NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
88 reportsClear category filterMileage unknown · Jul 5, 2001
Electrical SystemEquipment
RADIO FAILURE DISPLAY RANDOMLY CHANGES, CD WILL NOT EJECT WTY REPLACED; WATER PUMP FAILED AT 39000 MILES COST TO REPAIR NOT COVERED UNDER WTY, GM COMP $200 OF $350 REPAIR BILL;BATTERY AND ALTERNATOR FAILED NO INDICATION OF FAILURE UNTIL BATTERY WAS DEAD AND ALTERNATOR NOT CHARGEING THEN THE BATTERY LIGHT AND ABS LIGHT STAYED ON …
Read full complaint
RADIO FAILURE DISPLAY RANDOMLY CHANGES, CD WILL NOT EJECT WTY REPLACED; WATER PUMP FAILED AT 39000 MILES COST TO REPAIR NOT COVERED UNDER WTY, GM COMP $200 OF $350 REPAIR BILL;BATTERY AND ALTERNATOR FAILED NO INDICATION OF FAILURE UNTIL BATTERY WAS DEAD AND ALTERNATOR NOT CHARGEING THEN THE BATTERY LIGHT AND ABS LIGHT STAYED ON AND AS THE BATTERY BECAME WEAKER THE OTHER IDIOT LIGHTS ON THE DASH CAME ON UNTIL THE CAR EVENTUALLY QUIT RUNNING.
NHTSA ODI #747902
Mileage unknown · May 31, 2001
Electrical SystemFire
ELECTRICAL HARNESS CAUGHT ON FIRE. *AK
NHTSA ODI #889445
Mileage unknown · May 15, 2001
Electrical System
ELECTRICAL SYSTEM FAILS ON A REGULAR BASIS. THIS DEFECT RESULTS IN FAILURE OF ALL ELECTRICAL SYSTEMS, AND CAUSES ENGINE TO STALL WHILE VEHICLE IS IN OPERATION. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #888287
Mileage unknown · Apr 23, 2001
Air BagsElectrical System
AIRBAG LIGHT CAME ON. TOOK VEHICLE TO DEALER, WHO STATED THAT A FAULTY WIRING HARNESS HAD DISABLED BOTH AIRBAGS. *AK
NHTSA ODI #886493
Mileage unknown · Apr 23, 2001
Electrical System
WIRING HARNESS THAT PROVIDES ELECTRICITY TO BOTH THE DRIVER SIDE AND PASSENGER SIDE AIRBAGS WITHIN THE DASHBOARD HAD FAILED AS A RESULT OF A HIGH RESISTANCE CONNECTION FAILURE. THE PROBLEM WAS UNCOVERED BY THE DEALER AFTER THE AIRBAG WARNING LIGHT CAME ON. THE DEALER'S MECHANIC STATED THIS DISABLED BOTH AIRBAGS AND THAT HE HAD P…
Read full complaint
WIRING HARNESS THAT PROVIDES ELECTRICITY TO BOTH THE DRIVER SIDE AND PASSENGER SIDE AIRBAGS WITHIN THE DASHBOARD HAD FAILED AS A RESULT OF A HIGH RESISTANCE CONNECTION FAILURE. THE PROBLEM WAS UNCOVERED BY THE DEALER AFTER THE AIRBAG WARNING LIGHT CAME ON. THE DEALER'S MECHANIC STATED THIS DISABLED BOTH AIRBAGS AND THAT HE HAD PERSONALLY REPLACED AT LEAST 20 OF THESE HARNESSES FOR SAME PROBLEM. ANOTHER PERSONAL CONTACT AT ANOTHER PONTIAC DEALER STATED THAT "DOZENS" OF THESE HARNESSES HAVE BEEN REPLACED IN THEIR SHOP. THIS IS AN EXPENSIVE REPAIR OF $400.00 TO REMEDY THE PROBLEM IF NOT UNDER WARRANTY TIMEFRAME. PART HAS SINCE BEEN RE-DESIGNED TO CORRECT HIGH RESISTANCE CONNECTION PROBLEM.*AK
NHTSA ODI #744415
Mileage unknown · Mar 9, 2001
Air BagsElectrical SystemEngine And Engine Cooling
I PURCHASED MY CAR IN FEB OF 2000. IT ONLY HAS APRROX 43000 MILES AND I HAVE HAD NUMEROUS TRIPS TO THE DEALER AND OTHER MECHANICS. IN JUNE OF 2000 I HAD TO TAKE THE CAR IN BECAUSE THE HEADLIGHT COVERS FELL OFF. I HAD NOTICED CONDENSATION WHEN I PURCHASED THE CAR AND WAS TOLD BY THE SALESMAN THAT THIS WAS NORMAL. LUCKILY I FO…
Read full complaint
I PURCHASED MY CAR IN FEB OF 2000. IT ONLY HAS APRROX 43000 MILES AND I HAVE HAD NUMEROUS TRIPS TO THE DEALER AND OTHER MECHANICS. IN JUNE OF 2000 I HAD TO TAKE THE CAR IN BECAUSE THE HEADLIGHT COVERS FELL OFF. I HAD NOTICED CONDENSATION WHEN I PURCHASED THE CAR AND WAS TOLD BY THE SALESMAN THAT THIS WAS NORMAL. LUCKILY I FOUND THE COVERS AND DID NOT HAVE TO REPLACE THEM. IN SEPT OF 2000 I HAD TO REPLACE THE ALTERNATOR WHEN IT FAILED WHILE I WAS GOING TO WORK. THEN IN DEC OF 2000 I TOOK MY CAR TO HAVE THE TIRES ROTATED AND THE MECHANIC NOTICED THAT THE ANTIFREEZE IN THE RADIATOR WAS JUST ABOUT COMPLETELY SOLIDIFIED. I HAD TO PAY FOR RADIATOR FLUSHES AND WAS TOLD BY THE DEALER THAT IT WAS NORMAL "WEAR AND TEAR". THEY ALSO NOTICED THAT ONE OF THE MAIN ENGINE BELTS WAS NEEDED TO BE REPLACED AND I HAVE REPLACED IT. NOW IT IS MARCH OF 2001 AND MY CAR IS NOW AGAIN AT THE DEALERSHIP WITH ANTIFREEZE LEAKING FROM THE WATER PUMP AND AN AIRBAG LIGHT THAT WILL NOT GO OFF. I HAVE ALSO NOTICED ON NUMEROUS OCCASIONS THAT I WILL GET IN THE CAR AND THE WINDOWS WILL NOT GO DOWN. I KNOW THAT CARS NEED REPAIRS BUT I FEEL THAT I AM DEFINETLY HAVING LOTS OF PROBLEMS WHEN THE MILEAGE ON THE CAR IS NOT EXCESSIVE.THE OWNER OF THE DEALERSHIP TOLD MY HUSBAND THAT HE THOUGHT WE WOULD CONTINUE TO HAVE PROBLEMS WITH THE CAR AND THAT IF HE WERE IN OUR SHOES, HE WOULD TRADE THE CAR.*AK
NHTSA ODI #742192
Mileage unknown · Feb 6, 2001
Electrical System
I HAVE HAD NUMEROUS PROBLEMS WITH THIS CAR INCLUDING ELECTRICAL BLOW-OUTS EVERYWHERE INCLUDING BOTH HEADLIGHTS AND BOTH FOGLIGHTS, BATTERY EXPLOSION, HVAC KNOBS NOT WORKING, INTERIOR LIGHTS BLOWING OUT, BOTH HEADLIGHT COVERS FALLING OFF, WATER PUMP REPLACED, SIDE MIRROR PINS NONFUNCTIONAL, INTERIOR CARPET REPLACED DUE TO IMPROPE…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH THIS CAR INCLUDING ELECTRICAL BLOW-OUTS EVERYWHERE INCLUDING BOTH HEADLIGHTS AND BOTH FOGLIGHTS, BATTERY EXPLOSION, HVAC KNOBS NOT WORKING, INTERIOR LIGHTS BLOWING OUT, BOTH HEADLIGHT COVERS FALLING OFF, WATER PUMP REPLACED, SIDE MIRROR PINS NONFUNCTIONAL, INTERIOR CARPET REPLACED DUE TO IMPROPER INSTALLATION, RADIO/CLOCK FACE BLOWING OUT, AND MOST RECENTLY A FAULTY ALTERNATOR THAT HAD TO BE REPLACED. I THOUGHT I MIGHT HAVE GOTTEN A LEMON, BUT AFTER READING ALL OF THE COMPLAINTS ON THIS MESSAGE BOARD, I'M BEGINNING TO THINK THAT THESE CARS ARE JUNK. WHEN MY HEADLAMP COVERS FELL OFF, I HAD TO PAY AN EXORBITANT FEE FOR THEM. IS THERE A RECALL AFTER SO MANY COMPLAINTS??
NHTSA ODI #740497
Mileage unknown · Nov 22, 2000
Electrical SystemExterior LightingPower Train
THIS CAR HAS A SIGNIFICANT # OF SAFETY PROBLEMS THAT THE DEALER/MANUFACTURER HAVE REFUSED TO ADDRESS W/OUT SIGNIFICANT COST TO CONSUMER. UNTIL I SUSTAIN A SIGNIFICANT INJURY &/OR INJURE SOMEONE DUE TO THESE PRODUCT DEFECTS, I CAN NOT AFFORD A LEGAL CHALLENGE TO HAVE GM ADDRESS PROBLEMS, NOR CAN I BEAR COST. MY CAR IS AVAILABLE…
Read full complaint
THIS CAR HAS A SIGNIFICANT # OF SAFETY PROBLEMS THAT THE DEALER/MANUFACTURER HAVE REFUSED TO ADDRESS W/OUT SIGNIFICANT COST TO CONSUMER. UNTIL I SUSTAIN A SIGNIFICANT INJURY &/OR INJURE SOMEONE DUE TO THESE PRODUCT DEFECTS, I CAN NOT AFFORD A LEGAL CHALLENGE TO HAVE GM ADDRESS PROBLEMS, NOR CAN I BEAR COST. MY CAR IS AVAILABLE AS A SAMPLE OF THEIR JUNK! (SIGNED;CLAIMS ADJUSTER). NO SAFETY DEFECT LISTED IN SUMMARY. *AK
NHTSA ODI #736760
Mileage unknown · Oct 30, 2000
Electrical SystemSteering
I WAS BACKING OUT OF PARKING SPACE AND WENT TO STRAIGHTEN MY WHEELS BACK UP ONLY TO HERE A POP LIKE SOMETHING WAS BROKE AND THE WHEEL WAS REAL HARD TO TURN. I TURNED THE WHEEL BACK THE OTHER WAY AND IT BECAME EASY TO TURN. THE STEERING WHEEL WAS HARD TO TURN SOMETIMES THEN EASY. THE STEERING WHEEL WAS ALSO ABOUT 10-15 DEGREES OF…
Read full complaint
I WAS BACKING OUT OF PARKING SPACE AND WENT TO STRAIGHTEN MY WHEELS BACK UP ONLY TO HERE A POP LIKE SOMETHING WAS BROKE AND THE WHEEL WAS REAL HARD TO TURN. I TURNED THE WHEEL BACK THE OTHER WAY AND IT BECAME EASY TO TURN. THE STEERING WHEEL WAS HARD TO TURN SOMETIMES THEN EASY. THE STEERING WHEEL WAS ALSO ABOUT 10-15 DEGREES OF CENTERED. I WENT TO THREE SHOPS AND NONE WERE ABLE TO TELL ME WHAT WAS WRONG. MY STEERING RACK AND PINION WENT COMPLETELY OUT AND I HAD TO HAVE IT TOWED TO THE DEALER. COST $1304. TO HAVE MINE REPLACED. LUCKILY I WAS TURNING INTO MY DRIVEWAY WHEN IT WENT OUT. POSITIVE BATTERY POST BROKE COMPLETELY OFF WHILE TESTING BATTERY. SOME ACID LEAKED IN BATTERY BAY.
NHTSA ODI #735436
Mileage unknown · Oct 6, 2000
Electrical SystemEngine And Engine Cooling
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
NHTSA ODI #733614
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Dec 16, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WINDSHIELD WIPERS MAY STOP WORKING DUE TO A SEPARATION BETWEEN THE DRIVE PIN AND CRESCENT IN THE CRANK ARM ASSEMBLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF A PLASTIC WATER DEFLECTOR AND, IF NECESSARY, REPLACE THE WIPER MOTOR CRANK ARM AND INSTALL A WATER DEFLECTOR. ON VEHICLES RECEIVING A REPLACEMENT CRANK ARM AND NEW WATER DEFLECTOR, DEALERS WILL ALSO APPLY ADDITIONAL SEALING MATERIAL TO IMPROVE WATER DEFLECTION AWAY FROM THE CRANK ARM ASSEMBLY AND WILL INSTALL A REINFORCEMENT TO IMPROVE THE PERFORMANCE OF THE WIPER PARK MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration