IllustrationWAS DRIVING DOWN CITY STREET CAR WAS IN MOTION AND CAR DIED LEAVING ME WITH NO STEERING OR POWER. HAS NOT STARTED SINCE. HAVE NARROWED DOWN TO IGNITION OR SECURITY IT HAS KILLED A BATTERY. TURNS OVER BUT WILL NOT START. GETTING VERY COSTLY.
2001 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 2001 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
6525–50K
7750–75K
6375–100K
75100–150K
31150K+
343 reports with mileage · 195 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 232 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports4 fire reports14 injury reports
Electrical System complaints
232 reportsTL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD INTERMITTENTLY SHUT OFF. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AND STATED THAT THE IGNITION SWITCH NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE DEALER AND MANUFACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD INTERMITTENTLY SHUT OFF. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AND STATED THAT THE IGNITION SWITCH NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE TURN SIGNALS FAILED TO OPERATE. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY OVER THE COURSE OF THREE MONTHS. ON SEVERAL OCCASIONS, THE CONTACT ENGAGED THE HAZARD LIGHTS TO TEMPORARILY CORRECT THE F…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE TURN SIGNALS FAILED TO OPERATE. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY OVER THE COURSE OF THREE MONTHS. ON SEVERAL OCCASIONS, THE CONTACT ENGAGED THE HAZARD LIGHTS TO TEMPORARILY CORRECT THE FAILURE. A DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. IN ADDITION, THE CONTACT WAS PROVIDED WITH SERVICE REQUEST NUMBER: 8-470-818-4180. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000.
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE THE VEHICLE WAS IN THE LEFT TURNING LANE, THE CONTACT NOTICED THAT THE TURN SIGNALS DID NOT WORK. THE TURN SIGNALS SEEMED TO OPERATE AFTER THE TURN SIGNAL SWITCH WAS MANEUVERED SEVERAL TIMES. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECT…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE THE VEHICLE WAS IN THE LEFT TURNING LANE, THE CONTACT NOTICED THAT THE TURN SIGNALS DID NOT WORK. THE TURN SIGNALS SEEMED TO OPERATE AFTER THE TURN SIGNAL SWITCH WAS MANEUVERED SEVERAL TIMES. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE CONTACT CALLED ETTLESON BUICK GMC AT (708) 215-7213 (LOCATED AT 6201 S LA GRANGE ROAD, HODGKINS, IL 60525), BUT THE PARTS WERE NOT AVAILABLE FOR THE REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 123,000. PARTS DISTRIBUTION DISCONNECT. *TT *JS
ON THREE SEPARATE OCCASIONS IN THE PAST TWO MONTHS, MY VEHICLE HAS TURNED OFF WHILE DRIVING. THE STEERING WHEEL LOCKED UP AND THE CAR TURNED OFF. ON ALL THREE OCCASIONS I WAS COMING EITHER TO A STOP SIGN OR TRAFFIC LIGHT WITH MY FOOT ON THE BRAKE, ABOUT TO MAKE A RIGHT TURN. THANKFULLY, I WAS NOT YET IN THE INTERSECTION WHEN …
Read full complaint
ON THREE SEPARATE OCCASIONS IN THE PAST TWO MONTHS, MY VEHICLE HAS TURNED OFF WHILE DRIVING. THE STEERING WHEEL LOCKED UP AND THE CAR TURNED OFF. ON ALL THREE OCCASIONS I WAS COMING EITHER TO A STOP SIGN OR TRAFFIC LIGHT WITH MY FOOT ON THE BRAKE, ABOUT TO MAKE A RIGHT TURN. THANKFULLY, I WAS NOT YET IN THE INTERSECTION WHEN THIS HAPPENED. I BELIEVE THE ISSUE IS RELATED TO THE IGNITION SWITCH RECALL ISSUED BY GM. SOME TIME IN 2015 I DID MAKE AN APPOINTMENT WITH NORTHSTAR CHEVROLET IN CLIFTON PARK, NY TO HAVE THE ISSUE RESOLVED, ASSUMING THAT THEY WERE ACTUALLY GOING TO REPAIR THE IGNITION. I NOTIFIED THEM THAT I DID HAVE ISSUES WITH TURNING THE KEY WHEN TRYING TO TURN THE CAR ON. THEY SAID IT WAS NOT RELATED, THAT IT WAS AN OLD CAR AND THE IGNITION HAD WORN A CERTAIN WAY - THAT'S WHY THE KEY DIDN'T ALWAYS TURN EASILY. THEY SAID THE RECALL REPAIR WAS TO MAKE THE HOLE IN THE KEY SMALLER SO THAT I COULDN'T HAVE HEAVY ITEMS ATTACHED TO MY KEY. THEY LOOKED AT WHAT I DID HAVE ON MY KEY CHAIN AND SAID THE WEIGHT SHOULD BE FINE, IT WAS MAINLY FOR PEOPLE THAT HAD DOZENS OF KEYS OR VERY HEAVY ITEMS ON THE KEY RING. I LEFT WITHOUT ANY CHANGES TO MY KEY. NOW, IN MARCH AND APRIL 2017 I'VE HAD MORE SERIOUS ISSUES WITH MY CAR TURNING OFF. I ALSO HAVE PROBLEMS WITH TURNING MY CAR ON IF THE KEY IS NOT PUSHED UP IN THE IGNITION BEFORE BEING TURNED. THIS IS THE CASE EVEN WITHOUT ANYTHING ELSE ATTACHED TO THE KEY WHEN TRYING TO TURN THE CAR ON. I AM FEARFUL OF DRIVING MY CAR WITHOUT HAVING THIS PROPERLY REPAIRED, YET THE DEALERSHIP INSISTS THAT THEY ARE ONLY PERMITTED TO PERFORM THE SPECIFIED REPAIR TO THE KEY ITSELF, BUT WILL NOT BE ABLE TO MAKE ANY REPAIRS TO THE CAR ITSELF UNDER THE RECALL, EVEN THOUGH IT'S THE IGNITION SWITCH ON THE CAR THAT IS NOT MAKING PROPER CONTACT TO TURN THE CAR ON. I NEED MY FAULTY IGNITION SWITCH REPLACED BEFORE I HAVE AN ACCIDENT.
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING, THE DRIVER AND PASSENGER SIDE TURN SIGNALS FAILED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
BLINKERS JUST STOP WORKING SOMTIMES FOR HOURS AND THEN BACK ON WHILE DRIVING AND A CADILLAC CONVERTER IS MAKING NOISE.
WE ARE HAVING ISSUES WHEN WE USE OUR TURN SIGNALS. MOST OF THE TIME OUR SIGNALS DON'T WON'T WORK UNLESS WE WIGGLE (WITH FORCE) OUR HAZARD LIGHT BUTTON. THEN WE HEAR BUZZING AND CRACKLING THAT IS MOSTLY CONTINUOUS IN OUR HAZARD BUTTON. THIS HAPPENS WHEN WE ARE DRIVING OR SITTING STILL. IT DOES STOP CLICKING WHEN WE SHUT THE CAR O…
Read full complaint
WE ARE HAVING ISSUES WHEN WE USE OUR TURN SIGNALS. MOST OF THE TIME OUR SIGNALS DON'T WON'T WORK UNLESS WE WIGGLE (WITH FORCE) OUR HAZARD LIGHT BUTTON. THEN WE HEAR BUZZING AND CRACKLING THAT IS MOSTLY CONTINUOUS IN OUR HAZARD BUTTON. THIS HAPPENS WHEN WE ARE DRIVING OR SITTING STILL. IT DOES STOP CLICKING WHEN WE SHUT THE CAR OFF, BUT DOES OFTEN CONTINUE WHEN WE START OUR CAR BACK OFF. THE CRACKLING/BUZZING NOISE HAS WENT ON FOR AS LONG AS 15 MINUTES . I'M SURE IT WOULD HAVE GONE ON FOR LONGER, BUT WE WIGGLED THE HAZARD BUTTON AND PLACES A FOLDED PIECE OF PAPER TO LODGE IT QUIET. WE HAVE AN EXTREMELY HARD TIME USING OUR TURN SIGNALS AT TIMES, THEY JUST QUIT WORKING UNLESS WE WIGGLE OUR HAZARD LIGHT BUTTON.. ALL OF THIS HAPPENS WITH NORMAL DAY TO DAY DRIVING. *TR
'M WRITING TO NOTIFY GM ABOUT A DANGEROUS ISSUE WITH MY 2001 PONTIAC GRAND AM. THE SECURITY SYSTEM ACTIVATES PREVENTING THE CAR TO STOP FOR 10 MINUTES UNTIL IT RESETS, CAUSING MANY WORK RELATED ISSUES. THIS SECURITY ISSUE PREVENTS THE FUEL PUMP FROM ACTIVATING, ALLOWING THE CAR TO START. THE PROBLEM HAS GOTTEN SO SEVERE, THE C…
Read full complaint
'M WRITING TO NOTIFY GM ABOUT A DANGEROUS ISSUE WITH MY 2001 PONTIAC GRAND AM. THE SECURITY SYSTEM ACTIVATES PREVENTING THE CAR TO STOP FOR 10 MINUTES UNTIL IT RESETS, CAUSING MANY WORK RELATED ISSUES. THIS SECURITY ISSUE PREVENTS THE FUEL PUMP FROM ACTIVATING, ALLOWING THE CAR TO START. THE PROBLEM HAS GOTTEN SO SEVERE, THE CAR NOW SHUTS DOWN MID DRIVE WHILE ON THE INTERSTATE. LIVING IN LOUISVILLE, TN AWAY 10 HOURS FROM HOME, I HAVE NO OTHER CHOICE BUT TO KEEP USING THIS VEHICLE TO GET BACK AND FORTH FROM WORK. NOW I'M FORCED TO REMAIN IN THE OUTSIDE LANE TO QUICKLY GET OVER ONTO THE SHOULDER WHEN THE CAR SHUTS OFF. THIS HAS HAPPENED NO LESS THAN 15 TIMES A WEEK, ALMOST CAUSING AN ALMOST FATAL ACCIDENT. I'VE BEEN TO A TRUSTED MECHANIC WHERE WE REPLACED THE ECM TWO SEPARATE TIMES, BUT THE ISSUE STILL PERSISTS. HAS THERE BEEN MANY ISSUES REPORTED ABOUT THE CAR STOPPING IN THE MIDDLE OF A DRIVE?
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHEN THE VEHICLE'S IGNITION WAS MANUALLY TURNED TO THE OFF POSITION, THE KEY SLIPPED OUT OF THE IGNITION. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE KEY WOULD FALL OUT OF THE IGNITION. THE CONTACT DID NOT FEEL SAFE DRIVING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AN…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHEN THE VEHICLE'S IGNITION WAS MANUALLY TURNED TO THE OFF POSITION, THE KEY SLIPPED OUT OF THE IGNITION. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE KEY WOULD FALL OUT OF THE IGNITION. THE CONTACT DID NOT FEEL SAFE DRIVING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 130,000.
Official recalls
414V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V327000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
00V372000 · Power Train:manual Transmission
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available