When I was gassing up my car, a fuel leak occurred in the gas tank and my car caught on fire. The gas station attendant used a fire extinguisher to put the fire out. I had 113,262 miles on my car. As you can see, the leak in the plastic gas tank caused the gas tank fuel pump to burn up and burn up its wiring harness. I don…
Read full complaint
When I was gassing up my car, a fuel leak occurred in the gas tank and my car caught on fire. The gas station attendant used a fire extinguisher to put the fire out. I had 113,262 miles on my car. As you can see, the leak in the plastic gas tank caused the gas tank fuel pump to burn up and burn up its wiring harness. I don't want any money but I just thought the NHTSA should know. I do not need money because my insurance company will be reimbursing me for my total loss of the car.
NHTSA ODI #11446378
211,000 miles · Feb 21, 2017
Electrical SystemFuel/propulsion System
BLINKERS JUST STOP WORKING SOMTIMES FOR HOURS AND THEN BACK ON WHILE DRIVING AND A CADILLAC CONVERTER IS MAKING NOISE.
NHTSA ODI #10955719
208,720 miles · Sep 17, 2016
Electrical SystemFuel/propulsion System
'M WRITING TO NOTIFY GM ABOUT A DANGEROUS ISSUE WITH MY 2001 PONTIAC GRAND AM. THE SECURITY SYSTEM ACTIVATES PREVENTING THE CAR TO STOP FOR 10 MINUTES UNTIL IT RESETS, CAUSING MANY WORK RELATED ISSUES. THIS SECURITY ISSUE PREVENTS THE FUEL PUMP FROM ACTIVATING, ALLOWING THE CAR TO START. THE PROBLEM HAS GOTTEN SO SEVERE, THE C…
Read full complaint
'M WRITING TO NOTIFY GM ABOUT A DANGEROUS ISSUE WITH MY 2001 PONTIAC GRAND AM. THE SECURITY SYSTEM ACTIVATES PREVENTING THE CAR TO STOP FOR 10 MINUTES UNTIL IT RESETS, CAUSING MANY WORK RELATED ISSUES. THIS SECURITY ISSUE PREVENTS THE FUEL PUMP FROM ACTIVATING, ALLOWING THE CAR TO START. THE PROBLEM HAS GOTTEN SO SEVERE, THE CAR NOW SHUTS DOWN MID DRIVE WHILE ON THE INTERSTATE. LIVING IN LOUISVILLE, TN AWAY 10 HOURS FROM HOME, I HAVE NO OTHER CHOICE BUT TO KEEP USING THIS VEHICLE TO GET BACK AND FORTH FROM WORK. NOW I'M FORCED TO REMAIN IN THE OUTSIDE LANE TO QUICKLY GET OVER ONTO THE SHOULDER WHEN THE CAR SHUTS OFF. THIS HAS HAPPENED NO LESS THAN 15 TIMES A WEEK, ALMOST CAUSING AN ALMOST FATAL ACCIDENT. I'VE BEEN TO A TRUSTED MECHANIC WHERE WE REPLACED THE ECM TWO SEPARATE TIMES, BUT THE ISSUE STILL PERSISTS. HAS THERE BEEN MANY ISSUES REPORTED ABOUT THE CAR STOPPING IN THE MIDDLE OF A DRIVE?
NHTSA ODI #10907320
160,000 miles · Jul 1, 2014
Electrical SystemFuel/propulsion System
WENT TO GET IN MY CAR AT THE STORE AND THE SECURITY LIGHT WAS ON AND CAR WOULDN'T START HAD TO HAVE IT TOWED ACROSS TOWN. THEN I READ THAT IT IS A COMMON PROBLEM WITH THESE VEHICLES. NOW I HEAR GM IS RECALLING FOR IGNITION SWITCH. WHICH IS WHAT IS WRONG WITH MY VEHICLE. IM AFRAID IT WILL HAPPEN WHILE IM DRIVING. LETS HOPE NOT. W…
Read full complaint
WENT TO GET IN MY CAR AT THE STORE AND THE SECURITY LIGHT WAS ON AND CAR WOULDN'T START HAD TO HAVE IT TOWED ACROSS TOWN. THEN I READ THAT IT IS A COMMON PROBLEM WITH THESE VEHICLES. NOW I HEAR GM IS RECALLING FOR IGNITION SWITCH. WHICH IS WHAT IS WRONG WITH MY VEHICLE. IM AFRAID IT WILL HAPPEN WHILE IM DRIVING. LETS HOPE NOT. WENT TO THE GM WEB PAGE THEY SAID IT WASN'T RECALLED AND THEN I SEE IT ON A RECALL LIST. I GUESS I NEED TO PURSUE THIS A LITTLE MORE TO GET THE PROBLEM SOLVED. *TR
NHTSA ODI #10607575
122,000 miles · Apr 2, 2014
Engine And Engine CoolingFuel/propulsion System
I WAS DRIVING DOWN THE STREET AND THE CAR JUST SHUTS OFF WHILE DRIVING OR SLOWING DOWN. THEY ARE SAYING THE FUEL INJECTOR IS BAD. *TR
NHTSA ODI #10576744
118,947 miles · Sep 10, 2013
Electrical SystemFuel/propulsion SystemSteering
ON MY WAY TO WORK (2ND SHIFT) IN RUSH HOUR TRAFFIC AS I WAS PREPARING TO MERGE ONTO THE HIGHWAY THE CAR SIMPLY SHUT-OFF BLOCKING TRAFFIC. (I WAS EVENTUALLY - 20 MINUTES - ABLE TO GET HELP TO PUSH THE CAR OFF THE ROAD.) EVERYTHING SHUT OFF AND CAR WOULD NOT RESTART....EVERYTHING INCLUDING THE POWER-STEERING. THIS HAS HAPPENED …
Read full complaint
ON MY WAY TO WORK (2ND SHIFT) IN RUSH HOUR TRAFFIC AS I WAS PREPARING TO MERGE ONTO THE HIGHWAY THE CAR SIMPLY SHUT-OFF BLOCKING TRAFFIC. (I WAS EVENTUALLY - 20 MINUTES - ABLE TO GET HELP TO PUSH THE CAR OFF THE ROAD.) EVERYTHING SHUT OFF AND CAR WOULD NOT RESTART....EVERYTHING INCLUDING THE POWER-STEERING. THIS HAS HAPPENED ONE OTHER TIME AND THE VEHICLE IS NOW NOTHING MORE THEN A TWO-TON PAPERWEIGHT IN MY GARAGE - AND ABOUT AS USEFUL. ON A SECOND OCCASION IT CUT-OFF AS I PULLED INTO TRAFFIC AND ALMOST CAUSED A COLLISION...FORTUNATELY I WAS ABLE TO COAST FAR ENOUGH TO GET INTO THE TURN LANE AND THEN WHEN TRAFFIC CLEARED TO PUSH IT BACK OFF THE ROAD. AN ONLINE SEARCH TOLD ME THIS IS A WELL-KNOWN PROBLEM WITH THE SECURITY SYSTEM OF THE VEHICLE BUT THERE SEEMS NO AGREEMENT ON A SOLUTION/FIX. EVIDENTLY THE SECURITY SYSTEM SIMPLY DOES NOT RECOGNIZE THE KEY (EVEN WHEN IT IS THE CORRECT ONE) AND THINKS THE CAR IS BEING STOLEN AND THUS SHUTS ITSELF OFF. WHAT WOULD/COULD HAVE HAPPENED IF THIS OCCURRED WHILE I WAS AT SPEED IN TRAFFIC? IF PONTIAC KNOWS ABOUT THIS WHY IS THERE NO RECALL....DOES SOMEONE HAVE TO DIE FIRST? *TR
NHTSA ODI #10542855
240,000 miles · Sep 5, 2012
EngineFuel/propulsion SystemService Brakes
FUEL SYSTEM, GASOLINE DETAILS: @ TIMES YOU CAN SMELL GAS ON THE INSIDE OF THE RECENTLY PUT $690 INTO CHANGING THE ENTIRE FUEL SYSTEM BEFORE THAT IT COST ME $1100 FOR THE ENTIRE COOLANT SYSTEM $250 FOR COIL PACK AND COVER FREQUENTLY SPARKPLUGS CHANGED OUT THE AC BUTTONS WONT ALLOW THE AC TO TURN ON I LIVE IN THE SOUTH WE BURN…
Read full complaint
FUEL SYSTEM, GASOLINE DETAILS: @ TIMES YOU CAN SMELL GAS ON THE INSIDE OF THE RECENTLY PUT $690 INTO CHANGING THE ENTIRE FUEL SYSTEM BEFORE THAT IT COST ME $1100 FOR THE ENTIRE COOLANT SYSTEM $250 FOR COIL PACK AND COVER FREQUENTLY SPARKPLUGS CHANGED OUT THE AC BUTTONS WONT ALLOW THE AC TO TURN ON I LIVE IN THE SOUTH WE BURN UP DOWN HERE WITH NO AC IN A CAR AND AGAIN ON THIS PAST SUNDAY I JUST PUT ANOTHER 4170 INTO SPARKPLUGS AND COIL PACKS ONLY TO FIND OUT THAT ALL MY PROBLEMS ARE CAUSED FROM THE CARS SECURITY ANTI - THEFT DEVICE THAT IS DEFECTIVE I LOSE POWER NO RPM'S CAR WILL DIE IN THE MIDDLE OF THE INTERSTATE THAT I HAVE TO DRIVE IN DOWNTOWN GREEVILLE SC AND TOWNS LIKE ATLANTA AND CHATTANOOGA TN THE SMALL THINGS ARE THE RADIO THE LIGHTS THE HEADLAMPS DON'T SHINE NO BRIGHTER THAN A CANDLE ON A BIRTHDAY CAKE NOT TO MENTION THAT I GO THRU BREAKS AND TIRES LIKE THEY ARE CANDY IT SEEMS TO WEAR A GROOVE ON THE INSIDE BACK PASSENGER TIRE AND THE FRONT DRIVERS SIDE MAKES THIS LOUD GRINDING NOISE THAT I THINK COULD BE THE BRAKE BOOSTER BALL NOT SURE ON THAT BUT I HAVE SPENT ENOUGH MONEY ON THIS CAR TO KEEP IT GOING I COULD HAVE BOUGHT 2 NEW VEHICLES CAN SOMEONE PLEASE HAVE PONTIAC LOOK INTO RECALLS. *TR
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2001 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration