONE LAST YEAR
NHTSA ODI #11014669
130,000 miles · Jan 23, 2013
EngineSteering
TL* THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ENGINE RPMS INCREASED EXCESSIVELY ONCE THE VEHICLE WAS STARTED. IN ADDITION, COOLANT WAS LEAKING FROM THE TAIL PIPE AND THE FRONT END OF THE VEHICLE. THE CONTACT STATED THAT ENGINE OIL WAS ALSO LEAKING FROM THE VEHICLE. THE STEERING WHEEL WOULD ALSO SEIZ…
Read full complaint
TL* THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ENGINE RPMS INCREASED EXCESSIVELY ONCE THE VEHICLE WAS STARTED. IN ADDITION, COOLANT WAS LEAKING FROM THE TAIL PIPE AND THE FRONT END OF THE VEHICLE. THE CONTACT STATED THAT ENGINE OIL WAS ALSO LEAKING FROM THE VEHICLE. THE STEERING WHEEL WOULD ALSO SEIZE SPORADICALLY AND WOULD OFTEN SHAKE WHEN DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INSPECTED THE VEHICLE AND ADVISED THE CONTACT THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V116000 (ENGINE AND ENGINE COOLING), AND NHTSA CAMPAIGN ID NUMBER: 09E005000 (STEERING). THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10494483
180,000 miles · Sep 29, 2011
Steering
TL - THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHEN THE CONTACT ATTEMPTED TO MAKE A LEFT TURN THE VEHICLE MALFUNCTIONED DUE TO THE WHEEL BEARINGS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THAT THE WHEEL BEARINGS FAILED. THE CONTACT STATED PRIOR TO THE FAILURE THE REPAIRS WERE PERFORMED IN 2003 UNDER NHTSA CA…
Read full complaint
TL - THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHEN THE CONTACT ATTEMPTED TO MAKE A LEFT TURN THE VEHICLE MALFUNCTIONED DUE TO THE WHEEL BEARINGS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THAT THE WHEEL BEARINGS FAILED. THE CONTACT STATED PRIOR TO THE FAILURE THE REPAIRS WERE PERFORMED IN 2003 UNDER NHTSA CAMPAIGN ID NUMBER:02V286000 (STEERING:RACK AND PINION). THE MANUFACTURER WAS NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 180,000. RVK
NHTSA ODI #10427902
164,000 miles · Jul 29, 2011
Steering
THE DRIVER RECEIVED A (NHTSA) RECALL NOTICE (02-V-286-000) POWER STEERING WHEEL. THE DEALER'S MECHANIC REPLACED THE BEARING NOT THE RACK AND PINION. ONE MONTH LATER THE DRIVER COMPLAINED THAT THE STEERING WHEEL WAS HARD TO TURN AND THERE WAS A KNOCKING NOISE HEARD COMING FROM UNDERNEATH THE VEHICLE. THE CONSUMER TOOK THE VEHICLE…
Read full complaint
THE DRIVER RECEIVED A (NHTSA) RECALL NOTICE (02-V-286-000) POWER STEERING WHEEL. THE DEALER'S MECHANIC REPLACED THE BEARING NOT THE RACK AND PINION. ONE MONTH LATER THE DRIVER COMPLAINED THAT THE STEERING WHEEL WAS HARD TO TURN AND THERE WAS A KNOCKING NOISE HEARD COMING FROM UNDERNEATH THE VEHICLE. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALER FOR INSPECTION. THE DEALER'S MECHANIC WOULD NOT REPLACE THE PART. *TR
NHTSA ODI #10416292
97,000 miles · Jul 13, 2010
Steering
WE'VE SPENT FAR TOO MUCH MONEY TRYING TO FIX THE PROBLEM WITH OUR PONTIAC GRAND PRIX 1997 POWER STEERING FAILURE TO TURN LEFT WITHOUT EXTREME FORCE. *TR
NHTSA ODI #10342974
140,000 miles · Sep 25, 2009
Steering
THERE IS A RECALL OF 1997 PONTIAC GRAND PRIX #02V286000. RECALL DATE 11-04-2002 FOR ASSEMBLY DATES 1-1-1996 THROUGH 10-31-1997 MY CARS ASSEMBLY DATE IS 8-30-1996. MY CAR HAS THE EXACT CONSEQUENCE OF THIS RECALL. THE RECALL LISTING IS: CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINIO…
Read full complaint
THERE IS A RECALL OF 1997 PONTIAC GRAND PRIX #02V286000. RECALL DATE 11-04-2002 FOR ASSEMBLY DATES 1-1-1996 THROUGH 10-31-1997 MY CARS ASSEMBLY DATE IS 8-30-1996. MY CAR HAS THE EXACT CONSEQUENCE OF THIS RECALL. THE RECALL LISTING IS: CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE. CONSEQUENCE: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR. I TOOK THE CAR TO A REGULAR SHOP AND THE MECHANIC THERE USE TO BE A GM MACHANIC AND HE SAID I HAVE THE EXACT CAUSE OF THE RECALL PROBLEM. AND CAN'T BELIVE THAT GM WILL NOT COVER THIS CAR. ALL THE SYMPTOMS ARE THE SAME. AND THE BEARINGS ARE GONE FROM THE RACK. *TR
NHTSA ODI #10285243
176,000 miles · Aug 6, 2007
Steering
TL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT HE WAS UNABLE TO TURN HIS STEERING WHEEL WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE RACK AND PINION FAILED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS UNAWARE THAT THERE WAS A RECALL FOR THIS DEFECT, O…
Read full complaint
TL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT HE WAS UNABLE TO TURN HIS STEERING WHEEL WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE RACK AND PINION FAILED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS UNAWARE THAT THERE WAS A RECALL FOR THIS DEFECT, OTHERWISE HE WOULD HAVE TAKEN THE VEHICLE TO AN AUTHORIZED DEALER. THE MANUFACTURER STATED THAT HE WAS NEVER NOTIFIED DUE TO AN INTERNAL ERROR ON THEIR BEHALF. THE DEALER STATED THAT HIS VIN WAS INCLUDED IN RECALL NUMBER 02V286000 (STEERING:RACK AND PINION). BECAUSE THE VEHICLE WAS REPAIRED BY AN INDEPENDENT DEALER/MECHANIC, THE MANUFACTURER WILL NOT REPAIR OR REIMBURSE THE CONTACT, EVEN THOUGH THEY ADMIT TO THEIR INTERNAL ERROR. THE FAILURE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 235,000 AND FAILURE MILEAGE WAS 176,000.
NHTSA ODI #10198656
99,000 miles · Feb 8, 2007
SteeringVisibility
TL* - THE CONTACT CALLED REGARDING A 1997 OLDSMOBILE CUTLASS. THE CONTACT STATED ON FEBRUARY 3, 2007 WHEN SHE ATTEMPTED TO PUT THE VEHICLE IN REVERSE SHE NOTICED THERE WAS NO POWER STEERING, THERE WERE NO WARNING INDICATORS. THE CURRENT AND FAILURE MILEAGE WERE 99,000. THE CONTACT PUT POWER STEERING FLUID IN THE VEHICLE, AND …
Read full complaint
TL* - THE CONTACT CALLED REGARDING A 1997 OLDSMOBILE CUTLASS. THE CONTACT STATED ON FEBRUARY 3, 2007 WHEN SHE ATTEMPTED TO PUT THE VEHICLE IN REVERSE SHE NOTICED THERE WAS NO POWER STEERING, THERE WERE NO WARNING INDICATORS. THE CURRENT AND FAILURE MILEAGE WERE 99,000. THE CONTACT PUT POWER STEERING FLUID IN THE VEHICLE, AND IT ALL LEAKED OUT. THE VEHICLE WAS TOWED TO A MECHANIC. THE CONTACT DID NOT UNDERSTAND WHAT THE MECHANIC SAID NEEDED TO BE REPLACED. THE BLOWER FOR THE HEATER ONLY BLEW COLD AIR. THIS HAS BEEN HAPPENING SINCE FEBRUARY2006. SHE HAD IT REPAIRED. HOWEVER, IN MAY 2006 IT FAILED AGAIN. *AK
NHTSA ODI #10181953
22,786 miles · Oct 30, 2006
Steering
DT*: THE CONTACT STATED THE VEHICLE WAS SCHEDULED FOR THE RECALL REPAIR # 02V286000, FOR THE STEERING: RACK AND PINION, AT THE SERVICE DEALER. THE BEARING WAS REPLACED, BUT DUE TO AN UNAVAILABLE TOOL, THE RACK AND PINION WAS NOT REPLACED AS THE CONTACT HAD BEEN INFORMED BY THE SERVICE DEALER. THE RACK AND PINION PROBLEM HAD BE…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE WAS SCHEDULED FOR THE RECALL REPAIR # 02V286000, FOR THE STEERING: RACK AND PINION, AT THE SERVICE DEALER. THE BEARING WAS REPLACED, BUT DUE TO AN UNAVAILABLE TOOL, THE RACK AND PINION WAS NOT REPLACED AS THE CONTACT HAD BEEN INFORMED BY THE SERVICE DEALER. THE RACK AND PINION PROBLEM HAD BECOME A PROBLEM SINCE THE BEARING WAS REPLACED. THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10172135
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Dec 16, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WINDSHIELD WIPERS MAY STOP WORKING DUE TO A SEPARATION BETWEEN THE DRIVE PIN AND CRESCENT IN THE CRANK ARM ASSEMBLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF A PLASTIC WATER DEFLECTOR AND, IF NECESSARY, REPLACE THE WIPER MOTOR CRANK ARM AND INSTALL A WATER DEFLECTOR. ON VEHICLES RECEIVING A REPLACEMENT CRANK ARM AND NEW WATER DEFLECTOR, DEALERS WILL ALSO APPLY ADDITIONAL SEALING MATERIAL TO IMPROVE WATER DEFLECTION AWAY FROM THE CRANK ARM ASSEMBLY AND WILL INSTALL A REINFORCEMENT TO IMPROVE THE PERFORMANCE OF THE WIPER PARK MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration