TL* THE CONTACT OWNS A 1977 (NA) PONTIAC GRAND PRIX EQUIPPED WITH SIGMA REGENT TIRES, SIZE 235/75R/15 (NA). WHILE DRIVING APPROXIMATELY 75 MPH, THE FRONT DRIVER SIDE TIRE EXPERIENCED TREAD SEPARATION AND CAUSED DAMAGE TO THE DRIVER SIDE OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE UNK…
Read full complaint
TL* THE CONTACT OWNS A 1977 (NA) PONTIAC GRAND PRIX EQUIPPED WITH SIGMA REGENT TIRES, SIZE 235/75R/15 (NA). WHILE DRIVING APPROXIMATELY 75 MPH, THE FRONT DRIVER SIDE TIRE EXPERIENCED TREAD SEPARATION AND CAUSED DAMAGE TO THE DRIVER SIDE OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 15,000. MA 10/2 UPDATED 10/20/2017*CN
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
THE FOG LAMPS, LOW BEAM HEADLAMPS, AND HIGH BEAM HEADLAMPS CAN BE OPERATED SIMULTANEOUSLY. THIS CAN CAUSE THE HEADLAMP CIRCUIT BREAKER TO OVERLOAD AND TRIP, RESULTING IN LOSS OF HEADLAMPS (LOW AND HIGH BEAM) AND FOG LIGHTS.
Consequence & remedy
Consequence: LOSS OF HEADLAMPS WITHOUT PRIOR WARNING REDUCES DRIVERVISIBILITY IN INCLEMENT WEATHER CONDITIONS OR AT NIGHT, AND COULD RESULT IN AVEHICLE ACCIDENT. IN ADDITION, THE USE OF MORE THAN FOUR (4) WHITE LIGHTS ON AVEHICLE AT THE SAME TIME VIOLATES THE LAW IN SOME STATES.
Remedy: INSTALL NEW FOG LAMP RELAYS, NEW CIRCUIT BREAKERS AND NEW CIRCUIT BREAKER TERMINALS. ALSO, MODIFY THE LIGHTING CIRCUIT TO PREVENT THE FOG LAMPS AND HIGH BEAM LAMPS FROM OPERATING SIMULTANEOUSLY.
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequence & remedy
Consequence: THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy: INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1991 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration