NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
538 reports52,217 miles · Jul 4, 2008
Electrical SystemExterior Lighting
MULTIFUNCTION SWITCH WENT BAD. IT IS A KNOWN PROBLEM FROM GM. HOWEVER, THERE WAS NEVER A RECALL ON THIS SWITCH BECAUSE GM DOESN'T WANT TO PAY THE COSTS. IT COULD CAUSE PROBLEMS WITH TURN SIGNAL BLINKERS POSING A SAFETY HAZARD TO THE DRIVER AND OTHER MOTORISTS. I HAD TO TAKE MY VEHICLE TO THE GARAGE AND PARTS WERE REPLACED FO…
Read full complaint
MULTIFUNCTION SWITCH WENT BAD. IT IS A KNOWN PROBLEM FROM GM. HOWEVER, THERE WAS NEVER A RECALL ON THIS SWITCH BECAUSE GM DOESN'T WANT TO PAY THE COSTS. IT COULD CAUSE PROBLEMS WITH TURN SIGNAL BLINKERS POSING A SAFETY HAZARD TO THE DRIVER AND OTHER MOTORISTS. I HAD TO TAKE MY VEHICLE TO THE GARAGE AND PARTS WERE REPLACED FOR $316.40. *TR
NHTSA ODI #10233204
30,000 miles · Jun 18, 2008
Visibility
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT ALL FOUR REGULATORS ON HER WINDOWS HAD TO BE REPLACED BETWEEN MARCH AND NOVEMBER OF 2007. THE WINDOWS WOULD NO LONGER FUNCTION AFTER A CERTAIN POINT AND THE REGULATORS NEEDED REPLACING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY ORDERED PARTS FOR TH…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT ALL FOUR REGULATORS ON HER WINDOWS HAD TO BE REPLACED BETWEEN MARCH AND NOVEMBER OF 2007. THE WINDOWS WOULD NO LONGER FUNCTION AFTER A CERTAIN POINT AND THE REGULATORS NEEDED REPLACING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY ORDERED PARTS FOR THE REPAIR; HOWEVER, THE REPAIR WAS MADE AT AN INDEPENDENT REPAIR SHOP. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 42,000 AND FAILURE MILEAGE WAS APPROXIMATELY 30,000.
NHTSA ODI #10231445
56,000 miles · Jun 10, 2008
Electrical SystemFuel System, Gasoline
THIS IS MY PROCEDURE OF START ENGINE. TURN ON THE KEY, I CAN SEE THE SIGN OF SECURITY. WAIT 10MINUTES UNTIL LIGHTS OFF. TURN OFF THE KEY AND START THE ENGINE. THAT IS TOO ANNOYING ME. I ALREADY TOWED MY CAR 3 TIMES AND REPLACE THE FUEL PUMP. IT COSTS $500. IS THAT NOT SERIOUS? RECENTLY IT OCCURS TOO OFTEN!!! *TR
NHTSA ODI #10230402
157,000 miles · Jun 2, 2008
Electrical System
ABOUT A YEAR AFTER I GOT THE CAR, WHICH WAS AROUND 3 YEARS AGO, I WAS IN A PARKING LOT & TURNED IT OFF FOR A FEW MINUTES AND THEN WHEN I WENT TO START IT AGAIN IT WOULD NOT START. ALSO, THE SECURITY LIGHT WAS FLASHING. THAT HAPPENED AGAIN 6 MONTHS LATER AND THEN 3 MONTHS AFTER THAT AND THEN EVERY MONTH. THEN ABOUT 2-3 WEEKS AGO …
Read full complaint
ABOUT A YEAR AFTER I GOT THE CAR, WHICH WAS AROUND 3 YEARS AGO, I WAS IN A PARKING LOT & TURNED IT OFF FOR A FEW MINUTES AND THEN WHEN I WENT TO START IT AGAIN IT WOULD NOT START. ALSO, THE SECURITY LIGHT WAS FLASHING. THAT HAPPENED AGAIN 6 MONTHS LATER AND THEN 3 MONTHS AFTER THAT AND THEN EVERY MONTH. THEN ABOUT 2-3 WEEKS AGO THE INTERIOR CHIME AND INTERIOR LIGHTS WOULDN'T SHUT OFF. IT WAS EXACTLY WHAT IT WOULD DO IF I HAD JUST PUT MY KEY IN AND THE DOOR WAS OPEN. HOWEVER, MY KEY WAS NOT IN AND THE DOORS WERE CLOSED. WE DISCONNECTED A FUSE AND THAT AT LEAST MADE THE NOISE AND LIGHTS GO OFF AND KEPT MY BATTERY FROM DYING. MY RADIO ALSO DIDN'T WORK BUT I COULD LIVE WITH THAT. THEN ABOUT A WEEK AND A HALF AGO MY CAR STARTED LOCKING ITSELF EVERY 30 SECONDS AND THE TRUNK OPENED EVERY TIME THE CAR LOCKED. I OPENED THE DRIVERS SIDE DOOR AND SMOKE CAME POURING OUT. I CALLED A NEIGHBOR AND HE DISCONNECTED MY BATTERY AND TOOK MY CAR TO HIS HOUSE TO WORK ON IT. HE CALLED ME BACK THE NEXT DAY AND SAID THAT A MODULE UNDERNEATH MY PASSENGER SIDE DASH WAS MISFIRING AND IF WE HAD NOT DISCONNECTED THE BATTERY WHEN WE DID THE CAR WOULD HAVE CAUGHT FIRE. I SAW THE OLD COMPUTER MODULE. HALF OF THE PLASTIC WAS MELTED AWAY AND THE WIRES WERE BURNT. HE GOT A NEW ONE FROM A JUNK YARD FOR $50 FOR ME AND RESET IT, WITH A MACHINE FROM WORK, TO MY PASSLOCK. THAT SEEMS TO HAVE FIXED THE PROBLEM BUT I'VE READ COMPLAINTS FROM OTHER OWNERS OF PONTIAC GRAND AMS AND THE SAME THINGS ARE HAPPENING TO THEM. I JUST LISTED A COMPLAINT AND LET THEM KNOW WHAT I DID TO FIX IT BUT IF THIS IS HAPPENING TO THAT MANY PEOPLE SOMEONE COULD GET HURT IF THEY DON'T KNOW WHAT TO GET FIXED. MY CAR ALMOST CAUGHT FIRE AND IT WASN'T EVEN ON! *TR
NHTSA ODI #10229682
77,058 miles · May 15, 2008
Engine And Engine Cooling
CHANGE OIL LIGHT WILL COME ON EARLY, ABOUT AFTER 1,000 MILES - BEFORE THE TYPICAL 3,000 MILES OIL SHOULD BE CHANGED (I CHANGE MY OIL EVERY 3,000 MILES). *TR
NHTSA ODI #10227862
81,500 miles · May 14, 2008
Exterior Lighting
RELATED TO RECALL #03V327000 HAD MY HAZARD SWITCH REPLACED VIA RECALL. NEW SWITCH IS SAME AS OLD SWITCH AND IS DEFECTIVE. PONTIAC WON'T REPLACE. PURCHASE NEW SWITCH YESTERDAY AND IS ALSO DEFECTIVE. REPLACEMENT SWITCHES ARE ALSO DEFECTIVE. RECALL DOES NOT REMEDY PROBLEM. *TR
NHTSA ODI #10227718
44,000 miles · May 8, 2008
Electrical System
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING AT AN UNKNOWN SPEED, ALL OF THE INSTRUMENT PANEL LIGHTS FAILED. THE FAILURE OCCURRED INTERMITTENTLY. OCCASIONALLY, WITHIN A FIVE MINUTE INTERVAL, THE CONTACT HAD TO SHUT OFF AND RESTART THE VEHICLE IN ORDER FOR IT TO CORRECT ITSELF. THE FAILURE OCCURS APPROXIMATELY 4…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING AT AN UNKNOWN SPEED, ALL OF THE INSTRUMENT PANEL LIGHTS FAILED. THE FAILURE OCCURRED INTERMITTENTLY. OCCASIONALLY, WITHIN A FIVE MINUTE INTERVAL, THE CONTACT HAD TO SHUT OFF AND RESTART THE VEHICLE IN ORDER FOR IT TO CORRECT ITSELF. THE FAILURE OCCURS APPROXIMATELY 4-5 TIMES WHILE DRIVING. SHE TOOK THE VEHICLE TO A DEALER AND THEY COULD NOT DUPLICATE THE FAILURE EACH TIME. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 44,000 AND CURRENT MILEAGE WAS 52,000.
NHTSA ODI #10227065
126,000 miles · May 7, 2008
Electrical System
I HAVE A PONTIAC 2001 GRAND AM. IT WILL NOT START AND THERE IS SECURITY LIGHT ON. I HAVE READ HUNDREDS OF COMPLAINTS ON THIS ISSUE ON INTERNET WEBSITES. *TR
NHTSA ODI #10226890
92,000 miles · May 6, 2008
Electrical System
SECURITY FEATURE WILL NOT ALLOW THE CAR TO START, YOU HAVE TO TURN THE KEY TO ACC. FOR 10 MINUTES BEFORE IT WILL START , IN MY MIND THIS IS SERIOUS SAFETY PROBLEM , WHAT IF YOUR HAVING AN EMERGENCY AND DO NOT HAVE 10 MINUTES TO WAIT OR YOU HAVE TO SIT IN THE HOT CAR WITH AN INFANT THIS PROBLEM SHOULD BE ADDRESSED. *TR
NHTSA ODI #10226830
90,000 miles · May 4, 2008
Exterior LightingVisibility
MY HUSBAND BOUGHT ME A 2001 GRAND AM GT IN OCTOBER 05' @ 80,000 MILES. I HAD PROBLEMS WITH THE FRONT DRIVER AND PASSENGER WINDOWS IN A YEAR. THE DRIVER SIDE WINDOW REGULATOR POPPED AND BLEW OUT THEN ABOUT 2WKS LATER THE PASSENGER SIDE WINDOW WENT OUT!! MY IGNITION SWITCH DOESN'T WORK, I CAN TAKE MY KEYS OUT OF THE IGNITION WHILE…
Read full complaint
MY HUSBAND BOUGHT ME A 2001 GRAND AM GT IN OCTOBER 05' @ 80,000 MILES. I HAD PROBLEMS WITH THE FRONT DRIVER AND PASSENGER WINDOWS IN A YEAR. THE DRIVER SIDE WINDOW REGULATOR POPPED AND BLEW OUT THEN ABOUT 2WKS LATER THE PASSENGER SIDE WINDOW WENT OUT!! MY IGNITION SWITCH DOESN'T WORK, I CAN TAKE MY KEYS OUT OF THE IGNITION WHILE THE CAR IS STILL ON. MY SIGNAL LIGHTS WENT OUT I REPLACED THEM. MY DRIVER SIDE SEAT DOES NOT MANEUVER @ ALL. MY FOG LIGHT IN THE FRONT ON THE LEFT SIDE HAS CAME OFF COMPLETELY WHILE THE CAR WAS STILL PARKED. I HAVE NOTICED OTHER GRAND AMS @ DRIVE THROUGH RESTAURANTS WHO'S WINDOWS DON'T WORK AND YOU HAVE TO GET YOU'RE FOOD THROUGH THE DOOR!! THIS IS COMPLETELY UNACCEPTABLE AND SHOULD BE FIXED FREE OF CHARGE TO ALL OWNERS ASAP!! ITS A SHAME WE PAY SO MUCH FOR SO LITTLE!! *TR
NHTSA ODI #10226611
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration