TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE STEERING FELT ABNORMAL WHILE THE VEHICLE WAS BEING OPERATED AT 50 MPH. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE CRADLE WAS BEING HELD ON BY A SINGLE BOLT AND WOULD NEED TO BE REPLA…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE STEERING FELT ABNORMAL WHILE THE VEHICLE WAS BEING OPERATED AT 50 MPH. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE CRADLE WAS BEING HELD ON BY A SINGLE BOLT AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. ..UPDATED 06/21/17 *BF *AS
NHTSA ODI #10966315
182,000 miles · Sep 19, 2014
Engine And Engine CoolingStructureCrash
GOING THROUGH AN INTERSECTION, THE CAR SHUTS OFF AND THE CAR FOLLOWING RUNS INTO THE THE BACK OF US. *TR
NHTSA ODI #10637521
Mileage unknown · Feb 15, 2014
Electrical SystemElectronic Stability Control (esc)Structure
EVERYONE KNOWS THAT THE DASHBOARD OF ALL 2001 PONTIAC GRAND AMS ARE WORTHLESS. BEFORE I MENTION THAT THE WINDOW REGULATORS GO OUT FREQUENTLY, AND THE BLINKER MODULES ARE PURE JUNK CAUSING THE BLINKER TO BLINK AT HIGH RATE OF SPEED WHEN TURNING. THEY ALL GO BAD AND MAKE THE CARS LOOK AND SOUND LIKE HELL. THIS HAS BEEN GOING ON FO…
Read full complaint
EVERYONE KNOWS THAT THE DASHBOARD OF ALL 2001 PONTIAC GRAND AMS ARE WORTHLESS. BEFORE I MENTION THAT THE WINDOW REGULATORS GO OUT FREQUENTLY, AND THE BLINKER MODULES ARE PURE JUNK CAUSING THE BLINKER TO BLINK AT HIGH RATE OF SPEED WHEN TURNING. THEY ALL GO BAD AND MAKE THE CARS LOOK AND SOUND LIKE HELL. THIS HAS BEEN GOING ON FOR MANY YEARS LIKE ALL THE OTHERS WRITING IN WITH THE SAME DEMANDS. THERE MUST BE A RECALL AND IF THERE ISN'T ONE, THEN GM IS THE SORRIEST BUNCH OF UNCONCERNED AUTO MANUFACTURERS IN THE BUSINESS. IT MAKES THEM LOOK LIKE THIEVES AND I BELIEVE STRONGLY ABOUT THIS AND AM FOLLOWING THROUGH WITH EVERYTHING IN MY POWER TO SEE THAT ALL OF US ARE COMPENSATED. I WILL NOT CEASE TO STOP THIS PURSUIT. AND THIS IS NOT PERSONAL INFORMATION. I WILL DO WHATEVER IT TAKES TO DAMAGE GM PUBLICLY, SHOULD THIS NOT BE ADDRESSED. ANYONE CAN CALL ME AT [XXX], MY NAME IS [XXX] . I LIVE IN [XXX]AND I'M SICK AND TIRED OF BEING WALKED ALL OVER. JUST READ THE RESPONSES ON-LINE CONCERNING THIS ISSUE. IT SHOULD APPALLED THE ENTIRE WORKING STAFF AT GM. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10564447
126,000 miles · Apr 26, 2013
StructureVisibility/wiper
DASHBOARD IS ROLLING UP AND SEPERATING FROM CAR CAUSING LIMITED VISIBILTY , THIS IS HAPPENING IN ALL 1999 TO 2005 PONTIAC GRAND AM. *TR
NHTSA ODI #10509730
36,400 miles · Apr 27, 2012
Structure
I WAS LEAVING A DOCTOR'S APPOINTMENT. WHEN PULLING OUT OF MY PARKING SPOT THE CAR WOULD NOT TURN RIGHT. I TURNED THE WHEEL BACK AND FORTH AS FAR AS IT WOULD GO. IT WOULD TURN ALL THE WAY LEFT AND NOT GO RIGHT AT ALL. I BACKED BACK INTO MY PARKING SPOT. TOOK A LOOK UNDERNEATH AND DID NOT NOTICE ANYTHING WRONG. I GOT BACK IN AND T…
Read full complaint
I WAS LEAVING A DOCTOR'S APPOINTMENT. WHEN PULLING OUT OF MY PARKING SPOT THE CAR WOULD NOT TURN RIGHT. I TURNED THE WHEEL BACK AND FORTH AS FAR AS IT WOULD GO. IT WOULD TURN ALL THE WAY LEFT AND NOT GO RIGHT AT ALL. I BACKED BACK INTO MY PARKING SPOT. TOOK A LOOK UNDERNEATH AND DID NOT NOTICE ANYTHING WRONG. I GOT BACK IN AND TRIED TURNING THE WHEEL AGAIN. THIS TIME THE WHEEL TURNED BOTH WAYS. I LEFT THE PARKING LOT TO RETURN HOME. ON THE WAY HOME I HEARD SOME KNOCKING SOUNDS COMING FROM THE FRONT END WHENEVER I DROVE OVER A BUMP OR POT HOLE. ALSO TURNING THE CAR TO THE RIGHT DID NOT FEEL OR SOUND GOOD. I DECIDED TO DRIVE STRAIGHT TO MY MECHANIC. IN A COUPLE OF HOURS I GOT A PHONE CALL FROM MY MECHANIC. IT TURNS OUT THE FRAME WAS TOTALLY RUSTED OUT. THE FRAME BEING RUSTED OUT WAS CAUSING THE PROBLEMS WITH STEERING. THE CAR IS ONLY TEN YEARS OLD AND HAS 36, 400 MILES ON IT. *TR
NHTSA ODI #10456670
70,000 miles · Oct 9, 2007
EquipmentExterior LightingFuel System, Other
TL*CONTACT OWNS A 2001 PONTIAC GRAND AM. SHE NOTICED THAT THERE WAS A LEAK UNDER HER VEHICLE FOR A FEW YEARS. ON SEVERAL OCCASIONS THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE LEAK. THE DEALER LATER STATED THAT THE LEAK WAS COMING FROM THE GAS TANK LINE AND IT WAS A FUEL LEAK. THEY ALSO TOLD HER THAT THERE WAS A RELATED RECALL…
Read full complaint
TL*CONTACT OWNS A 2001 PONTIAC GRAND AM. SHE NOTICED THAT THERE WAS A LEAK UNDER HER VEHICLE FOR A FEW YEARS. ON SEVERAL OCCASIONS THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE LEAK. THE DEALER LATER STATED THAT THE LEAK WAS COMING FROM THE GAS TANK LINE AND IT WAS A FUEL LEAK. THEY ALSO TOLD HER THAT THERE WAS A RELATED RECALL; HOWEVER, HER VIN WAS NOT RELATED. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED AND REQUEST THAT HER VIN IS A PART OF THE EXISTING NHTSA CAMPAIGN ID NUMBER 07E021000. THE DEALER INFORMATION IS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 98,000. THE CONSUMER STATED THE VEHICLE IS STILL LOCATED AT THE REPAIR SHOP AWAITING WORD FROM THE CORP OFFICE. THE DEALER STATED REPLACED HAZARD LIGHTS SWITCH, SPEAKER RADIO REAR DOOR, MOLDING WINDSHIELD SIDE PILLAR, EXTERIOR BULBS, AND WIPER BLADE. UPDATED 10/31/07 *TR
NHTSA ODI #10205286
Mileage unknown · Nov 10, 2006
StructureCrash
I PURCHASED A USED VEHICLE IN MARCH 2006. AT THAT TIME I WAS PROVIDED A "CAR REPORT" THAT SHOWED NO ACCIDENT HISTORY/CLEAN TO EVERYTHING. AT A LATER TIME I WENT TO PURCHASE NEW INSURANCE AND I WAS FIRST ALERTED TO AN "ACCIDENT". I FOUND OUT THE VEHICLE WAS IN AN ACCIDENT IN JUNE 2002, OVER $700.00 IN DAMAGE. IN 2003 AGAIN, WAS…
Read full complaint
I PURCHASED A USED VEHICLE IN MARCH 2006. AT THAT TIME I WAS PROVIDED A "CAR REPORT" THAT SHOWED NO ACCIDENT HISTORY/CLEAN TO EVERYTHING. AT A LATER TIME I WENT TO PURCHASE NEW INSURANCE AND I WAS FIRST ALERTED TO AN "ACCIDENT". I FOUND OUT THE VEHICLE WAS IN AN ACCIDENT IN JUNE 2002, OVER $700.00 IN DAMAGE. IN 2003 AGAIN, WAS TAKEN TO A BODY SHOP FOR REPAIRS. I HAVE TRIED TO WORK WITH THE DEALERSHIP TO HANDLE THIS SITUATION. I TOOK THE VEHICLE TO ONE OF THEIR VENDORS-SAME OUTCOME. MY VENDOR SAME OUTCOME--EXTENSIVE DAMAGE/FRAME STRAIGHTENING ETC. I ASKED FOR MY MONEY BACK OR A NEW VEHICLE. THEY REFUSED. IT WOULD COST MORE TO FIX THIS CAR THAN IT IS WORTH. I NEED SOME ASSISTANCE. I LOOKED THEM UP ON THE BBB AND THEY HAVE 55 REPORTS IN 36 MONTHS. NOT TO MENTION THEY ARE MAKING A 1000% PROFIT OFF OF ME. *JB
NHTSA ODI #10173172
Mileage unknown · Sep 6, 2006
Structure
EVERYTIME THERE IS A HEAVY RAIN THE FLOORS OF MY 2001 PONTIAC GRAND AM GETS SOAKED. YESTERDAY WAS BY FAR THE WORST OF ALL, THERE WAS ABOUT 3 INCHES OF STANDING WATER ON THE PASSENGER SIDE FLOOR. MY CAR SMELLS OF MILDEW AND THE CARPET IS RUINED. THIS SEEMS TO BE A COMMON PROBLEM FOR THIS CAR AND I WOULD LIKE TO SEE SOMETHING DONE…
Read full complaint
EVERYTIME THERE IS A HEAVY RAIN THE FLOORS OF MY 2001 PONTIAC GRAND AM GETS SOAKED. YESTERDAY WAS BY FAR THE WORST OF ALL, THERE WAS ABOUT 3 INCHES OF STANDING WATER ON THE PASSENGER SIDE FLOOR. MY CAR SMELLS OF MILDEW AND THE CARPET IS RUINED. THIS SEEMS TO BE A COMMON PROBLEM FOR THIS CAR AND I WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS. I FEEL LIKE I HAVE WASTED MY MONEY AND I STILL HAVE 2 YEARS OF PAYMENTS REMAINING. *NM
NHTSA ODI #10167461
132,000 miles · Sep 1, 2006
Structure
DUE TO WATER LEAKING INTO THE CAR THE BCM COMPUTER HAD TO BE REPLACED. THE MECHANIC THAT FIXED THE CAR SAID THE FUEL PUMP HAD TO BE REPLACED ALSO. *NM
NHTSA ODI #10167231
Mileage unknown · Aug 13, 2003
Structure
DASHBOARD IS RISING WHICH COULLD PREVENT AIR BAGS FROM DEPLOYING UPON IMPACT. CONSUMER HAS CONTACTED THE DEALER.*AK
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2001 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration