NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
214 reports150,000 miles · Mar 24, 2014
Engine
TL* THE CONTACT OWNS 2000 PONTAIC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS RECURRING OVER A TWO YEAR PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO COULD NOT DIAGNOSE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER …
Read full complaint
TL* THE CONTACT OWNS 2000 PONTAIC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS RECURRING OVER A TWO YEAR PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO COULD NOT DIAGNOSE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10574489
90,000 miles · Feb 4, 2013
SteeringSuspensionVehicle Speed Control
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE…
Read full complaint
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE FRONT RODS, THE FRONT HUB ASSEMBLIES, THE SHOCKS AND THE TIRES ALL IN AN ATTEMPT TO FIX THE ISSUE. BECAUSE OF THE SHAKING IT CONSTANTLY DESTROYS MY FRONT HUB ASSEMBLIES WHICH I HAVE HAD TO REPLACE 2 TIMES IN THE PAST 2 YEARS. IT ALSO MAKES IT EXTREMELY UNSAFE TO DRIVE AS ONE OF THE SHOPS TOLD ME THAT THE FRONT ASSEMBLIES WERE SO DESTROYED FROM THE SHAKING THAT I AM EXTREMELY LUCKY THAT THE TIRES DID NOT FOLD UNDER THE VEHICLE AND CAUSE A MAJOR ACCIDENT. I HAVE TRIED FOR 3 YEARS TO FIX THIS ISSUE AND NO ONE HAS A REMEDY. I HAVE ALSO READ ON CONSUMER REVIEW THAT MANY OTHER PEOPLE HAVE EXPERIENCED THE SAME ISSUE WITH THEIR BONNEVILLE IN THE SAME YEAR (2000) AND AGAIN, NO SHOPS HAVE BEEN ABLE TO FIND THE REASON BEHIND THE SHAKING. I DO NOT THINK THAT THIS VEHICLE SHOULD BE ALLOWED TO HAVE BEEN MANUFACTURED WITH THIS ISSUE AND I DO NOT UNDERSTAND WHY THERE IS NO RECALL IN PLACE TO FIX THIS LIFE THREATENING DEFECT. *TR
NHTSA ODI #10496393
90,000 miles · Feb 4, 2013
SteeringSuspension
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE…
Read full complaint
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE FRONT RODS, THE FRONT HUB ASSEMBLIES, THE SHOCKS AND THE TIRES ALL IN AN ATTEMPT TO FIX THE ISSUE. BECAUSE OF THE SHAKING IT CONSTANTLY DESTROYS MY FRONT HUB ASSEMBLIES WHICH I HAVE HAD TO REPLACE 2 TIMES IN THE PAST 2 YEARS. IT ALSO MAKES IT EXTREMELY UNSAFE TO DRIVE AS ONE OF THE SHOPS TOLD ME THAT THE FRONT ASSEMBLIES WERE SO DESTROYED FROM THE SHAKING THAT I AM EXTREMELY LUCKY THAT THE TIRES DID NOT FOLD UNDER THE VEHICLE AND CAUSE A MAJOR ACCIDENT. I HAVE TRIED FOR 3 YEARS TO FIX THIS ISSUE AND NO ONE HAS A REMEDY. I HAVE ALSO READ ON CONSUMER REVIEW THAT MANY OTHER PEOPLE HAVE EXPERIENCED THE SAME ISSUE WITH THEIR BONNEVILLE IN THE SAME YEAR (2000) AND AGAIN, NO SHOPS HAVE BEEN ABLE TO FIND THE REASON BEHIND THE SHAKING. I DO NOT THINK THAT THIS VEHICLE SHOULD BE ALLOWED TO HAVE BEEN MANUFACTURED WITH THIS ISSUE AND I DO NOT UNDERSTAND WHY THERE IS NO RECALL IN PLACE TO FIX THIS LIFE THREATENING DEFECT. *TR
NHTSA ODI #10496390
100,000 miles · Dec 4, 2012
EngineFire
WAS GOING TO START MY CAR I TURNED THE KEY TO THE ON POSITION AND HEARD A VERY LOUD EXPLOSION AND THE MOTOR BROKE OUT IN FLAMES. *TR
NHTSA ODI #10487362
90,500 miles · Mar 26, 2012
Electrical SystemFire
TL* THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE ENGINE SUDDENLY CAUGHT ON FIRE WITHOUT WARNING. THE DRIVER AND PASSENGERS ALL WERE ABLE TO EXIT THE VEHICLE WITHOUT ANY INJURIES. THE POLICE AND FIRE DEPARTMENT WERE NOTIFIED, BUT A REPORT WAS UNAVAILABLE. THE FIRE DEP…
Read full complaint
TL* THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE ENGINE SUDDENLY CAUGHT ON FIRE WITHOUT WARNING. THE DRIVER AND PASSENGERS ALL WERE ABLE TO EXIT THE VEHICLE WITHOUT ANY INJURIES. THE POLICE AND FIRE DEPARTMENT WERE NOTIFIED, BUT A REPORT WAS UNAVAILABLE. THE FIRE DEPARTMENT INFORMED THE CONTACT THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC AND PENDING AN INVESTIGATION. THE VEHICLE WAS DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,500.
NHTSA ODI #10453019
195,000 miles · Dec 21, 2011
Engine And Engine CoolingFire
THIS 2000 PONTIAC BONNEVILLE 3.8L WITH APPROXIMATELY 195K MILES WAS OPERATING NORMALLY OVER THE LAST 72 HOURS. IT HAD BEEN DRIVEN APPROXIMATELY 300 MILES BETWEEN 12/16 AND 12/18 @ 12:50 PM THE DATE OF THE FIRE.THAT COLD MORNING (8 DEGREES F) IT WAS DRIVEN 10 MILES RT @ 9AM, 20 MILES RT BETWEEN 10:30 AND NOON, AND THEN SAT FOR AP…
Read full complaint
THIS 2000 PONTIAC BONNEVILLE 3.8L WITH APPROXIMATELY 195K MILES WAS OPERATING NORMALLY OVER THE LAST 72 HOURS. IT HAD BEEN DRIVEN APPROXIMATELY 300 MILES BETWEEN 12/16 AND 12/18 @ 12:50 PM THE DATE OF THE FIRE.THAT COLD MORNING (8 DEGREES F) IT WAS DRIVEN 10 MILES RT @ 9AM, 20 MILES RT BETWEEN 10:30 AND NOON, AND THEN SAT FOR APPROXIMATELY 1/2 HOUR BEFORE IT WAS DRIVEN 5 MILES TO A LOCAL STORE BY MY SON. WHEN HE ARRIVED AT THE STORE/GAS STATION HE PARKED NEAR THE PUMPS AND WHEN HE SHUT OFF ENGINE TO GO INTO STORE, SMELLED BURNING SMOKE FROM THE FRONT OF THE CAR. HE OPENED THE HOOD AND WAS GREETED BY ACTIVE FLAMES COMING FROM THE FRONT OF THE ENGINE. THE FIRE WAS SUBSEQUENTLY EXTINGUISHED AND THE BURNED PART OF THE ENGINE WAS THE TOP AND FRONT LEFT QUARTER (FACING THE VEHICLE). THE ANTI-FREEZE RESERVOIR WAS MELTED THROUGH. *TR
NHTSA ODI #10440893
142,000 miles · May 7, 2011
Engine And Engine CoolingFire
AFTER CAR WAS PARKED FOR 5 - 10 MINUTES FIRE IN ENGINE COMPARTMENT. *TR
NHTSA ODI #10399458
54,002 miles · Apr 3, 2011
Engine And Engine Cooling
I SMELLED A BURNING ODOR IN MY BONNEVILLE SSEI. THE LOCAL GM DEALER, ON THE INCIDENT DATE IN THIS FORM, TOLD ME THE CAUSE WAS OIL DRIPPING ON THE EXHAUST MANIFOLD AND THAT IT WAS A FIRE HAZARD. UPON FURTHER INVESTIGATION, I FOUND AN EXISTING NHTSA ACTION NUMBER (EA07008) FOR THE EXACT PROBLEM I AM HAVING FOR THE EXACT 3800 SER…
Read full complaint
I SMELLED A BURNING ODOR IN MY BONNEVILLE SSEI. THE LOCAL GM DEALER, ON THE INCIDENT DATE IN THIS FORM, TOLD ME THE CAUSE WAS OIL DRIPPING ON THE EXHAUST MANIFOLD AND THAT IT WAS A FIRE HAZARD. UPON FURTHER INVESTIGATION, I FOUND AN EXISTING NHTSA ACTION NUMBER (EA07008) FOR THE EXACT PROBLEM I AM HAVING FOR THE EXACT 3800 SERIES II V6 L67 GM ENGINE. THERE WERE 2 RECALLS FOR CARS WITH THIS ENGINE, BUT MY PONTIAC MODEL WAS NOT INCLUDED (EVEN THOUGH IT HAS THE EXACT SAME ENGINE). THE NHTSA CAMPAIGN ID NUMBERS ASSOCIATED WITH THE RECALLS ARE 08V118000 & 09V116000. I ESCALATED THIS PROBLEM WITHIN GM AND THEY TOLD ME TO TAKE THE VEHICLE BACK TO THE GM DEALER FOR ANOTHER INSPECTION. THE GM DEALER VERIFIED THAT MY ENGINE IS THE SAME AS THE RECALLED ENGINE AND THAT I HAVE THE SAME PROBLEM. GM REFUSED TO FIX THE PROBLEM BECAUSE MY VEHICLE'S VIN WASN'T SPECIFICALLY INCLUDED IN THE RECALLS. I STRONGLY BELIEVE MY VEHICLE SHOULD HAVE BEEN INCLUDED IN THE EARLIER RECALLS AND NOW SHOULD BE CONSIDERED FOR A NEW RECALL TO ELIMINATE THIS SAFETY HAZARD.
NHTSA ODI #10394914
74,000 miles · Dec 14, 2010
Electrical SystemEngine And Engine CoolingFuel System, GasolineFire
FIRE IGNITED IN THE ENGINE COMPARTMENT WHILE PARKED IN A MALL PARKING LOT ABOUT 5 TO 10 MINUTES AFTER LEAVING VEHICLE COMPLETELY DESTROYING THE FRONT OF THE VEHICLE.
NHTSA ODI #10371389
Mileage unknown · Mar 22, 2010
Engine And Engine Cooling
I HAVE A 2000 PONTIAC BONNEVILLE W/ A 3.8 V6 3800 SERIES LL ENGINE. I HAVE NOTICED OIL COMING FROM THE INTAKE DRIPPING DOWN ONTO THE MANIFOLD. THERE IS A RECALL ON THE SUPER CHARGED 3800 SERIES LL FOR THE REGAL AND GRAND PRIX. I WOULD LIKE TO NO WHY THERE IS NO RECALL ON THIS MODEL. SAME PROBLEM, JUST NOT SUPER CHARGED. WHAT HAP…
Read full complaint
I HAVE A 2000 PONTIAC BONNEVILLE W/ A 3.8 V6 3800 SERIES LL ENGINE. I HAVE NOTICED OIL COMING FROM THE INTAKE DRIPPING DOWN ONTO THE MANIFOLD. THERE IS A RECALL ON THE SUPER CHARGED 3800 SERIES LL FOR THE REGAL AND GRAND PRIX. I WOULD LIKE TO NO WHY THERE IS NO RECALL ON THIS MODEL. SAME PROBLEM, JUST NOT SUPER CHARGED. WHAT HAPPENS IF IT CATCHES FIRE LIKE SOME OF THE OTHERS HAVE? THEN WILL THERE BE A RECALL? I HAVE CALLED THE DEALERSHIP AND THERE IS NOTHING THEY CAN DO IT IS ALL ON ME. *DT
NHTSA ODI #10321431
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration