IllustrationSEAT BELT SOMETIMES LATCH AND SOMETIMES IT WON'T/ FUEL LEAK AND FUMES
1991 Pontiac Firebird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Firebird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 27 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports2 injury reports
What owners actually said
27 reportsTL* THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. THE CONTACT STATED THAT THERE WAS FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SOUDER JOINT WAS FRACTURED WHICH, ALLOWED FUEL TO LEAK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT IN…
Read full complaint
TL* THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. THE CONTACT STATED THAT THERE WAS FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SOUDER JOINT WAS FRACTURED WHICH, ALLOWED FUEL TO LEAK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 94V077000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 135,000.
TL* THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. WHILE STOPPED AT A RED LIGHT, THE VEHICLE ACCELERATED FORWARD WITHOUT DRIVER INTENT. THE CONTACT TOOK THE VEHICLE TO BE REPAIRED WHEN HE WAS ADVISED BY THE DEALER THAT THE DRIVERS SIDE PRESSURE SENSOR, BEHIND THE HEADLIGHT, WAS DEFECTIVE. THE FAILURE MILEAGE WAS 10,000 AND THE CUR…
Read full complaint
TL* THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. WHILE STOPPED AT A RED LIGHT, THE VEHICLE ACCELERATED FORWARD WITHOUT DRIVER INTENT. THE CONTACT TOOK THE VEHICLE TO BE REPAIRED WHEN HE WAS ADVISED BY THE DEALER THAT THE DRIVERS SIDE PRESSURE SENSOR, BEHIND THE HEADLIGHT, WAS DEFECTIVE. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT WAS 56,000. UPDATED 05/10/10 *BF THE DEALER REPLACED THE THROTTLE POSITION SENSOR. UPDATED 06/11/10*JB
TL*THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. THE CONTACT STATED THAT THE FIRST TIME HE PLACED FUEL IN THE VEHICLE, GASOLINE BEGAN TO LEAK AND FUMES WERE PRESENT. THE DEALER STATED THAT THERE WERE NO RECALLS THAT APPLIED TO HIS VIN. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBERS 94V077000 (FUEL SYSTEM, GASOLINE:STORAGE: TANK…
Read full complaint
TL*THE CONTACT OWNS A 1991 PONTIAC FIREBIRD. THE CONTACT STATED THAT THE FIRST TIME HE PLACED FUEL IN THE VEHICLE, GASOLINE BEGAN TO LEAK AND FUMES WERE PRESENT. THE DEALER STATED THAT THERE WERE NO RECALLS THAT APPLIED TO HIS VIN. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBERS 94V077000 (FUEL SYSTEM, GASOLINE:STORAGE: TANK ASSEMBLY:FILLER PIPE AND CAP) AND 06E043000 (FUEL SYSTEM: GASOLINE). THE CURRENT MILEAGE WAS 61,231 AND FAILURE MILEAGE WAS 60,230. UPDATE 10/01/08 *CW THE GAS TANK FILLER NECK SEAM AT THE TANK LEAKED GAS. UPDATED 10/03/08. *JB
DT*: THE CONTACT STATED THAT THERE WAS A GASOLINE SMELL COMING FROM THE VEHICLE WHILE IT WAS PARKED IN THE GARAGE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. UPON INSPECTION THE MECHANIC FOUND A LEAK COMING FROM THE GASOLINE FILLER PIPE. THERE IS A NHTSA CAMPAIGN ID #94V077000, REGARDING THE GASOLINE: STORAGE TANK A…
Read full complaint
DT*: THE CONTACT STATED THAT THERE WAS A GASOLINE SMELL COMING FROM THE VEHICLE WHILE IT WAS PARKED IN THE GARAGE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. UPON INSPECTION THE MECHANIC FOUND A LEAK COMING FROM THE GASOLINE FILLER PIPE. THERE IS A NHTSA CAMPAIGN ID #94V077000, REGARDING THE GASOLINE: STORAGE TANK ASSEMBLY: FILLER PIPE AND CAP. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE HAS NOT BEEN REPAIRED. UPDATED 3/20/2006 - *NM
WHEN APPLYING THE THE BRAKES THE VEHICLE PULSATES UP AND DOWN. CONSUMER STATES TOOK TO DEALER AND DISCOVERED THE ROTORS WERE WARPED. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
IN A FRONTAL COLLISION NONE OF THE AIR BAGS DEPLOYED ON IMPACT.*AK
VEHICLE WAS NOT INCLUDED IN RECALL 94V077000 FOR FUEL TANK NECK FILLER BUT HAS SAME LEAKING PROBLEM.L PLEASE DESCRIBE DETAILS. *AK
THE RIGHT REAR AXLE BROKE DUE TO A BAD CASTING CAUSING THE WHEEL TO LEAVE THE VEHICLE AND THE CAR TO CRASH*AK
VEHICLE EXPERIENCED EXTREME VIBRATION, SEVERAL REPAIRS ON THE SUSPENSION SYSTEM AND ROTATION OF THE TIRES DID NOT REMEDY VIBRATION PROBLEMS, REPLACEMENT OF THE TIRES SOLVED THE VIBRATION PROBLEM, THE FIRESTONE FIREHAWK TIRES WERE EXPERIENCING TREAD SEPARATION WHICH CAUSED THE VIBRATION PROBLEM. *MJS
Official recalls
394V077000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Apr 25, 1994
THE FUEL FILLER NECK SOLDER JOINT CAN DEVELOP CRACKS OR PIN HOLE LEAKS, WHICH DOES NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE CRACKS AND HOLES CAN ALLOW FUEL VAPOR AND FUEL LEAKAGE.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: GASOLINE VAPORS AND FUEL LEAKS CAN RESULT IN A FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Remedy: DEALERS WILL INSPECT THE FUEL TANK ASSEMBLY AND REPLACE THOSE WHICH EXHIBIT THE CRACKS OR PIN HOLE LEAKS.
91V067000 · Seat Belts:front:anchorage
Apr 22, 1991
THE METAL LATCHPLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES, CAUSING A "NO LATCH" CONDITION. MOVEMENT OF THE SEAT OCCUPANT IN THIS CONDITION COULD CAUSE LATCHPLATE RELEASE FROM THE BUCKLE.
Consequence & remedy
Consequence: UNBELTED OR INCORRECTLY BELTED SEAT OCCUPANTS ARESUBJECTED TO INCREASED RISK OF INJURY IN THE EVENT OF SUDDEN STOP OR ACCIDENT.
Remedy: REPLACE THE RETRACTOR ASSEMBLY FOR THE SAFETY BELT (FRONT AND REAR IN COUPES AND FRONT ONLY IN CONVERTIBLES).
91V031000 · Visibility:windshield
Feb 19, 1991
POOR BOND ADHESION BETWEEN THE WINDSHIELD GLASS AND THE MOUNTING, WHICH COULD ALLOW THE WINDSHIELD TO SEPARATE FROM THE VEHICLE DURING A COLLISION. THIS FAILS TO CONFORM WITH FMVSS 212.
Consequence & remedy
Consequence: IF WINDSHIELD SEPARATION OCCURS IN A COLLISION, ANUNBELTED OCCUPANT COULD BE EJECTED FROM THE VEHICLE, AND PERSONAL INJURY COULDOCCUR.
Remedy: REMOVE ALL SEALER FROM WINDSHIELD AND MOUNTING; APPLY NEW BONDING AND SEALANT MATERIAL, AND REINSTALL WINDSHIELD.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA93005 · Fuel Leaks
Opened Jan 29, 1993 · Closed Apr 26, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92073 · Fuel Tank Leakage
Opened Sep 2, 1992 · Closed Jan 29, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
DP91012 · Axle Shaft And Wheel Lug Studs
Opened Sep 17, 1991 · Closed Jan 16, 1992
Status: closed (inferred from source dates) · Suspension
AXLE SHAFT AND WHEEL LUG STUDS