IllustrationVATS THE ANTI THEFT THAT LOCKS UP GM CARS BECAUSE OF THE SERCUITY CHIP THAT'S IN THE KEY PEOPLE HAVE GOT ROBBED SITTING IN A PARKING LOT WAITING ON THEY CAR TO START OR FOR SOME ONE TO COME GET THEM. *TT
2001 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 2001 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
6525–50K
7750–75K
6375–100K
75100–150K
31150K+
343 reports with mileage · 195 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 232 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports4 fire reports14 injury reports
Equipment complaints
22 reports2001 PONTIAC GRAND AM GT WONT START. TURN THE KEY TO START AND NOTHING. AFTER A DAY THEN THE CAR WILL START... WHEN THE CAR START YOU CAN HEAR THE GAS PUMP TURN ON... WHEN THE PROBLEM STARTS THERE IS NOTHING. *TR
CAR WON'T START. LEAVES ME (WIDOW) STRANDED WHEREVER I AM, AWAITING TOW TRUCK. THESE ARE WHAT HAVE BEEN REPEATED CULPRITS - DEFECTIVE PASS DOOR LOCK, DEFECTIVE HAZARD SWITCH (2 REPLACEMENTS) FAULTY IGNITION SWITCH (2 REPLACEMENTS), FAULTY IGNITION PASS LOCK SENSOR... THIS CAR HAS ALOT OF FAULTY REPLACED OVER AND OVER AGAIN SINC…
Read full complaint
CAR WON'T START. LEAVES ME (WIDOW) STRANDED WHEREVER I AM, AWAITING TOW TRUCK. THESE ARE WHAT HAVE BEEN REPEATED CULPRITS - DEFECTIVE PASS DOOR LOCK, DEFECTIVE HAZARD SWITCH (2 REPLACEMENTS) FAULTY IGNITION SWITCH (2 REPLACEMENTS), FAULTY IGNITION PASS LOCK SENSOR... THIS CAR HAS ALOT OF FAULTY REPLACED OVER AND OVER AGAIN SINCE 2004, 2006, 2008, 2009 AND 2010... LATEST REPLACEMENT OF FAULTY PASS DOOR LOCK SENSOR IS LISTED BELOW... *TR
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE SECURITY LIGHT BEGAN FLASHING ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE KEY WAS RESET WHICH ALLOWED THE VEHICLE TO START. THE FAILURE CONTINUED TO OCCUR THREE TIMES AFTER THE KEY WAS RESET. THE…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE SECURITY LIGHT BEGAN FLASHING ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE KEY WAS RESET WHICH ALLOWED THE VEHICLE TO START. THE FAILURE CONTINUED TO OCCUR THREE TIMES AFTER THE KEY WAS RESET. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 130,000.
I HAVE A 2001 PONTIAC GRAND AM THAT I HAVE HAD ISSUES WITH SINCE I BOUGHT THE CAR. NOW FOR THE SECOND TIM IN THREE YEARS I HAVE HAD TO REPLACE THE PASSLOCK SENSOR AND THE IGNITION SWITCH CYLINDER. THIS FIX HAS COST ME OVER $700.00 EACH TIME NOT INCLUDING THE TOW. I AM A MOTHER OF TWO KIDS THAT WORKS FULL-TIME AND GOES TO SCHOOL…
Read full complaint
I HAVE A 2001 PONTIAC GRAND AM THAT I HAVE HAD ISSUES WITH SINCE I BOUGHT THE CAR. NOW FOR THE SECOND TIM IN THREE YEARS I HAVE HAD TO REPLACE THE PASSLOCK SENSOR AND THE IGNITION SWITCH CYLINDER. THIS FIX HAS COST ME OVER $700.00 EACH TIME NOT INCLUDING THE TOW. I AM A MOTHER OF TWO KIDS THAT WORKS FULL-TIME AND GOES TO SCHOOL PART TIME, THIS PROBLEM HAS DRAINED ME OF MONEY THAT I USE TO SUPPORT MY CHILDREN. I HAVE MISSED WORK AND SCHOOL BECAUSE OF THIS PROBLEM. THERE ARE FORUMS THAT I HAVE LOOKED AT AND READ WITH PEOPLE GOING THROUGH THE SAME ISSUE. I HAVE TAKEN IT TO A GM DEALER AND ALSO A MECHANIC IN ORDER TO FIX THIS PROBLEM THAT'S WHEN I REALIZED IT WAS THE SAME ISSUE. I COMPARED NOTES. I BELIEVE THAT THIS IS GOING TO BE HAPPENING AGAIN IN THE NEXT FEW YEARS ACCORDING TO MY MECHANIC, WHO HAS ALSO HEARD PEOPLE DISCUSSING THIS SAME ISSUE. *TR
THE VERY SAME PROBLEMS/ISSUES ARE OCCURRING WITH/IN MY 2001 PONTIAC GRAND AM. I AM THE ONLY OWNER OF MY VEHICLE AND HAVE EXPERIENCED EVERY SINGLE ISSUE OTHERS HAVE WROTE ABOUT. FROM THE SECURITY ISSUE TO THE DRIVER SIDE SEAT NOT MOVING AT ALL..... GM REALLY NEEDS TO RESEARCH/INVESTIGATE THESE MATTERS AND PLACE RE-CALLS ON ALL…
Read full complaint
THE VERY SAME PROBLEMS/ISSUES ARE OCCURRING WITH/IN MY 2001 PONTIAC GRAND AM. I AM THE ONLY OWNER OF MY VEHICLE AND HAVE EXPERIENCED EVERY SINGLE ISSUE OTHERS HAVE WROTE ABOUT. FROM THE SECURITY ISSUE TO THE DRIVER SIDE SEAT NOT MOVING AT ALL..... GM REALLY NEEDS TO RESEARCH/INVESTIGATE THESE MATTERS AND PLACE RE-CALLS ON ALL OF THEM ASAP. THIS IS A VERY SERIOUS MATTER AND APPARENTLY THEY ARE OVERLOOKING THIS COMPLETELY. *TR
A FEW YEARS BACK, I HAD A PROBLEM IN WHICH MY RPMS WOULD RISE INSANELY WHEN I WAS STOPPED AT A LIGHT, AND EVEN WHEN I PUT MY CAR IN PARK. IT WAS AS IF I WAS "FLOORING IT". I TOOK IT TO THE DEALER. THEY SAID IT WAS A HEAD GASKET PROBLEM. LUCKILY, IT WAS STILL UNDER WARRANTY, AS I ONLY HAD ABOUT 45,000 MILES ON IT. I TOOK IT HOME …
Read full complaint
A FEW YEARS BACK, I HAD A PROBLEM IN WHICH MY RPMS WOULD RISE INSANELY WHEN I WAS STOPPED AT A LIGHT, AND EVEN WHEN I PUT MY CAR IN PARK. IT WAS AS IF I WAS "FLOORING IT". I TOOK IT TO THE DEALER. THEY SAID IT WAS A HEAD GASKET PROBLEM. LUCKILY, IT WAS STILL UNDER WARRANTY, AS I ONLY HAD ABOUT 45,000 MILES ON IT. I TOOK IT HOME AFTER IT WAS "FIXED", AND IT CONTINUED TO DO THE SAME THING. I TOOK IT BACK TO THE DEALER, AND THEY SAID THAT THEY FIXED THE PROBLEM AND THAT IT WILL BE OK. I TOOK IT BACK HOME AND IT HAS PRETTY MUCH NEVER STOPPED. IT TENDS TO DO IT MORE IN THE SUMMER AS OPPOSED TO THE WINTER. RECENTLY, THE CAR WAS LEAKING COOLANT. I TOOK IT BACK TO THE DEALER. I WAS ONCE AGAIN TOLD THAT IT WAS THE HEAD GASKET. MY CAR IS NO LONGER UNDER WARRANTY, SO I HAD TO PAY $1600 TO GET IT FIXED. 2 HEAD GASKET PROBLEMS WITHIN A MATTER OF 2 YEARS? THAT SEEMS LIKE SOMETHING THAT SHOULD NEVER HAPPEN. AFTER GETTING THAT FIXED, I TAKE IT HOME. IT RUNS FINE FOR ABOUT 2 DAYS, AND THEN STARTS PULLING SOME CRAZY STUFF. THE SERVICE ENGINE SOON LIGHT CAME ON, ALTHOUGH THERE WEREN'T ANY NOTICEABLE ISSUES. THE LIGHT WENT OFF 2 DAYS LATER. AFTER THAT, I STARTED EXPERIENCING OTHER PROBLEMS. MY CAR HAS A SERIOUS LACK OF POWER WHEN GOING UP A HILL. IF I STEP ON THE GAS A LITTLE MORE, THE SERVICE ENGINE SOON LIGHT WILL FLASH. IT DOESN'T STAY ON, IT JUST FLASHES FOR ABOUT A MINUTE. WHENEVER I COME TO A STOP, MY CAR TENDS TO VIOLENTLY SHAKE. I'M AFRAID TO TAKE IT BACK TO THE DEALER TO SEE WHAT'S WRONG, BECAUSE I'M AFRAID I'LL HAVE TO PAY EVEN MORE MONEY FOR SOMETHING THAT WASN'T WRONG PRIOR TO TAKING IT THE 1ST TIME. *TR
I HAVE A 2001 GRAND-AM. THERE WAS A RECALL ON THE HAZARD LIGHT SWITCH #NHTSA RECALL CAMPAIGN NUMBER: 03V327000 COMPONENT: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH DETAILS: CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITION…
Read full complaint
I HAVE A 2001 GRAND-AM. THERE WAS A RECALL ON THE HAZARD LIGHT SWITCH #NHTSA RECALL CAMPAIGN NUMBER: 03V327000 COMPONENT: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH DETAILS: CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE. CONSEQUENCE: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH. CORRECTIVE ACTION: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537. UNITS POTENTIALLY AFFECTED: 670740 RECALL INITIATED BY: ODI DATE ADDED TO NHTSA DATABASE: 09/04/2003 I HAVE CALLED PONTIAC BECAUSE I AM HAVING THE EXACT PROBLEM BUT THEY SAY MY VIN PUTS MY CAR OUT OF THE ALMOST 700,000 CARS EFFECTED. WHAT CAN I DO? *TR
TL*CONTACT OWNS A 2001 PONTIAC GRAND AM. SHE NOTICED THAT THERE WAS A LEAK UNDER HER VEHICLE FOR A FEW YEARS. ON SEVERAL OCCASIONS THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE LEAK. THE DEALER LATER STATED THAT THE LEAK WAS COMING FROM THE GAS TANK LINE AND IT WAS A FUEL LEAK. THEY ALSO TOLD HER THAT THERE WAS A RELATED RECALL…
Read full complaint
TL*CONTACT OWNS A 2001 PONTIAC GRAND AM. SHE NOTICED THAT THERE WAS A LEAK UNDER HER VEHICLE FOR A FEW YEARS. ON SEVERAL OCCASIONS THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE LEAK. THE DEALER LATER STATED THAT THE LEAK WAS COMING FROM THE GAS TANK LINE AND IT WAS A FUEL LEAK. THEY ALSO TOLD HER THAT THERE WAS A RELATED RECALL; HOWEVER, HER VIN WAS NOT RELATED. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED AND REQUEST THAT HER VIN IS A PART OF THE EXISTING NHTSA CAMPAIGN ID NUMBER 07E021000. THE DEALER INFORMATION IS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 98,000. THE CONSUMER STATED THE VEHICLE IS STILL LOCATED AT THE REPAIR SHOP AWAITING WORD FROM THE CORP OFFICE. THE DEALER STATED REPLACED HAZARD LIGHTS SWITCH, SPEAKER RADIO REAR DOOR, MOLDING WINDSHIELD SIDE PILLAR, EXTERIOR BULBS, AND WIPER BLADE. UPDATED 10/31/07 *TR
I OWN A 2001 PONTIAC GRAND AM. I HAVE EXPERIENCED SEVERAL OF THE SAME PROBLEMS/ISSUES NOTED IN PREVIOUS COMPLAINTS. MY 1 AND 2 FUNCTION ON THE FAN IS NO LONGER WORKING, THE TURN SIGNALS APPEAR TO HAVE A SHORT/WIRING PROBLEM, THE DRIVER AND PASSENGER SIDE WINDOW MOTOR/BRACKETS NEEDED TO BE REPLACED, THE DRIVER SEAT ADJUSTER IS …
Read full complaint
I OWN A 2001 PONTIAC GRAND AM. I HAVE EXPERIENCED SEVERAL OF THE SAME PROBLEMS/ISSUES NOTED IN PREVIOUS COMPLAINTS. MY 1 AND 2 FUNCTION ON THE FAN IS NO LONGER WORKING, THE TURN SIGNALS APPEAR TO HAVE A SHORT/WIRING PROBLEM, THE DRIVER AND PASSENGER SIDE WINDOW MOTOR/BRACKETS NEEDED TO BE REPLACED, THE DRIVER SEAT ADJUSTER IS BROKEN, THE(GEAR SHAFT) BUTTON THAT PUTS THE CAR IN GEAR(P,R,N,D) POPS OUT FREQUENTLY, DRIVER FLOOR HAS BEEN SOAK AND WET PERIODICALLY, AND NUMEROUS BRAKING SYSTEM PROBLEMS(NEED TO REPLACE ROTORS AND BRAKE PADS FREQUENTLY, HAD TO REPLACE BRAKE CALIPERS/HUBS/WHEEL BEARINGS). THE ONLY PROBLEM THAT WAS COVERED UNDER A RECALL WAS THE TURNING SWITCH, WHICH THE PROBLEM HAS RE-OCCURRED. I WOULD LIKE TO SEE THE MANUFACTURER COVER THESE PROBLEMS THAT HAVE BECOME REPETITIVE IN SEVERAL OTHER VEHICLES. *JB
Official recalls
414V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V327000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
00V372000 · Power Train:manual Transmission
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available