NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
136 reportsClear category filter63,800 miles · Feb 3, 2003
Engine And Engine Cooling
I PURCHASED MY VEHICLE, 1997 PONTIAC GRAND PRIX ON 5/5/01 WITH 50,768 MILES. I TOOK MY CAR TO THE LOCAL DEALER FOR A RECALL ON THE FRONT STEERING PINION. I HAD ASKED THEM TO REPLACE THE COOLANT SINCE THE MANUAL CALLED TO REPLACE AT 5 YEARS OR 150,000 MILE. I WAS INFORMED THAT THE INTAKE MANIFOLD WAS LEAKING AND WAS TURNING MY…
Read full complaint
I PURCHASED MY VEHICLE, 1997 PONTIAC GRAND PRIX ON 5/5/01 WITH 50,768 MILES. I TOOK MY CAR TO THE LOCAL DEALER FOR A RECALL ON THE FRONT STEERING PINION. I HAD ASKED THEM TO REPLACE THE COOLANT SINCE THE MANUAL CALLED TO REPLACE AT 5 YEARS OR 150,000 MILE. I WAS INFORMED THAT THE INTAKE MANIFOLD WAS LEAKING AND WAS TURNING MY ANTIFREEZE INTO MUD. I ASKED THE SERVICE MANAGER WHAT CAUSED THE MANIFOLD TO LEAK. HE TOLD ME THAT IT WAS WARPED AND WOULD HAVE TO BE REPLACED. THE COST TO REPLACE IT WOULD BE $400.00. MY CAR HAS APPROXIMATELY 13,000 MILES ON IT SINCE I BOUGHT IT. IT IS MAINLY USED LOCALLY WITH THE LONGEST ROUND TRIP DRIVEN TO DATE AT APPROXIMATELY 100 MILES. I HAVE MY OIL CHANGED AT REGULAR INTERVALS WITH THE DEALER, AND MAINTAIN ALL OTHER FLUIDS, WIPERS ETC. I ASKED THE MANAGER HOW LONG IT WOULD TAKE TO REPLACE THE INTAKE MANIFOLD. HE SAID IT WOULD TAKE LONGER TO FIND ONE THAN REPLACE IT. HE SAID THAT THEY HAVE REPLACED A LOT OF THESE ON THIS ENGINE, AND THEY ARE IN SHORT SUPPLY. I HAVE CHECKED YOUR WEB SITE FOR ANY TYPE OF RECALL AND HAVE FOUND NONE. I DID FIND ONE COMPLAINT REPORT THAT A FIRE HAD OCCURED BECAUSE OF A CRACKED INTAKE MANIFOLD. DO I RUN THE RISK OF A FIRE WITH MY VEHICLE BEFORE THEY REPLACE THE MANIFOLD? ALSO, IF THIS PIECE IS SO PRONE TO FAILURE, WHAT IS CAUSING IT? COULD SOMEONE PLEASE RESPOND BACK TO ME WITH SOME ANSWERS?
NHTSA ODI #10005212
81,232 miles · Dec 21, 2002
Engine And Engine Cooling
ENGINE HAS SHUT DOWN WHILE DRIVING AT VARIOUS SPEEDS WHILE ON A STRAIGHTAWAY OR TURNS. VERY HAZARDOUS SITUATION AS ALL POWER ASSIST IS LOST. ENGINE WILL RESTART IMMEDIATELY BUT NEVER KNOW WHEN POWER LOSS WILL OCCUR. HAVE NOTICED MANY OTHER SIMILAR COMPLAINTS ON THIS WEB SITE. TS
NHTSA ODI #10000335
Mileage unknown · Dec 11, 2002
Engine And Engine Cooling
THE VEHICLE HESITATE WHILE STARTING UP AND BACK FIRED. PLEASE FURNISH ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. MR
NHTSA ODI #8024224
Mileage unknown · Oct 7, 2002
Engine And Engine CoolingEquipmentExterior Lighting
CONSUMER STATES THE VEHICLE'S FRONT HEAD LIGHT LENSES DROPPED AND THE DEALER REPLACED BOTH LAMP ASSEMBLIES. *YH
NHTSA ODI #567744
Mileage unknown · Jun 25, 2002
Electrical SystemEngine And Engine CoolingEquipment
RECALL 99V348000 REPAIRS ON WINDSHIELD WIPERS WERE DONE IN JULY OF 2000, VEHICLE HAS BEEN TAKEN BACK TO DEALER NUMEROUS TIMES. WINDSHIELD WIPERS STOPPED WORKING INTERMITTENTLY.*AK MAP LAMP ASSEMBLY, DOOR LIGHTS, REAR DOOR LENS, GASKET LAMP AND HEADLAMP ASSEMBLY WERE ALL REPLACED, ABS LIGHT ILLUMINATED, DEALER ADJUSTED BRAKE LIG…
Read full complaint
RECALL 99V348000 REPAIRS ON WINDSHIELD WIPERS WERE DONE IN JULY OF 2000, VEHICLE HAS BEEN TAKEN BACK TO DEALER NUMEROUS TIMES. WINDSHIELD WIPERS STOPPED WORKING INTERMITTENTLY.*AK MAP LAMP ASSEMBLY, DOOR LIGHTS, REAR DOOR LENS, GASKET LAMP AND HEADLAMP ASSEMBLY WERE ALL REPLACED, ABS LIGHT ILLUMINATED, DEALER ADJUSTED BRAKE LIGHT SWITCH. BOTH OUTER TIE RODS WERE REPLACED. WINDSHIELD COWL PANEL LEAKED AND WAS REPLACED. STEERING COLUMN WAS REPLACED. SERPENTINE BELT HAS BEEN REPLACED 3 TIMES, VALVE COVER GASKET HAS BEEN REPLACED 2 TIMES, VEHICLE HAS EXPERIENCED 3 OIL LEAKS, OIL PAN AND WATER PUMP WERE REPLACED, A BELT SNAPPED AND HAS NOT YET BEEN REPAIRED. ALTERNATOR HAS BEEN REPLACED 3 TIMES. THE SUPERCHARGER GASKET WAS REPLACED. THE AUTOMATIC SHIFT MECHANISM WAS REPLACED. THE RADIO SKIPS AND THE RADIO MODULE TO THE STEERING COLUMN BROKE. 2 FRONT WHEEL SPEED SENSOR JUMPER WIRING WAS REPLACED. *SLC
NHTSA ODI #8012533
Mileage unknown · May 22, 2002
Engine And Engine Cooling
THE FAN TO RADIATOR DOES NOT WORK AND IT MIGHT CAUSE A FIRE IF THE CAR GETS TO HOT. *AK
NHTSA ODI #762148
Mileage unknown · Apr 23, 2002
Engine And Engine Cooling
WHEN MAKING A LEFT TURN VEHICLE LOCKS UP AND THEN SHUTSDOWN. WAS CAUSED BY FILTER BEING CLOGGED. REPLACED PART, PROBLEM STILL OCCURRING.*AK
NHTSA ODI #8008430
Mileage unknown · Mar 28, 2002
Engine And Engine Cooling
DEALER'S SEVICE MAN STATED THERE IS LEAKAGE FROM THE LOWER AND UPPER INTAKE MANIFOLD GASKETS AND RECOMMENDS REPLACING GASKET AND UPPER MANIFOLD. I DON'T BELIEVE A CAR WITH ONLY 33,000 MILES ON IT SHOULD HAVE A SERIOUS PROBLEM LIKE THIS. THANK YOU FOR YOUR TIME. NLM
NHTSA ODI #759911
Mileage unknown · Feb 20, 2002
Engine And Engine Cooling
SERPENTINE BELT HAD TO BE REPLACED AT DEALER. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8004318
Mileage unknown · Jan 30, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
ENGINE COMPLETELY SHUT OFF WHILE DRIVING, STEERING COLUMN LOCKS, BRAKES BARELY FUNCTIONED. ALTERNATOR REPLACED TWICE. DIAGNOSED WITH SAME PROBLEM. ONCE IN JULY 2001, AGAIN IN AUGUST 2001. SERVICE ENGINE LIGHT COMES ON AGAIN. DRIVES OK NOW, BUT WORRIED IT WILL CONTINUE TO GIVE ME PROBLEMS. IN AND OUT OF SHOP 4 TIMES IN PAST …
Read full complaint
ENGINE COMPLETELY SHUT OFF WHILE DRIVING, STEERING COLUMN LOCKS, BRAKES BARELY FUNCTIONED. ALTERNATOR REPLACED TWICE. DIAGNOSED WITH SAME PROBLEM. ONCE IN JULY 2001, AGAIN IN AUGUST 2001. SERVICE ENGINE LIGHT COMES ON AGAIN. DRIVES OK NOW, BUT WORRIED IT WILL CONTINUE TO GIVE ME PROBLEMS. IN AND OUT OF SHOP 4 TIMES IN PAST YEAR FOR SAME PROBLEM. BACK IN SHOP TODAY FOR WHO KNOWS WHAT.
NHTSA ODI #757539
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Dec 16, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WINDSHIELD WIPERS MAY STOP WORKING DUE TO A SEPARATION BETWEEN THE DRIVE PIN AND CRESCENT IN THE CRANK ARM ASSEMBLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF A PLASTIC WATER DEFLECTOR AND, IF NECESSARY, REPLACE THE WIPER MOTOR CRANK ARM AND INSTALL A WATER DEFLECTOR. ON VEHICLES RECEIVING A REPLACEMENT CRANK ARM AND NEW WATER DEFLECTOR, DEALERS WILL ALSO APPLY ADDITIONAL SEALING MATERIAL TO IMPROVE WATER DEFLECTION AWAY FROM THE CRANK ARM ASSEMBLY AND WILL INSTALL A REINFORCEMENT TO IMPROVE THE PERFORMANCE OF THE WIPER PARK MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration