← New search

2005 Pontiac G6

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2005 Pontiac G6 do not stand out strongly from the model-year median of 679.

About this comparison →

When problems were reported

Mileage at the reported incident

574 reports with mileage · 105 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

26 crash reports4 fire reports13 injury reports

Exterior Lighting complaints

62 reports
Clear category filter
29,000 miles · Feb 21, 2009
Exterior Lighting

2005 PONTIAC G6 HAS A PROBLEM WITH THE BRAKE LIGHTS WHERE THE LIGHTS STAY ON WHILE BRAKE PEDAL IS NOT BEING PUSHED, OR DON'T COME ON AT ALL UNLESS YOU PUSH REALLY HARD. I LOOKED ONLINE TO SEE IF I COULD FIND A SOLUTION AND FOUND MANY OTHER PEOPLE ARE HAVING SIMILAR ISSUES. *TR

NHTSA ODI #10259508

Mileage unknown · Jan 23, 2009
Exterior Lighting

MY BRAKE LIGHTS WILL BE ON WITHOUT THE BRAKES BEING PRESSED AND WILL GO OFF WHEN THE BRAKES ARE APPLIED. HAS OCCURRED ON AND OFF OVER THE LAST 6 MONTHS. I HAVE BEEN ON SEVERAL FORUMS AND THIS SEEMS TO BE A COMMON OCCURRENCE WITH G6 OWNERS. *TR

NHTSA ODI #10256146

50,000 miles · Dec 26, 2008
Exterior Lighting

I OWN A 2005 PONTIAC G6, AND THE PROBLEM IS WITH THE BRAKE SWITCH. THE BRAKE LIGHTS COME ON EVEN WHEN I'M NOT STEPPING ON THE BRAKE PEDAL. THIS HAPPENS ON A REGULAR BASIS, THAT I CAN SEE THE REFLECTION OF MY BRAKE LIGHTS COMING ON WHILE I'M DRIVING. *TR

NHTSA ODI #10252857

58,000 miles · Dec 23, 2008
Exterior Lighting

TL*THE CONTACT OWNS A 2005 PONTIAC G6. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE LIGHTS ILLUMINATE. WHEN THE VEHICLE WAS SLOWED DOWN, THE LIGHTS DIM. THE DEALER HAS NOT YET BEEN LOCATED. THE FAILURE AND CURRENT MILEAGES WERE 58,000.

NHTSA ODI #10252653

51,000 miles · Nov 1, 2008
Exterior Lighting

2005 PONTIAC G6, BRAKE LIGHTS COME ON WITHOUT TOUCHING THE BRAKES. IT OCCURS SPORADICALLY. IF YOU TAP THE BRAKE PEDAL, THE LIGHTS GO OFF FOR ABOUT 3-5 SECONDS, THEN THEY COME BACK ON. I'VE HAD IT IN AT THE PONTIAC DEALERSHIP TWICE AND THEY DON'T KNOW HOW TO FIX THE PROBLEM. I'VE DONE INTERNET SEARCHES ABOUT THIS ISSUE AND IT…

Read full complaint

2005 PONTIAC G6, BRAKE LIGHTS COME ON WITHOUT TOUCHING THE BRAKES. IT OCCURS SPORADICALLY. IF YOU TAP THE BRAKE PEDAL, THE LIGHTS GO OFF FOR ABOUT 3-5 SECONDS, THEN THEY COME BACK ON. I'VE HAD IT IN AT THE PONTIAC DEALERSHIP TWICE AND THEY DON'T KNOW HOW TO FIX THE PROBLEM. I'VE DONE INTERNET SEARCHES ABOUT THIS ISSUE AND IT APPEARS TO BE HAPPENING TO OTHER G6 OWNERS ALL OVER THE U.S. I'VE HAD OTHER MOTORISTS FLASH ME AND MOTION TO ME ON THE FREEWAY AND I DON'T THINK IT IS SAFE TO DRIVE THE CAR THIS WAY. *TR

NHTSA ODI #10247445

34,000 miles · Oct 21, 2008
Exterior Lighting

I HAVE A 2005 PONTIAC G6 GT. THE BRAKE LIGHTS,WITH NO KNOWN CAUSE,BEGAN TO STAY ON WHEN ACCELERATING AND TURN OFF WHEN THE BRAKE WAS HIT. THIS OCCURRED DAY AND NIGHT WITHOUT ANY KNOWN CAUSE. THE BIGGER PROBLEM WAS THAT THE LIGHTS WORKED SOMETIMES,MAKING IT HARD TO DIAGNOSE A PROBLEM. I HAVE YET TO FIND A MECHANIC WHO HAS BEEN…

Read full complaint

I HAVE A 2005 PONTIAC G6 GT. THE BRAKE LIGHTS,WITH NO KNOWN CAUSE,BEGAN TO STAY ON WHEN ACCELERATING AND TURN OFF WHEN THE BRAKE WAS HIT. THIS OCCURRED DAY AND NIGHT WITHOUT ANY KNOWN CAUSE. THE BIGGER PROBLEM WAS THAT THE LIGHTS WORKED SOMETIMES,MAKING IT HARD TO DIAGNOSE A PROBLEM. I HAVE YET TO FIND A MECHANIC WHO HAS BEEN ABLE TO DETERMINE AND CORRECT THE BRAKE LIGHTS. *TR

NHTSA ODI #10246251

25,000 miles · Sep 18, 2008
Electrical SystemExterior LightingInterior LightingCrash

I OWN A 2005 PONTIAC G6 WHICH I PURCHASED FROM A DEALER AFTER IT HAD BEEN LEASED FOR 1 YEAR. THE VEHICLE HAD 12000 MILES ON IT WHEN PURCHASE. NUMEROUS PROBLEMS HAVE OCCURRED WITH THIS VEHICLE AFTER PURCHASE. STARTING WITH A NOISE, CLUNK IN THE STEERING. THIS HAS BEEN IN THE REPAIR SHOP FOR UPWARDS TO 7-8 TIMES, EACH TIME NEW REP…

Read full complaint

I OWN A 2005 PONTIAC G6 WHICH I PURCHASED FROM A DEALER AFTER IT HAD BEEN LEASED FOR 1 YEAR. THE VEHICLE HAD 12000 MILES ON IT WHEN PURCHASE. NUMEROUS PROBLEMS HAVE OCCURRED WITH THIS VEHICLE AFTER PURCHASE. STARTING WITH A NOISE, CLUNK IN THE STEERING. THIS HAS BEEN IN THE REPAIR SHOP FOR UPWARDS TO 7-8 TIMES, EACH TIME NEW REPAIRS DONE ON DIFFERENT PARTS. THIS PROBLEM HAS NEVER BEEN RESOLVED. NOW AT 64500 MILES THE NOISE IS STILL THERE AFTER REPAIRS ONLY 4000 MILES AGO. STARTING IN OCTOBER OF 2007 I BEGAN HAVING PROBLEMS WITH THE BRAKE LIGHTS AND CRUISE CONTROL. BRAKE LIGHTS WORKING ONLY SPORADICALLY AS WELL AS THE CRUISE CONTROL. THERE HAS BEEN DOCUMENTED REPAIRS ON THE IS OF 7-8 TIMES AS WELL. THIS PROBLEM ALSO HAS NEVER BEEN RESOLVED. ON SEPTEMBER 17, 2008 MY CAR WAS INVOLVED IN A REAR-END AUTOMOBILE ACCIDENT IN MOST PART AND NO DOUBT DUE TO FAULTY BRAKE LIGHT SYSTEM. MANY OTHER PROBLEMS HAVE OCCURRED WITH THIS VEHICLE AS WELL INCLUDING POOR SUNVISOR MANUFACTURING, LEAKY MAP LIGHTS IN OVERHEAD CONSOLE, RAPID WEAR OF BRAKE PADS AND ROTORS, RAPID TIRE WEAR, STARTING DRAGS WHEN STARTING, OCCASIONALLY THE CAR WILL NOT SHIFT OUT OF PARK WHEN THE CAR IS RUNNING AND BRAKE PEDAL IS APPLIED. *TR

NHTSA ODI #10242800

33,000 miles · Sep 8, 2008
Exterior Lighting

TL*THE CONTACT OWNS A 2005 PONTIAC G6. WHENEVER THE CONTACT ACCELERATED, THE BRAKE LIGHTS WOULD ILLUMINATE. WHENEVER HE APPLIED THE BRAKES, THE BRAKES LIGHT WOULD TURN OFF. THE CONTACT ALSO NOTICED THAT THE CRUISE CONTROL FEATURE WOULD NOT WORK. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. SPEED WAS NOT A FACTOR. THE …

Read full complaint

TL*THE CONTACT OWNS A 2005 PONTIAC G6. WHENEVER THE CONTACT ACCELERATED, THE BRAKE LIGHTS WOULD ILLUMINATE. WHENEVER HE APPLIED THE BRAKES, THE BRAKES LIGHT WOULD TURN OFF. THE CONTACT ALSO NOTICED THAT THE CRUISE CONTROL FEATURE WOULD NOT WORK. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. SPEED WAS NOT A FACTOR. THE CURRENT MILEAGE WAS 58,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 10/16/08 *BF THE BRAKE LIGHT WAS DISENGAGING THE CRUISE CONTROL. UPDATED 10/21/08. *JB

NHTSA ODI #10241305

Mileage unknown · Aug 6, 2008
Exterior Lighting

I BOUGHT MY 2005 G6 1 MONTH AGO. WHEN I DRIVE AT NIGHT MY BRAKE LIGHT ARE ALWAYS ON. WHEN I TOUCH MY BRAKES THE LIGHTS GO OUT. THE DEALERSHIPS CAN NOT SEEM TO FIND ANYTHING WRONG. *TR

NHTSA ODI #10237257

60,000 miles · Apr 24, 2008
Exterior Lighting

I HAVE A FAULTY BRAKELIGHT SWITCH ON MY 2005 PONTIAC G6...THAT'S WHAT I WAS TOLD. THE LIGHTS FUNCTION JUST THE OPPOSITE AS THEY WERE DESIGNED. MY BRAKELIGHTS ARE ON WHEN I'M MOVING [DRIVING] AND THEY GO OFF WHEN I HIT MY BRAKES. I WENT ONLINE TO RESEARCH AND FOUND OTHERS COMPLAINING OF THE SAME PROBLEM ALL G6 OWNERS. I BE…

Read full complaint

I HAVE A FAULTY BRAKELIGHT SWITCH ON MY 2005 PONTIAC G6...THAT'S WHAT I WAS TOLD. THE LIGHTS FUNCTION JUST THE OPPOSITE AS THEY WERE DESIGNED. MY BRAKELIGHTS ARE ON WHEN I'M MOVING [DRIVING] AND THEY GO OFF WHEN I HIT MY BRAKES. I WENT ONLINE TO RESEARCH AND FOUND OTHERS COMPLAINING OF THE SAME PROBLEM ALL G6 OWNERS. I BELIEVE THIS COULD LEAD TO FATAL AND SERIOUS INJURIES. THANK YOU FOR YOUR TIME. AT THIS TIME I AM STILL WAITING FOR THE DEALER TO RESPOND BACK IF THIS IS/WAS A RECALL. *TR

NHTSA ODI #10225557

Official recalls

5

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Vehicle Speed Control:cruise Control

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Exterior Lighting:brake Lights:switch

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Exterior Lighting:brake Lights

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Electrical System:wiring

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift

Apr 30, 2014

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Consequence & remedy

Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ‘PARK’ position, the transmission may not be in ‘PARK.’ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Additional source detail variants (2)

Power Train:automatic Transmission:lever And Linkage:floor Shift

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ‘PARK’ position, the transmission may not be in ‘PARK.’ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Power Train:automatic Transmission

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ‘PARK’ position, the transmission may not be in ‘PARK.’ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

09V036000 · Exterior Lighting:brake Lights

Jan 30, 2009

GM IS RECALLING 8,012 MY 2005-2006 PONTIAC G6 VEHICLES. THE BRAKE LAMPS MAY NOT OPERATE PROPERLY BECAUSE OF CORROSION IN A WIRING CONNECTOR. CORROSION IN THE CONNECTOR COULD CAUSE THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKE PEDAL HAS NOT BEEN DEPRESSED, OR THE LAMPS MAY NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. IN ADDITION, THE CRUISE CONTROL MAY NOT ENGAGE, AND GREATER BRAKE PEDAL FORCE MAY BE REQUIRED TO SHIFT THE VEHICLE OUT OF PARK.

Consequence & remedy

Consequence: BRAKE LAMPS THAT ARE NOT OPERATING PROPERLY MAY NOT WARN A DRIVER IN A FOLLOWING VEHICLE OF THE BRAKING STATUS AND COULD LEAD TO A CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL APPLY A DIELECTRIC LUBRICANT TO THE CONNECTOR TO PREVENT CORROSION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2009. OWNERS MAY CONTACT PONTIAC AT 1- 800-620-7668 OR OWNER CENTER AT WWW.GMOWNERCENTER.COM.

05V098000 · Equipment:other:owners/service/other Manual

Mar 14, 2005

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THE CHILD RESTRAINT LOWER ANCHORS IN THE CENTER REAR SEATING POSITION ARE LOCATED APPROXIMATELY 90MM BEHIND THE CORRESPONDING Z-POINT OF THE CHILD RESTRAINT FIXTURE (CRF). THE OWNER'S MANUAL STATES THAT ANCHORS ARE AT THE OUTBOARD SEATING POSITIONS ONLY.

Consequence & remedy

Consequence: WITHOUT ADDITIONAL AND CORRECTED OWNER'S MANUAL INFORMATION, AN OWNER MAY ENCOUNTER DIFFICULTY IN INSTALLING CHILD RESTRAINTS WITH RIGID ATTACHMENTS IN THE CENTER POSITION.

Remedy: OWNERS WILL BE MAILED AN OWNER'S MANUAL SUPPLEMENT. THE RECALL IBEGAN ON MARCH 20, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA13005 · Brake Light Switch/sensor Malfunction

Opened Jun 6, 2013 · Closed Jul 1, 2014

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights

On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Additional source detail variants (3)

Exterior Lighting:brake Lights

On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Exterior Lighting

On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Exterior Lighting:tail Lights

On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

RQ13001 · Brake Light Malfunction

Opened Feb 4, 2013 · Closed Jun 6, 2013

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights

The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Additional source detail variants (3)

Exterior Lighting:brake Lights

The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Exterior Lighting

The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Exterior Lighting:tail Lights

The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

PE08054 · Stop Lamp Malfunction

Opened Sep 15, 2008 · Closed Jan 30, 2009

Status: closed (inferred from source dates) · Electrical System:software; Exterior Lighting:brake Lights:switch

GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.

Additional source detail variants (2)

Electrical System:software

GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.

Exterior Lighting:brake Lights:switch

GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.

PE07023 · Loss Of Power Steering Assist

Opened Apr 25, 2007 · Closed Sep 25, 2007

Status: closed (inferred from source dates) · Steering:electric Power Assist System

DURING THIS INVESTIGATION, GENERAL MOTORS (GM) INDICATED THAT APPROXIMATELY 15,600 MODEL YEAR (MY) 2005 PONTIAC G6 VEHICLES BUILT FROM NOVEMBER 3, 2004 THROUGH JANUARY 5, 2005 MAY EXPERIENCE A LOSS OF POWER STEERING ASSIST DUE TO AN INSUFFICIENT CRIMP AT THE TORQUE AND POSITION SENSOR TRANSDUCER LOCATED IN THE STEERING COLUMN ASSEMBLY. GM HAS INDICATED THAT IT PLANS TO SEND LETTERS TO THE OWNERS OF THESE VEHICLES TO INFORM THEM THAT IT WILL EXTEND THE WARRANTY COVERAGE FOR THE EPS SYSTEM IN THEIR VEHICLES TO 7 YEARS OR 70,000 MILES.STATISTICAL ANALYSIS OF THE FAILURES IN THE POPULATION AFFECTED BY THE WIRING CRIMP PROBLEM INDICATE THAT THE PROBLEM IS AN EARLY LIFE FAILURE THAT SHOULD OCCUR WITHIN THE TERMS OF THE EXTENDED COVERAGE.GM'S INVESTIGATION OF EPS FAILURES IN THE SUBJECT VEHICLES IDENTIFIED A PROBLEM WITH THE CONNECTOR CRIMPS DURING THE TWO MONTH PRODUCTION RANGE COVERED BY THE WARRANTY EXTENSION.DURING THIS PERIOD THE CRIMPS MAY BE ASYMMETRICAL, RESULTING ININADEQUATE PRESSURE ON THE WIRE THAT CAN LEAD TO ELECTRICAL NOISE IN THE SIGNAL FROM THE SENSOR TO THE CONTROLLER.THE CONTROLLER MAY INTERPRET THIS ELECTRICAL NOISE AS A MALFUNCTION OF THE SYSTEM AND DEFAULT TO MANUAL MODE (I.E., TURN OFF THE EPS SYSTEM).IF THE POWER STEERING ASSIST IS LOST, THE DRIVER INFORMATION CENTER (DIC) DISPLAYS A POWER STEERING WARNING MESSAGE, A CHIME IS SOUNDED, ANDTHE SERVICE VEHICLE SOON LIGHT WILL ILLUMINATE.IN MANUAL MODE THE STEERING REQUIRES INCREASED EFFORT, ESPECIALLY AT SPEEDS LESS THAN 20 MILES PER HOUR (MPH).ODI'S ANALYSIS OF THE FAILURE DATA SHOW THAT APPROXIMATELY 30 PERCENT OF THE COMPLAINTS AND FIELD REPORTS (569 OF 1913) INVOLVE VEHICLES BUILT IN THE RANGE COVERED BY GM'S EXTENDED POLICY, WHICH ACCOUNT FOR ONLY ABOUT 7 PERCENT OF THE SUBJECT VEHICLE POPULATION.THE COMPLAINT RATE FOR THE NON-PEAK MONTHS IS RELATIVELY HIGH, AT 673 PER 100,000 VEHICLES.THE RATE FOR THE PEAK MONTHS IS 5 TIMES HIGHER AT 3,645 PER 100,000 VEHICLES.SIMILAR DIFFERENCES ARE EVIDENT IN THE WARRANTY DATA, WITH APPROXIMATELY 27 PERCENT OF THE EPS WARRANTY CLAIMS (1120 OF 4145) INVOLVING VEHICLES BUILT IN THE PEAK MONTHS.THE WARRANTY RATE FOR THE NON-PEAK MONTHS IS 1.5% AND THE RATE FOR THE PEAK MONTHS IS 7.2%.ODI IDENTIFIED 9 CRASHES THAT ARE POTENTIALLY RELATED TO EPS SYSTEM FAILURE IN THE SUBJECT VEHICLES.THE CRASHES OCCURRED AT LOW SPEEDS, SUCH AS DRIVEWAY AND PARKING LOT TYPE MANEUVERS.THE CRASHES RESULTED IN ONE ALLEGED INJURY, BUT ODI WAS UNABLE TO OBTAIN INFORMATION ABOUT THE TYPE OR SEVERITY OF THE INJURY.NONE OF THE CRASHES INVOLVE VEHICLES BUILT IN THE TWO MONTH PERIOD COVERED BY GM'S EXTENDED WARRANTY COVERAGE.THE SUBJECT VEHICLES USE THE SAME EPS SYSTEM AS THE MY 2004 CHEVROLET MALIBU VEHICLES INVESTIGATED BY ODI IN EA04-018.ALTHOUGH THE FAILURE RATES ARE HIGH IN THIS INVESTIGATION, PARTICULARLY FOR THE PEAK MONTHS, THEY ARE SIGNIFICANTLY LOWER THAN FOR THE MALIBU VEHICLES INVESTIGATED IN EA04-018.AS IN THOSE VEHICLES, THE EFFECTS ON STEERING EFFORT ARE SMALL AT SPEEDS GREATER THAN 15-20 MPH.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.