IllustrationTHERE IS DRAIN TUBING CONNECTED TO THE SUNROOF THAT COMES UNCONNECTED BECAUSE ITS TOO SHORT AND LEAKS/POURS WATER ALL OVER THE PASSENGER FRONT AND BACK SIDE OF THE VEHICLE. IT HAPPENS WHETHER YOURE DRIVING IT OR ITS SITTING STILL. WATER JUST POURS IN AND SOAKS EVERYTHING ON PASSENGER SIDE.
2005 Pontiac G6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Pontiac G6 do not stand out strongly from the model-year median of 679.
About this comparison →How this year compares
Owner complaints by model year
Compare all G6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
7625–50K
10550–75K
11075–100K
140100–150K
76150K+
574 reports with mileage · 105 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports4 fire reports13 injury reports
Structure complaints
14 reportsTL* THE CONTACT OWNS A 2005 PONTIAC G6. THE CONTACT STATED THAT THE ROOF FAILED AND CAUSED WATER TO ENTER INTO THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE WATER WOULD DAMAGE THE CARPET, DASHBOARD, AND ELECTRICAL SYSTEM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2005 PONTIAC G6. THE CONTACT STATED THAT THE ROOF FAILED AND CAUSED WATER TO ENTER INTO THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE WATER WOULD DAMAGE THE CARPET, DASHBOARD, AND ELECTRICAL SYSTEM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. *TT
TL*THE CONTACT OWNS A 2005 PONTIAC G6. THE CONTACT STATED THAT DURING INCLEMENT WEATHER CONDITIONS, WATER LEAKED INTO THE INTERIOR OF THE VEHICLE, WHICH CAUSED ELECTRICAL ISSUES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ENTIRE WEATHER STRIPPING WAS REPLACED. THREE MONTHS AFTER THE REPAIR WAS PERFORMED THE FAILU…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC G6. THE CONTACT STATED THAT DURING INCLEMENT WEATHER CONDITIONS, WATER LEAKED INTO THE INTERIOR OF THE VEHICLE, WHICH CAUSED ELECTRICAL ISSUES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ENTIRE WEATHER STRIPPING WAS REPLACED. THREE MONTHS AFTER THE REPAIR WAS PERFORMED THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 7,000.
BOTH SIDES OF THE PANORAMIC SUN ROOF HAS COME UNATTACHED AND LEAKED IN MY FLOOR ON MULTIPLE OCCASIONS AND IS VERY DISTRACTING GETTING DRIPPED ON AND WILL EVENTUALLY CAUSE A WRECK. WORST CAR EVER!!!!! ALSO THE BRAKES ARE TERRIBLE. I'VE DONE SO MUCH WORK MYSELF TO MY BRAKES AND HAD SHOPS DO SOME TOO BECAUSE I CANNOT AFFORD TO REPL…
Read full complaint
BOTH SIDES OF THE PANORAMIC SUN ROOF HAS COME UNATTACHED AND LEAKED IN MY FLOOR ON MULTIPLE OCCASIONS AND IS VERY DISTRACTING GETTING DRIPPED ON AND WILL EVENTUALLY CAUSE A WRECK. WORST CAR EVER!!!!! ALSO THE BRAKES ARE TERRIBLE. I'VE DONE SO MUCH WORK MYSELF TO MY BRAKES AND HAD SHOPS DO SOME TOO BECAUSE I CANNOT AFFORD TO REPLACE THE [XXX] THROUGH A SHOP EVER 6 MO. MY PASSENGER SIDE ROTOR LOCKED UP FOR NO REASON 2 DIFF. SHOPS COULDN'T FIND A REASON. THE BLEEDING PROCESS IS RIDICULOUS AND THE BRAKES DO NOT LAST MORE THAN 4-6 MO TOPS NO MATTER HOW YOU BRAKE ON THEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
2005 PONTIAC G6 - WATER POURS FROM THE INTERIOR LIGHTS SPLASHING THE INSIDE OF THE CAR AND DRIVER WHICH IS AS UNEXPECTED AS A CHILD RUNNING IN FRONT OF A VEHICLE. THE SUDDEN DOWNPOUR MAY CAUSE THE DRIVER TO LOOSE CONTROL OF THE VEHICLE WHEN THEY LOOK UP TO SEE WHERE THE WATER IS COMING FROM.. NOBODY WAS INJURED IN MY INCIDENT HO…
Read full complaint
2005 PONTIAC G6 - WATER POURS FROM THE INTERIOR LIGHTS SPLASHING THE INSIDE OF THE CAR AND DRIVER WHICH IS AS UNEXPECTED AS A CHILD RUNNING IN FRONT OF A VEHICLE. THE SUDDEN DOWNPOUR MAY CAUSE THE DRIVER TO LOOSE CONTROL OF THE VEHICLE WHEN THEY LOOK UP TO SEE WHERE THE WATER IS COMING FROM.. NOBODY WAS INJURED IN MY INCIDENT HOWEVER, THE WATER IS COMING FROM THE DRAIN TUBES FROM THE TOP OF THE CAR WHICH HAVE A TENDANCY TO BECOME DISCONNECTED. I AM TOLD THIS IS NOT CONSIDERED A SAFETY HAZARD BUT A DRIVER DOES NOT EXPECT TO BE SUDDENLY SOAKED BY WATER WHEN DRIVING A CAR AND CAN CAUSE THE DRIVER TO BECOME RECKLESS WHICH MAY CAUSE DAMAGE OR INJURY TO A VEHICLE OR A PERSON IF IT HAS NOT ALREADY. THIS IS A COMMON PROBLEM AND NEEDS TO SERIOUSLY CONSIDERED AS A SAFETY HAZARD. OTHER THAN THE SAFETY HAZARD THAT IT IS, IT ALSO CAUSES THE INTERIOR OF THE CAR TO BE COMPLETELY DESTROYED FROM MOLD AND/OR MILDEW NEEDING COMPLETE REPLACEMENT. THE DEALERS ARE VERY MUCH AWARE OF THE PROBLEM BUT YET I HAVE TAKEN MY CAR IN TWICE AND BECAUSE IT WASN'T LEAKING AT THE TIME, THE COULD NOT SEE A PROBLEM. MIND YOU THE BACK FLOORBOARD AND SEAT WERE COMPLETELY SOAKED FROM 8 GALLONS OF WATER WHICH HAD BEEN SUCKED OUT OF THE CAR PRIOR TO DRIVING IT TO THE DEALERSHIP. *TR
BOTH THE DRIVER & REAR PASSENGER HAVE WATER DAMAGE DUE TO A FAULTY MFGD SUNROOF. IT LEAKS WHEN IT RAINS AND WHEN I CONTACTED GM THEY SAID THAT THEY CANNOT COVER THE DIAGNOSTIC CHARGE FOR THE VEHICLE INSPECTION. *TR
THE SEAL ON MY PANORAMIC ROOF LEAKED DURING A TORRENTIAL DOWNPOUR. I DID NOT DRIVE THE CAR FOR A FEW DAYS BECAUSE OF HAVING SURGERY. 2 DAYS AFTER THE RAIN STORM WHEN I OPENED MY CAR I FOUND AN INCH OF WATER COVERING THE FLOOR AND MOLD COVERING MOST OF THE INTERIOR. MOLD WAS ALSO LOCATED INSIDE THE AIR CONDITIONING SYSTEM WHEN TU…
Read full complaint
THE SEAL ON MY PANORAMIC ROOF LEAKED DURING A TORRENTIAL DOWNPOUR. I DID NOT DRIVE THE CAR FOR A FEW DAYS BECAUSE OF HAVING SURGERY. 2 DAYS AFTER THE RAIN STORM WHEN I OPENED MY CAR I FOUND AN INCH OF WATER COVERING THE FLOOR AND MOLD COVERING MOST OF THE INTERIOR. MOLD WAS ALSO LOCATED INSIDE THE AIR CONDITIONING SYSTEM WHEN TURNED ON. THE HEATED SEATS WERE RUINED AS WERE ANY ELECTRICAL DEVICES INSIDE THE CAR. ALL PERSONAL ITEMS AND INFANT SEAT WERE ALSO RUINED. I AM STILL WAITING TO HEAR WHAT IS GOING TO BE DONE. THEY ARE TRYING TO CONVINCE ME IT CAN BE CLEANED, BUT WITH THE AMOUNT OF MOLD AND MY EXISTING ASTHMA IT IS A DETRIMENT TO MY HEALTH TO BE INSIDE THE VEHICLE. I ALSO HAVE AN INFANT WHICH CANNOT COME INTO THE VEHICLE AT ALL BECAUSE OF SAID MOLD. I STILL DON'T KNOW AFTER CONTACTING GM IF THEY WILL FIX THE PROBLEM OR IF I NEED TO SCRAP THE CAR. THIS IS THE SECOND PROBLEM I HAVE HAD, HOWEVER THE FIRST INVOLVED THE BRAKE ROTORS GRINDING TOO QUICKLY AND CAUSING THE CAR TO SHAKE VIOLENTLY WHEN BRAKING AT ANY SPEED. I HAVE HAD TO HAVE THE BRAKES DONE AT LEAST EVERY 3 MONTHS TO CORRECT THE PROBLEM FOR THE PAST 2 AND A HALF YEARS. *TR
I TOOK A LEASE OVER OF A 2005 G6 LESS THAN A YEAR AGO. I HAVE HAD NOTHING BUT PROBLEMS WITH IT FROM THE VERY BEGINNING. A LOT OF TIMES IT DOESN'T START JUST SPUTTERS REPEATEDLY. TOOK IT IN TO GET IT CHECKED OUT OF COURSE THEY SAY THEY CAN'T FIND ANYTHING WRONG. RIGHT AFTER WE GOT THE CAR WE HAD TO HAVE THE BRAKES REPLACED AND AL…
Read full complaint
I TOOK A LEASE OVER OF A 2005 G6 LESS THAN A YEAR AGO. I HAVE HAD NOTHING BUT PROBLEMS WITH IT FROM THE VERY BEGINNING. A LOT OF TIMES IT DOESN'T START JUST SPUTTERS REPEATEDLY. TOOK IT IN TO GET IT CHECKED OUT OF COURSE THEY SAY THEY CAN'T FIND ANYTHING WRONG. RIGHT AFTER WE GOT THE CAR WE HAD TO HAVE THE BRAKES REPLACED AND ALSO THERE WAS A CLUNKING NOISE. HAD TO HAVE BOTH RIGHT AND LEFT FRONT STRUTS REPLACED. CLUNKING NOISE STILL HAD NOT GONE AWAY, EVERYTIME I TAKE IT IN I COMPLAIN OF THE CLUNKING AND EACHTIME THEY SAY IT IS DUE TO SOMETHING ELSE THAT NEEDS TO BE REPLACED. HAVE HAD A PULSATION PROBLEM WHEN BRAKES APPLIED. POWER STEERING WENT ON IT QUITE A FEW TIMES, HAD IT REPLACED AND HAS DONE IT SINCE. THE REARVIEW MIRROR SNAPPED RIGHT OFF WHEN BEING ADJUSTED. VISOR COVER SNAPPED OFF. DOOR LOCK KNOB SNAPPED OFF. MOST OF THE WORK WE HAVE HAD DONE WAS COVERED BY WARRANTY. THE WARRANTY IS NOW UP AND THE RIGHT BALL BEARING NOW NEEDS TO BE REPLACED WHICH IS WHY I HEAR CLUNKING IS WHAT I WAS TOLD. HOW COME IT IS ALWAYS SOMETHING DIFFERENT CAUSING THE CLUNKING NOISE? IS GOING TO COST AROUND $500 TO FIX. WHAT A PIECE OF JUNK. WE WILL NEVER BUY ANOTHER NORTH AMERICAN MADE PIECE OF JUN AGAIN!!! *TR
I OWN A 2005 PONTIAC G-6 WITH ABOUT 60,000 MILES . BOUGHT THE CAR USED AND HAVE ONLY PUT ABOUT 10,000 MILES ON IT. IT HAS A PANORAMIC SUNROOF THAT WAS WORKING FINE FOR ABOUT 6 MONTHS AND ALL OF A SUDDEN GETS STUCK . MY FIRST PANEL IS OPEN.. WANTS TO WORK BUT LOOKS OUT OF LINE WITH THE OTHER PANELS. TOOK IT TO THE DEALERSHIP AND …
Read full complaint
I OWN A 2005 PONTIAC G-6 WITH ABOUT 60,000 MILES . BOUGHT THE CAR USED AND HAVE ONLY PUT ABOUT 10,000 MILES ON IT. IT HAS A PANORAMIC SUNROOF THAT WAS WORKING FINE FOR ABOUT 6 MONTHS AND ALL OF A SUDDEN GETS STUCK . MY FIRST PANEL IS OPEN.. WANTS TO WORK BUT LOOKS OUT OF LINE WITH THE OTHER PANELS. TOOK IT TO THE DEALERSHIP AND THEY SAY THAT IT IS "COMING APART" AND THEY HAVE TO REPLACE IT . I DON'T HAVE AN EXT WARRANTY SO IM QUOTED $1,400 TO REPLACE THE WHOLE THING. WENT TO ANOTHER PLACE THEY SAY THAT SAME THING, I HAVE TO REPLACE IT. I AM ABOUT TO GET THIS THING FIXED FOR ABOUT $ 800 OR SO FOR A USED ONE. JUST RECENTLY I SPENT $700.00 REPLACING MY STEERING COLUMN DUE TO POWER STEERING FAILURE. I HAVE HAD THE CAR FOR LESS THAN 1 YR AND I HAVE HAD PROBLEM AFTER PROBLEM WITH IT ! I HATE THIS CAR AND PLAN ON TRADING IT IN SOON.... *TR
TOO MANY COMPLAINTS TO WRITE THEM ALL UP, HERE ARE A FEW: ENGINE MAKES METAL GRINDING "WHOOSHING" NOISE INDEPENDENT FROM ACCELERATION-DEALER CANNOT REPLICATE, WARPED ROTORS-DEALER WANTED OVER $1,000 TO FIX, HAVE HAD RADIO REPLACED 5 TIMES DUE TO DISC ERRORS-DEALER KEEPS REPLACING, HAD STEERING RACK AND WATER PUMP REPLACED AT 30,…
Read full complaint
TOO MANY COMPLAINTS TO WRITE THEM ALL UP, HERE ARE A FEW: ENGINE MAKES METAL GRINDING "WHOOSHING" NOISE INDEPENDENT FROM ACCELERATION-DEALER CANNOT REPLICATE, WARPED ROTORS-DEALER WANTED OVER $1,000 TO FIX, HAVE HAD RADIO REPLACED 5 TIMES DUE TO DISC ERRORS-DEALER KEEPS REPLACING, HAD STEERING RACK AND WATER PUMP REPLACED AT 30,000 MILES-DEALER COVERED, SENSOR THAT TURNS ON LIGHTS WENT-DEALER REPLACED, POWER STEERING PROBLEMS, HARD TO TURN AND ROUGH, BUT NO "LOCK-UPS" LIKE OTHERS HAVE HAD(THANKFULLY)-DEALER CANNOT REPLICATE, HAD DRIVERS SIDE FRONT PANEL SUNROOF DRAIN CLOG, WATER SOAKED FRONT CARPET(3 INCHES OF WATER)-DEALER FIXED BUT LEFT ME WITH A MOLDY CARPET!, ENGINE FLUTTERS/STUTTERS TO A START ON RANDOM-DEALER HAS NO ANSWER FOR ME, TRUNK LID WAS SCRAPING REAR BUMPER DUE TO LATCHES BEING TIGHTENED WRONG-DEALER FIXED, HEADLAMP FULL OF CONDENSATION-DEALER FIXED, CAR RIDICULOUSLY BAD IN THE RAIN AND SNOW, STABILITY CONTROL MAKES LOUD GRINDING NOISES AND CAUSES THE CAR TO BUCK, REPLACED TIRES WITH SNOW TIRES, STILL BAD-DEALER HAS NO ANSWER FOR ME, LARGE DEEP SCRATCH ACROSS WINDSHIELD RIGHT IN THE LINE OF VIEW FROM CONTOUR OEM WINDSHIELD WIPERS, DEALER SAID TOO BAD. THOSE ARE JUST A FEW, I CANT REMEMBER THEM ALL, THIS CAR IS SUCH A LEMON. IM STICKING WITH TOYOTA FROM NOW ON! I LEARNED MY LESSON! *TR
Official recalls
514V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
09V036000 · Exterior Lighting:brake Lights
Jan 30, 2009
GM IS RECALLING 8,012 MY 2005-2006 PONTIAC G6 VEHICLES. THE BRAKE LAMPS MAY NOT OPERATE PROPERLY BECAUSE OF CORROSION IN A WIRING CONNECTOR. CORROSION IN THE CONNECTOR COULD CAUSE THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKE PEDAL HAS NOT BEEN DEPRESSED, OR THE LAMPS MAY NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. IN ADDITION, THE CRUISE CONTROL MAY NOT ENGAGE, AND GREATER BRAKE PEDAL FORCE MAY BE REQUIRED TO SHIFT THE VEHICLE OUT OF PARK.
Consequence & remedy
Consequence: BRAKE LAMPS THAT ARE NOT OPERATING PROPERLY MAY NOT WARN A DRIVER IN A FOLLOWING VEHICLE OF THE BRAKING STATUS AND COULD LEAD TO A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL APPLY A DIELECTRIC LUBRICANT TO THE CONNECTOR TO PREVENT CORROSION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2009. OWNERS MAY CONTACT PONTIAC AT 1- 800-620-7668 OR OWNER CENTER AT WWW.GMOWNERCENTER.COM.
05V098000 · Equipment:other:owners/service/other Manual
Mar 14, 2005
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THE CHILD RESTRAINT LOWER ANCHORS IN THE CENTER REAR SEATING POSITION ARE LOCATED APPROXIMATELY 90MM BEHIND THE CORRESPONDING Z-POINT OF THE CHILD RESTRAINT FIXTURE (CRF). THE OWNER'S MANUAL STATES THAT ANCHORS ARE AT THE OUTBOARD SEATING POSITIONS ONLY.
Consequence & remedy
Consequence: WITHOUT ADDITIONAL AND CORRECTED OWNER'S MANUAL INFORMATION, AN OWNER MAY ENCOUNTER DIFFICULTY IN INSTALLING CHILD RESTRAINTS WITH RIGID ATTACHMENTS IN THE CENTER POSITION.
Remedy: OWNERS WILL BE MAILED AN OWNER'S MANUAL SUPPLEMENT. THE RECALL IBEGAN ON MARCH 20, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA13005 · Brake Light Switch/sensor Malfunction
Opened Jun 6, 2013 · Closed Jul 1, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
RQ13001 · Brake Light Malfunction
Opened Feb 4, 2013 · Closed Jun 6, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
PE08054 · Stop Lamp Malfunction
Opened Sep 15, 2008 · Closed Jan 30, 2009
Status: closed (inferred from source dates) · Electrical System:software; Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Additional source detail variants (2)
Electrical System:software
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
PE07023 · Loss Of Power Steering Assist
Opened Apr 25, 2007 · Closed Sep 25, 2007
Status: closed (inferred from source dates) · Steering:electric Power Assist System
DURING THIS INVESTIGATION, GENERAL MOTORS (GM) INDICATED THAT APPROXIMATELY 15,600 MODEL YEAR (MY) 2005 PONTIAC G6 VEHICLES BUILT FROM NOVEMBER 3, 2004 THROUGH JANUARY 5, 2005 MAY EXPERIENCE A LOSS OF POWER STEERING ASSIST DUE TO AN INSUFFICIENT CRIMP AT THE TORQUE AND POSITION SENSOR TRANSDUCER LOCATED IN THE STEERING COLUMN ASSEMBLY. GM HAS INDICATED THAT IT PLANS TO SEND LETTERS TO THE OWNERS OF THESE VEHICLES TO INFORM THEM THAT IT WILL EXTEND THE WARRANTY COVERAGE FOR THE EPS SYSTEM IN THEIR VEHICLES TO 7 YEARS OR 70,000 MILES.STATISTICAL ANALYSIS OF THE FAILURES IN THE POPULATION AFFECTED BY THE WIRING CRIMP PROBLEM INDICATE THAT THE PROBLEM IS AN EARLY LIFE FAILURE THAT SHOULD OCCUR WITHIN THE TERMS OF THE EXTENDED COVERAGE.GM'S INVESTIGATION OF EPS FAILURES IN THE SUBJECT VEHICLES IDENTIFIED A PROBLEM WITH THE CONNECTOR CRIMPS DURING THE TWO MONTH PRODUCTION RANGE COVERED BY THE WARRANTY EXTENSION.DURING THIS PERIOD THE CRIMPS MAY BE ASYMMETRICAL, RESULTING ININADEQUATE PRESSURE ON THE WIRE THAT CAN LEAD TO ELECTRICAL NOISE IN THE SIGNAL FROM THE SENSOR TO THE CONTROLLER.THE CONTROLLER MAY INTERPRET THIS ELECTRICAL NOISE AS A MALFUNCTION OF THE SYSTEM AND DEFAULT TO MANUAL MODE (I.E., TURN OFF THE EPS SYSTEM).IF THE POWER STEERING ASSIST IS LOST, THE DRIVER INFORMATION CENTER (DIC) DISPLAYS A POWER STEERING WARNING MESSAGE, A CHIME IS SOUNDED, ANDTHE SERVICE VEHICLE SOON LIGHT WILL ILLUMINATE.IN MANUAL MODE THE STEERING REQUIRES INCREASED EFFORT, ESPECIALLY AT SPEEDS LESS THAN 20 MILES PER HOUR (MPH).ODI'S ANALYSIS OF THE FAILURE DATA SHOW THAT APPROXIMATELY 30 PERCENT OF THE COMPLAINTS AND FIELD REPORTS (569 OF 1913) INVOLVE VEHICLES BUILT IN THE RANGE COVERED BY GM'S EXTENDED POLICY, WHICH ACCOUNT FOR ONLY ABOUT 7 PERCENT OF THE SUBJECT VEHICLE POPULATION.THE COMPLAINT RATE FOR THE NON-PEAK MONTHS IS RELATIVELY HIGH, AT 673 PER 100,000 VEHICLES.THE RATE FOR THE PEAK MONTHS IS 5 TIMES HIGHER AT 3,645 PER 100,000 VEHICLES.SIMILAR DIFFERENCES ARE EVIDENT IN THE WARRANTY DATA, WITH APPROXIMATELY 27 PERCENT OF THE EPS WARRANTY CLAIMS (1120 OF 4145) INVOLVING VEHICLES BUILT IN THE PEAK MONTHS.THE WARRANTY RATE FOR THE NON-PEAK MONTHS IS 1.5% AND THE RATE FOR THE PEAK MONTHS IS 7.2%.ODI IDENTIFIED 9 CRASHES THAT ARE POTENTIALLY RELATED TO EPS SYSTEM FAILURE IN THE SUBJECT VEHICLES.THE CRASHES OCCURRED AT LOW SPEEDS, SUCH AS DRIVEWAY AND PARKING LOT TYPE MANEUVERS.THE CRASHES RESULTED IN ONE ALLEGED INJURY, BUT ODI WAS UNABLE TO OBTAIN INFORMATION ABOUT THE TYPE OR SEVERITY OF THE INJURY.NONE OF THE CRASHES INVOLVE VEHICLES BUILT IN THE TWO MONTH PERIOD COVERED BY GM'S EXTENDED WARRANTY COVERAGE.THE SUBJECT VEHICLES USE THE SAME EPS SYSTEM AS THE MY 2004 CHEVROLET MALIBU VEHICLES INVESTIGATED BY ODI IN EA04-018.ALTHOUGH THE FAILURE RATES ARE HIGH IN THIS INVESTIGATION, PARTICULARLY FOR THE PEAK MONTHS, THEY ARE SIGNIFICANTLY LOWER THAN FOR THE MALIBU VEHICLES INVESTIGATED IN EA04-018.AS IN THOSE VEHICLES, THE EFFECTS ON STEERING EFFORT ARE SMALL AT SPEEDS GREATER THAN 15-20 MPH.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.