NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
75 reportsClear category filter126,000 miles · Jul 1, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE TRYING TO START THE VEHICLE IN HEAVY RAINY WEATHER CONDITIONS, THE VEHICLE WOULD START AND WITHIN A FEW SECONDS, THE ENGINE WOULD STALL. THE FAILURE DOES NOT OCCUR UNLESS IT RAINS. THE DEALER ADVISED HIM TO HAVE A DIAGNOSTIC TEST PERFORMED. THE CONTACT…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE TRYING TO START THE VEHICLE IN HEAVY RAINY WEATHER CONDITIONS, THE VEHICLE WOULD START AND WITHIN A FEW SECONDS, THE ENGINE WOULD STALL. THE FAILURE DOES NOT OCCUR UNLESS IT RAINS. THE DEALER ADVISED HIM TO HAVE A DIAGNOSTIC TEST PERFORMED. THE CONTACT IS CONCERNED THAT THE VEHICLE WILL STALL IF HE ATTEMPTS TO DRIVE IT TO THE DEALER. GENERAL MOTORS CONFIRMED THAT THE FAILURE NEEDED TO BE DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000.
NHTSA ODI #10340996
Mileage unknown · Jan 2, 2010
Engine And Engine CoolingCrash
I HAVE REPLACED THE RADIATOR TWICE, THE WATER PUMP TWICE (GOING ON NUMBER 3 TOMORROW) AND ALSO GET TO DO AN INTAKE MANIFOLD GASKET. I OWN A 2001 PONTIAC GRAND AM. THE CAUSE HAS SINCE BEEN DISCOVERED AS THE DEX-COOL COOLANT THAT GM MANUFACTURES WHICH EATS ANYTHING IT COMES IN CONTACT WITH. RECALL NEEDS ISSUED, AND REPAIR WORK …
Read full complaint
I HAVE REPLACED THE RADIATOR TWICE, THE WATER PUMP TWICE (GOING ON NUMBER 3 TOMORROW) AND ALSO GET TO DO AN INTAKE MANIFOLD GASKET. I OWN A 2001 PONTIAC GRAND AM. THE CAUSE HAS SINCE BEEN DISCOVERED AS THE DEX-COOL COOLANT THAT GM MANUFACTURES WHICH EATS ANYTHING IT COMES IN CONTACT WITH. RECALL NEEDS ISSUED, AND REPAIR WORK PAID FOR. *TR
NHTSA ODI #10297790
123,000 miles · Jun 23, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE ENGINE WAS ABLE TO BE RESTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE OCCURRED ON FOUR MORE OCCASIONS. RECENTLY, THE ENGINE FAILED TO RESTART. THE VEHICLE IS…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE ENGINE WAS ABLE TO BE RESTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE OCCURRED ON FOUR MORE OCCASIONS. RECENTLY, THE ENGINE FAILED TO RESTART. THE VEHICLE IS CURRENTLY INOPERABLE AND HAS NOT BEEN REPAIRED. IN ADDITION, THE PASS LOCK SYSTEM WAS PREVIOUSLY REPLACED. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND CURRENT MILEAGES WERE 123,000.
NHTSA ODI #10274774
150,000 miles · Apr 17, 2009
Electrical SystemEngine And Engine CoolingExterior Lighting
RECALL NUMBER: 03V327000 DATES MANUFACTURED: MAR 2000 TO MAY 2001 NUMBER OF VEHICLES AFFECTED: 670740 DATE OWNERS NOTIFIED ON: FEB 2004 CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRAC…
Read full complaint
RECALL NUMBER: 03V327000 DATES MANUFACTURED: MAR 2000 TO MAY 2001 NUMBER OF VEHICLES AFFECTED: 670740 DATE OWNERS NOTIFIED ON: FEB 2004 CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE. I TRIED CALLING PONTIAC TODAY AND THEY REFUSED TO INSPECT MY CAR FREE OF CHARGE. THE ALSO TELL ME THAT THIS IS NOT A VALID RECALL NUMBER. I HAVE SEVAL ISSUES WITH MY CAR. I HAVE PAID SEVERAL THOUSANDS OF DOLLARS ON THIS CAR. *TR
NHTSA ODI #10265880
80,300 miles · Dec 29, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. DURING ROUTINE MAINTENANCE A TECHNICIAN STATED THAT UNDER PRESSURE OF THE INTAKE MANIFOLD WAS INOPERABLE AND NEEDED TO BE REPLACED. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST WHICH EXCEEDED $700.00. THE FAILURE AND CURRENT MILEAGES WERE 80,300. UPDATED 03/18/09. *LJ THE INTAKE…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. DURING ROUTINE MAINTENANCE A TECHNICIAN STATED THAT UNDER PRESSURE OF THE INTAKE MANIFOLD WAS INOPERABLE AND NEEDED TO BE REPLACED. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST WHICH EXCEEDED $700.00. THE FAILURE AND CURRENT MILEAGES WERE 80,300. UPDATED 03/18/09. *LJ THE INTAKE MANIFOLD GASKET WAS LEAKING AND NEEDED TO BE REPLACED. UPDATED 03/20/09. *JB
NHTSA ODI #10253074
89,000 miles · Dec 1, 2008
Engine And Engine CoolingVisibility
3 WINDOW REGULATOR ARE BROKEN ON DRIVER SIDE, AND PASSENGER. THE REAR WINDOW DEFROSTER ONLY DEFROST HALF THE WINDOW, INTERIOR LIGHTS DO NOT GO OFF WHEN THE SWITCH IS ON AUTO, ENGINE OVERHEATS, TURN SIGNALS DO NOT WORK, THE ENGINE IS HARD TO START . I HAVE NOT FIXED THE WINDOWS BUT I BEEN TO THE DEALERSHIP FOR THE OVERHEATING AND…
Read full complaint
3 WINDOW REGULATOR ARE BROKEN ON DRIVER SIDE, AND PASSENGER. THE REAR WINDOW DEFROSTER ONLY DEFROST HALF THE WINDOW, INTERIOR LIGHTS DO NOT GO OFF WHEN THE SWITCH IS ON AUTO, ENGINE OVERHEATS, TURN SIGNALS DO NOT WORK, THE ENGINE IS HARD TO START . I HAVE NOT FIXED THE WINDOWS BUT I BEEN TO THE DEALERSHIP FOR THE OVERHEATING AND I WAS TOLD THERE WAS NO PROBLEMS. I HAD TO REPLACE THE FUEL PUMP BECAUSE THE CAR WOULD NOT START. THESE ISSUES BEGAN OVER A YEAR AGO. *TR
NHTSA ODI #10250229
17,373 miles · Aug 29, 2008
Engine And Engine Cooling
PROBLEM: INTAKE MANIFOLD GASKET FAILURE AND PASSLOCK SYSTEM MALFUNCTION DESCR: PURCHASED CAR IN 1/01, DOCUMENTED LEAK OF COOLANT IN NOV. '01. NOTHING COULD BE FOUND. IN 2003, AFTER I TOLD THEM WHERE THE LEAK WAS COMING FROM, THEY FOUND THE PROBLEM AND REPLACED THE GASKET. THIS IS A SAFETY ISSUE FOR ME BECAUSE I WAS A DIVO…
Read full complaint
PROBLEM: INTAKE MANIFOLD GASKET FAILURE AND PASSLOCK SYSTEM MALFUNCTION DESCR: PURCHASED CAR IN 1/01, DOCUMENTED LEAK OF COOLANT IN NOV. '01. NOTHING COULD BE FOUND. IN 2003, AFTER I TOLD THEM WHERE THE LEAK WAS COMING FROM, THEY FOUND THE PROBLEM AND REPLACED THE GASKET. THIS IS A SAFETY ISSUE FOR ME BECAUSE I WAS A DIVORCED MOTHER WITH A SMALL CHILD WHO DRIVES ALMOST 300 MILES EACH WEEK TO WORK AND BACK. AFTER SOME ARGUING THE DEALER COVERED THE COST, EXCEPT FOR A 200 DEDUCTIBLE. IN JANUARY 2007, THE SAME THING HAPPENED AGAIN - THIS TIME COSTING ME $900.00. THE NEXT SAFETY ISSUE IS THE PASSLOCK SYSTEM ON THE CAR. THE LATEST STRANDING OCCURRED ON WEDNESDAY, AUGUST 27, 2008. I HAVE BEEN "STRANDED" THREE OR FOUR TIMES BECAUSE THE CAR WOULD CRANK BUT WOULD NOT TURN OVER. TWO OR THREE TIMES, THE CAR HAS HAD TO BE TOWED TO THE DEALERSHIP. I BOUGHT THIS CAR, MY FIRST NEW CAR, BECAUSE I NEEDED SOMETHING RELIABLE. EVERYTIME THE CAR HAS BROKEN DOWN, I HAVE MISSED TIME FROM WORK, HAVE HAD TO PAY SEVERAL TIMES TO HAVE THE CAR TOWED (THANKFULLY INSURANCE HAS COVERED SOME OF THAT) AND HAD TO PAY FOR REPAIRS. *TR
NHTSA ODI #10240192
54,000 miles · Aug 20, 2008
Engine And Engine Cooling
WHILE DRIVING CAR, THE ENGINE JUST STOPS/STALLS. IT HAS ONLY HAPPENED SO FAR WHEN SLOWING TO STOP. I AM ABLE TO IMMEDIATELY RESTART IT AFTER SHIFTING TO PARK OR NEUTRAL. *TR
NHTSA ODI #10238973
77,058 miles · May 15, 2008
Engine And Engine Cooling
CHANGE OIL LIGHT WILL COME ON EARLY, ABOUT AFTER 1,000 MILES - BEFORE THE TYPICAL 3,000 MILES OIL SHOULD BE CHANGED (I CHANGE MY OIL EVERY 3,000 MILES). *TR
NHTSA ODI #10227862
77,000 miles · Feb 23, 2008
Engine And Engine CoolingEquipment
A FEW YEARS BACK, I HAD A PROBLEM IN WHICH MY RPMS WOULD RISE INSANELY WHEN I WAS STOPPED AT A LIGHT, AND EVEN WHEN I PUT MY CAR IN PARK. IT WAS AS IF I WAS "FLOORING IT". I TOOK IT TO THE DEALER. THEY SAID IT WAS A HEAD GASKET PROBLEM. LUCKILY, IT WAS STILL UNDER WARRANTY, AS I ONLY HAD ABOUT 45,000 MILES ON IT. I TOOK IT HOME …
Read full complaint
A FEW YEARS BACK, I HAD A PROBLEM IN WHICH MY RPMS WOULD RISE INSANELY WHEN I WAS STOPPED AT A LIGHT, AND EVEN WHEN I PUT MY CAR IN PARK. IT WAS AS IF I WAS "FLOORING IT". I TOOK IT TO THE DEALER. THEY SAID IT WAS A HEAD GASKET PROBLEM. LUCKILY, IT WAS STILL UNDER WARRANTY, AS I ONLY HAD ABOUT 45,000 MILES ON IT. I TOOK IT HOME AFTER IT WAS "FIXED", AND IT CONTINUED TO DO THE SAME THING. I TOOK IT BACK TO THE DEALER, AND THEY SAID THAT THEY FIXED THE PROBLEM AND THAT IT WILL BE OK. I TOOK IT BACK HOME AND IT HAS PRETTY MUCH NEVER STOPPED. IT TENDS TO DO IT MORE IN THE SUMMER AS OPPOSED TO THE WINTER. RECENTLY, THE CAR WAS LEAKING COOLANT. I TOOK IT BACK TO THE DEALER. I WAS ONCE AGAIN TOLD THAT IT WAS THE HEAD GASKET. MY CAR IS NO LONGER UNDER WARRANTY, SO I HAD TO PAY $1600 TO GET IT FIXED. 2 HEAD GASKET PROBLEMS WITHIN A MATTER OF 2 YEARS? THAT SEEMS LIKE SOMETHING THAT SHOULD NEVER HAPPEN. AFTER GETTING THAT FIXED, I TAKE IT HOME. IT RUNS FINE FOR ABOUT 2 DAYS, AND THEN STARTS PULLING SOME CRAZY STUFF. THE SERVICE ENGINE SOON LIGHT CAME ON, ALTHOUGH THERE WEREN'T ANY NOTICEABLE ISSUES. THE LIGHT WENT OFF 2 DAYS LATER. AFTER THAT, I STARTED EXPERIENCING OTHER PROBLEMS. MY CAR HAS A SERIOUS LACK OF POWER WHEN GOING UP A HILL. IF I STEP ON THE GAS A LITTLE MORE, THE SERVICE ENGINE SOON LIGHT WILL FLASH. IT DOESN'T STAY ON, IT JUST FLASHES FOR ABOUT A MINUTE. WHENEVER I COME TO A STOP, MY CAR TENDS TO VIOLENTLY SHAKE. I'M AFRAID TO TAKE IT BACK TO THE DEALER TO SEE WHAT'S WRONG, BECAUSE I'M AFRAID I'LL HAVE TO PAY EVEN MORE MONEY FOR SOMETHING THAT WASN'T WRONG PRIOR TO TAKING IT THE 1ST TIME. *TR
NHTSA ODI #10218950
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration