NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
11 reportsClear category filter79,000 miles · Mar 4, 2016
Air BagsService BrakesVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING 45 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE FAILED TO STOP. THE CONTACT REAR ENDED ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED CHEST AND LEFT KNEE INJURIES THAT REQUIRED MEDICAL ATTENT…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING 45 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE FAILED TO STOP. THE CONTACT REAR ENDED ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED CHEST AND LEFT KNEE INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
NHTSA ODI #10839880
112,000 miles · Oct 10, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH UPHILL WHEN THE VEHICLE INCREASED ACCELERATION WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE ENGINE RPMS BEGAN RAPIDLY INCREASED SIMULTANEOUSLY WITH THE FAILURE. THE VEHICLE CAME TO A STOP WHEN THE BRAKE PEDAL WAS ENGAGED. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH UPHILL WHEN THE VEHICLE INCREASED ACCELERATION WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE ENGINE RPMS BEGAN RAPIDLY INCREASED SIMULTANEOUSLY WITH THE FAILURE. THE VEHICLE CAME TO A STOP WHEN THE BRAKE PEDAL WAS ENGAGED. THE FAILURE RECURRED INTERMITTENTLY AND PROGRESSED OVER A MATTER OF WEEKS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.
NHTSA ODI #10479662
240,000 miles · Sep 5, 2012
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
MY CAR HAS A SECURITY DEVICE THAT WHEN DRIVING WILL COMPLETELY SHUT DOWN THE CAR AND I HAVE TO DRIVE ON I26 TO GET TO WORK THIS IS A MAJOR INTERSTATE WHAT HAPPENS WHEN IM DRIVING THIS CAR AND IT SHUTS DOWN IN FRONT OF A BIG TRUCK AND I CANT STEER IT BECAUSE THE POWER AND ELECTRICAL CONTROL HAS COMPLETELY QUIT. THIS IS A DEATH TR…
Read full complaint
MY CAR HAS A SECURITY DEVICE THAT WHEN DRIVING WILL COMPLETELY SHUT DOWN THE CAR AND I HAVE TO DRIVE ON I26 TO GET TO WORK THIS IS A MAJOR INTERSTATE WHAT HAPPENS WHEN IM DRIVING THIS CAR AND IT SHUTS DOWN IN FRONT OF A BIG TRUCK AND I CANT STEER IT BECAUSE THE POWER AND ELECTRICAL CONTROL HAS COMPLETELY QUIT. THIS IS A DEATH TRAP WAITING TO HAPPEN PONTIAC OR GM SHOULD REALLY RECALL THIS I HAD TO REPLACE MY COMPLETE COOLANT SYSTEM AND FUEL SYSTEM ONLY TO BE TOLD ITS THE CARS ANTI-THEFT DETERRENT SECURITY DEVICE IT IS A JUST A MATTER OF TIME BEFORE SOMEONE IS HURT OR EVEN WORSE BY THIS DEFECTIVE DEVICE. HOW MANY COMPLAINTS DO WE HAVE TO MAKE TO GET THIS PART RECALLED AND FIXED? IT'S TOO LATE WHEN YOUR DEAD TO MAKE A RECALL. *TR
NHTSA ODI #10473968
103,000 miles · Feb 10, 2007
Fuel System, GasolineVehicle Speed Control
I BOUGHT A USED 2001 PONTIAC GRAND AM IN FEBRUARY 2002. THE CRUISE CONTROL WENT OUT ON THE CAR IN JANUARY 2003. AFTER NUMEROUS ATTEMPTS TO GET THIS FIXED AT THE DEALER I FINALLY GAVE UP. SHORTLY AFTERWARDS THE FUEL PUMP HAD TO BE REPLACED (SPRING 2003). SINCE THAT TIME I'VE HAD TO REPLACE THE FUEL PUMP TWICE LAST FALL. NOW ITS …
Read full complaint
I BOUGHT A USED 2001 PONTIAC GRAND AM IN FEBRUARY 2002. THE CRUISE CONTROL WENT OUT ON THE CAR IN JANUARY 2003. AFTER NUMEROUS ATTEMPTS TO GET THIS FIXED AT THE DEALER I FINALLY GAVE UP. SHORTLY AFTERWARDS THE FUEL PUMP HAD TO BE REPLACED (SPRING 2003). SINCE THAT TIME I'VE HAD TO REPLACE THE FUEL PUMP TWICE LAST FALL. NOW ITS GONE OUT AGAIN. WHAT CAN I DO? THE CAR HAS AN EVIDENT ELECTRICAL PROBLEM. *NM
NHTSA ODI #10182201
50,000 miles · Sep 25, 2006
Electronic Stability ControlService Brakes, HydraulicVehicle Speed Control
DT*: THE CONTACT STATED WHILE PARKED, THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP THREE TIMES TO REPLACE THE BEARINGS, WHICH HAD THE SPEED SENSORS ATTACHED. ON THE FORTH VISIT, THE ABS PROBLEM REOCCURRED. OTHER COMPONENTS AFFECTED WERE THE CRUISE CONTROL AND THE TRACTION CONTROL. THE MANUFACTURER WAS C…
Read full complaint
DT*: THE CONTACT STATED WHILE PARKED, THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP THREE TIMES TO REPLACE THE BEARINGS, WHICH HAD THE SPEED SENSORS ATTACHED. ON THE FORTH VISIT, THE ABS PROBLEM REOCCURRED. OTHER COMPONENTS AFFECTED WERE THE CRUISE CONTROL AND THE TRACTION CONTROL. THE MANUFACTURER WAS CONTACTED, AND PROVIDED NO RESOLUTION. THE CONTACT EXPRESSED CONCERN BECAUSE THE DEFECTS REPRESENTED A RISK TO SAFETY.
NHTSA ODI #10169217
48,100 miles · Jun 14, 2005
Vehicle Speed Control
FIRST TIME MY DAUGHTER WAS DRIVING CAR SHE HAD A VERY HARD TIME STOPPING THE CAR AS IF THE GAS WAS STUCK ON. A FRIEND LOOKED AT IT STATED THAT THE THROTTLE WAS STUCK IN THE OPEN POSITION. GARAGE HAD IT 3 DAYS. CHANGED THROTTLE DID IT AGAIN 1 DAY LATER CALLED GARAGE BACK HAS NOW BEEN THERE 2 DAYS.. STILL WAITING
NHTSA ODI #10125310
38,767 miles · Nov 7, 2004
Vehicle Speed Control
GAS PEDAL HAD ALWAYS HAD A BIT OF A "HITCH" TO IT. WHILE DRIVING ON A MAJOR HIGHWAY THE GAS PEDAL BECAME STUCK IN THE "ON" POSITION. WE WERE LUCKY ENOUGH TO BE ABLE TO GET OFF OF THE ROAD AND INTO A PARKING LOT WHERE WE TURNED THE ENGINE OFF. CAR HAD TO BE TOWED TO A REPAIR SHOP - UNDRIVEABLE. CONSEQUENCES: WE WERE STRANDED …
Read full complaint
GAS PEDAL HAD ALWAYS HAD A BIT OF A "HITCH" TO IT. WHILE DRIVING ON A MAJOR HIGHWAY THE GAS PEDAL BECAME STUCK IN THE "ON" POSITION. WE WERE LUCKY ENOUGH TO BE ABLE TO GET OFF OF THE ROAD AND INTO A PARKING LOT WHERE WE TURNED THE ENGINE OFF. CAR HAD TO BE TOWED TO A REPAIR SHOP - UNDRIVEABLE. CONSEQUENCES: WE WERE STRANDED FOR 2 HOURS IN A REMOTE AREA WAITING FOR A TOW TRUCK AND WITHOUT THE CAR FOR OVER A WEEK - THE TIME IT TOOK TO GET A REPLACEMENT PART. ACCORDING TO THE REPAIRMAN, THE NYLON BUSHING ON THE GAS PEDAL MECHANISM WAS BROKEN. THEY HAD TO REPLACE THE GAS PEDAL ASSEMBLY. THE OLD PART IS NOT AVAILABLE. IT WAS A FRIGHTENING EXPERIENCE. WORST IS THAT JUST 2 WEEKS BEFORE THAT MY WIFE HAD DRIVEN THE CAR TO FLORIDA ALONE - OVER 1000 MILES FROM OLD HOME IN NEW YORK - MOST OF THE TRIP ON THE INFAMOUS I 95. SHE COULD HAVE BEEN KILLED HAD THIS HAPPENED ON THAT ROAD. *JB
NHTSA ODI #10098412
15,500 miles · Oct 5, 2004
Service Brakes, HydraulicVehicle Speed Control
FIRST THE SPEED SENSOR MALFUNCTIONED. THEN, THE SPEED SENSOR HUB MALFUNCTIONED WITHIN ONE YEAR TIME LIMIT. THESE SENSORS HAD AN EFFECT ON THE ANTI LOCK BRAKING SYSTEM WHICH DID NOT WORK WHEN SENSORS FAILED. CRUISE CONTROL WILL NOT WORK BECAUSE IT MADE THE BRAKE LIGHT COME ON. TOOK VEHICLE IN TO SEE WHAT WAS WRONG. DEALER DID N…
Read full complaint
FIRST THE SPEED SENSOR MALFUNCTIONED. THEN, THE SPEED SENSOR HUB MALFUNCTIONED WITHIN ONE YEAR TIME LIMIT. THESE SENSORS HAD AN EFFECT ON THE ANTI LOCK BRAKING SYSTEM WHICH DID NOT WORK WHEN SENSORS FAILED. CRUISE CONTROL WILL NOT WORK BECAUSE IT MADE THE BRAKE LIGHT COME ON. TOOK VEHICLE IN TO SEE WHAT WAS WRONG. DEALER DID NOT SOLVE THE PROBLEM. *AK
NHTSA ODI #10095082
Mileage unknown · May 5, 2004
Vehicle Speed Control
WHILE DRIVING CONSUMER ATTEMPTED TO ACCELERATE IN ORDER TO PASS ANOTHER VEHICLE AND ACCELERATOR PEDAL STUCK IN POSITION. IN ORDER TO STOP CONSUMER HAD TO SHUT THE VEHICLE OFF AND COAST OFF THE HIGHWAY.*AK
NHTSA ODI #10072136
6,000 miles · Oct 7, 2003
Vehicle Speed Control
ACCELERATOR STICKS WHILE DRIVING, ESPECIALLY IN HOT WEATHER. THE ONLY WAY TO BRAKE IS TO MANUALLY PULL UP ACCELERATOR WITH YOUR FOOT. DEALER SAYS IT IS THE THROTTLE BODY NEEDING TO BE CLEANED. IT HAS BEEN CLEANED SEVERAL TIMES AND THINGS NEVER CLEAR UP THE PROBLEM. *JB
NHTSA ODI #10041364
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration