NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
47 reportsClear category filter98,000 miles · Mar 20, 2015
SteeringVehicle Speed Control
WHILE DRIVING THE BONNEVILLE THE CAR WILL JUST SHUT DOWN, LOOSES ALL POWER. IT HAS HAPPENED ON THE EXPRESSWAY AND ALSO JUST ON LOCAL CITY DRIVING. YOU CAN BE GOING 30 MPH OR 65 MPH. CAR WILL JUST SHUT DOWN (WHICH IS VERY SCARY GOING 65 MPH) AND SOMEONE ON YOUR BUMPER. LOOSES POWER STEERING SO ITS HARD TO MOVE OVER LANES ON TH…
Read full complaint
WHILE DRIVING THE BONNEVILLE THE CAR WILL JUST SHUT DOWN, LOOSES ALL POWER. IT HAS HAPPENED ON THE EXPRESSWAY AND ALSO JUST ON LOCAL CITY DRIVING. YOU CAN BE GOING 30 MPH OR 65 MPH. CAR WILL JUST SHUT DOWN (WHICH IS VERY SCARY GOING 65 MPH) AND SOMEONE ON YOUR BUMPER. LOOSES POWER STEERING SO ITS HARD TO MOVE OVER LANES ON THE EXPRESSWAY, WE HAVE FOUND YOU NEED TO IMMEDIATELY PUT ON EMERGENCY FLASHERS, SHIFT CAR INTO NEUTRAL AND TURN THE KEY. SOMETIMES IT WILL START ON THE FIRST TURN OF THE KEY BUT SOMETIMES IT TAKES MULTIPLE TIMES OF TURNING THE KEY, ALL THIS WHILE COASTING ON THE EXPRESSWAY WITH PEOPLE BUZZING ALL AROUND YOU. THE ONE TIME IT HAPPENED I WAS RIGHT BY THE GARAGE WE HAVE BEEN TAKING IT TO, TOOK IT OVER, THEY RAN A CHECK ON THE COMPUTER SYSTEM AND NOTHING CAME UP. THEY ARE AT A LOSS AS TO WHAT TO DO WITHOUT JUST START RANDOMLY CHANGING PARTS THEY THINK IT MIGHT PERTAIN TO? ANY SUGGESTIONS, THIS ISN'T SAFE TO DRIVE WHEN IT DOES THIS, AND ITS JUST RANDOM WHEN IT DOES DO IT, NO WARNING. *TR
NHTSA ODI #10700689
90,000 miles · Feb 4, 2013
SteeringSuspensionVehicle Speed Control
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE…
Read full complaint
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE FRONT RODS, THE FRONT HUB ASSEMBLIES, THE SHOCKS AND THE TIRES ALL IN AN ATTEMPT TO FIX THE ISSUE. BECAUSE OF THE SHAKING IT CONSTANTLY DESTROYS MY FRONT HUB ASSEMBLIES WHICH I HAVE HAD TO REPLACE 2 TIMES IN THE PAST 2 YEARS. IT ALSO MAKES IT EXTREMELY UNSAFE TO DRIVE AS ONE OF THE SHOPS TOLD ME THAT THE FRONT ASSEMBLIES WERE SO DESTROYED FROM THE SHAKING THAT I AM EXTREMELY LUCKY THAT THE TIRES DID NOT FOLD UNDER THE VEHICLE AND CAUSE A MAJOR ACCIDENT. I HAVE TRIED FOR 3 YEARS TO FIX THIS ISSUE AND NO ONE HAS A REMEDY. I HAVE ALSO READ ON CONSUMER REVIEW THAT MANY OTHER PEOPLE HAVE EXPERIENCED THE SAME ISSUE WITH THEIR BONNEVILLE IN THE SAME YEAR (2000) AND AGAIN, NO SHOPS HAVE BEEN ABLE TO FIND THE REASON BEHIND THE SHAKING. I DO NOT THINK THAT THIS VEHICLE SHOULD BE ALLOWED TO HAVE BEEN MANUFACTURED WITH THIS ISSUE AND I DO NOT UNDERSTAND WHY THERE IS NO RECALL IN PLACE TO FIX THIS LIFE THREATENING DEFECT. *TR
NHTSA ODI #10496393
90,000 miles · Feb 4, 2013
SteeringSuspension
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE…
Read full complaint
WHEN THE VEHICLE IS ACCELERATING THERE IS A SUBSTANTIAL AMOUNT OF SHAKING IN THE FRONT END. IT GETS VERY BAD BETWEEN 50-60 MPH. I HAVE HAD ALL THE TIRES REPLACED BECAUSE I THOUGHT IT WAS THE ALIGNMENT, AND I HAVE BROUGHT THE CAR TO AT LEAST 3 DIFFERENT SHOPS AND ALL 3 HAVE NO IDEA WHAT IS CAUSING THE SHAKING. I HAVE REPLACED THE FRONT RODS, THE FRONT HUB ASSEMBLIES, THE SHOCKS AND THE TIRES ALL IN AN ATTEMPT TO FIX THE ISSUE. BECAUSE OF THE SHAKING IT CONSTANTLY DESTROYS MY FRONT HUB ASSEMBLIES WHICH I HAVE HAD TO REPLACE 2 TIMES IN THE PAST 2 YEARS. IT ALSO MAKES IT EXTREMELY UNSAFE TO DRIVE AS ONE OF THE SHOPS TOLD ME THAT THE FRONT ASSEMBLIES WERE SO DESTROYED FROM THE SHAKING THAT I AM EXTREMELY LUCKY THAT THE TIRES DID NOT FOLD UNDER THE VEHICLE AND CAUSE A MAJOR ACCIDENT. I HAVE TRIED FOR 3 YEARS TO FIX THIS ISSUE AND NO ONE HAS A REMEDY. I HAVE ALSO READ ON CONSUMER REVIEW THAT MANY OTHER PEOPLE HAVE EXPERIENCED THE SAME ISSUE WITH THEIR BONNEVILLE IN THE SAME YEAR (2000) AND AGAIN, NO SHOPS HAVE BEEN ABLE TO FIND THE REASON BEHIND THE SHAKING. I DO NOT THINK THAT THIS VEHICLE SHOULD BE ALLOWED TO HAVE BEEN MANUFACTURED WITH THIS ISSUE AND I DO NOT UNDERSTAND WHY THERE IS NO RECALL IN PLACE TO FIX THIS LIFE THREATENING DEFECT. *TR
NHTSA ODI #10496390
134,000 miles · Sep 20, 2007
Steering
INTERMEDIATE STEERING SHAFT GOING BAD MAKING THE CAR FRONT END SHIMMY BETWEEN 65-70 MPH. I HAVE REPLACED THE TIRES MAKING SURE THE TIRES WERE BALANCED TWICE. AND OF ALL THE THREADS I HAVE BEEN READING THE PROBLEM IS IN THIS SHAFT. *TR
NHTSA ODI #10203596
112,000 miles · Jan 16, 2007
Steering
TL* - THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH IN HIS 2000 PONTIAC BONNEVILLE (FAILURE MILEAGE 112000 ) SHIFTED THE VEHICLE INTO IN REVERSE AND HEARD A LOUD POP. SHE TRIED TO MOVE THE STEERING WHEEL, BUT IT WOULD NOT TURN WITH THE TIRE. THE PONTIAC DEALERSHIP STATED THAT SOMETHING HIT THE BOTTOM OF THE VEHICLE. THE C…
Read full complaint
TL* - THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH IN HIS 2000 PONTIAC BONNEVILLE (FAILURE MILEAGE 112000 ) SHIFTED THE VEHICLE INTO IN REVERSE AND HEARD A LOUD POP. SHE TRIED TO MOVE THE STEERING WHEEL, BUT IT WOULD NOT TURN WITH THE TIRE. THE PONTIAC DEALERSHIP STATED THAT SOMETHING HIT THE BOTTOM OF THE VEHICLE. THE CONTACT STATED THAT SHE HAS NOT BEEN IN A CRASH NOR HAS SHE STRUCK ANYTHING FOR THE RACK AND PINION STEERING TO HAVE FAILED. *NM UPDATED 2/27/2007 - *NM
NHTSA ODI #10178803
130,000 miles · Nov 15, 2006
Steering
DT*: THE CONTACT STATED WHEN THE ENGINE WAS RUNNING AND THE STEERING WHEEL WAS TURNED IN EITHER DIRECTION, THERE WAS A HOLLOW POUNDING SOUND. ALSO, THE SOUND OCCURRED WHEN THE VEHICLE WAS STOPPED OR TRAVELING FASTER THAN 5 MPH. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE THE INTERMEDIATE STEERING SHAFT WAS REPLACED. SIX MO…
Read full complaint
DT*: THE CONTACT STATED WHEN THE ENGINE WAS RUNNING AND THE STEERING WHEEL WAS TURNED IN EITHER DIRECTION, THERE WAS A HOLLOW POUNDING SOUND. ALSO, THE SOUND OCCURRED WHEN THE VEHICLE WAS STOPPED OR TRAVELING FASTER THAN 5 MPH. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE THE INTERMEDIATE STEERING SHAFT WAS REPLACED. SIX MONTHS LATER, THE PART FAILED AGAIN. THE PROBLEM CONTINUED AND REQUIRED REPLACEMENT MORE THAN 7 TIMES. THE MANUFACTURER WAS NOTIFIED. UPDATED 3/25/08 *CN
NHTSA ODI #10173585
105,000 miles · Oct 18, 2006
Electrical SystemSeatsSteering
TRUNK AREA LEAKS AND WATER BUILDS UP IN THE SPARE TIRE STORAGE. CLANKING NOISE IN STEERING COLUMN WHILE TURNING EITHER DIRECTION DURING COLDER WEATHER. FRONT DRIVERS SEAT HEATER WORKED THEN QUIT FOR NO REASON, PUSH BUTTON ON & LIGHT COMES ON BUT DOESN'T STAY ON. WIPERS WHILE IN INTERMITTENT WILL STOP DURING A SWEEP ACROSS WIN…
Read full complaint
TRUNK AREA LEAKS AND WATER BUILDS UP IN THE SPARE TIRE STORAGE. CLANKING NOISE IN STEERING COLUMN WHILE TURNING EITHER DIRECTION DURING COLDER WEATHER. FRONT DRIVERS SEAT HEATER WORKED THEN QUIT FOR NO REASON, PUSH BUTTON ON & LIGHT COMES ON BUT DOESN'T STAY ON. WIPERS WHILE IN INTERMITTENT WILL STOP DURING A SWEEP ACROSS WINDSHIELD, WHEN TURNED ON OR OFF ALSO TURNS ON/OFF THE DASH LIGHTS AT THE SAME TIME, AND WHILE IN INTERMITTENT IF BLINKER IS USED THE WIPER WILL STOP DURING A SWEEP ACROSS WINDSHIELD. *NM
NHTSA ODI #10171169
12,943 miles · Sep 21, 2006
Steering
INTERMEDIATE STEERING SHAFT HAS BEEN REPLACED TWICE AND LUBRICATED TWICE IN THE LAST FOUR YEARS. CONTINUES TO CLUNK WHEN TURNING THE CAR. GENERAL MOTORS WAS CONTACTED AND ADMITTED THERE IS A PROBLEM WITH THE STEERING AND SAID THEY ARE WORKING ON A FIX. RIGHT NOW THE FIX IS ONLY TEMPORARY AND CAN BE COSTLY. *JB
NHTSA ODI #10168840
48,600 miles · Aug 23, 2006
Steering
DT*: THE CONTACT STATED WHILE DRIVING AND TURNING THE STEERING WHEEL TO EITHER SIDE, THERE WAS A LOUD CLUNKING NOISE COMING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE SHAFT WAS GREASED. AFTER THE REPAIR, THE PROBLEMS CONTINUED. UPDATED 9/15/2006 - THE NOISE COULD ALSO BE HEARD WHEN THE VE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AND TURNING THE STEERING WHEEL TO EITHER SIDE, THERE WAS A LOUD CLUNKING NOISE COMING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE SHAFT WAS GREASED. AFTER THE REPAIR, THE PROBLEMS CONTINUED. UPDATED 9/15/2006 - THE NOISE COULD ALSO BE HEARD WHEN THE VEHICLE WAS IN PARK IDLING. *NM
NHTSA ODI #10166329
87,388 miles · Mar 6, 2006
Engine And Engine CoolingSteering
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE, THERE WAS A HESITATION, AN ODOR OF FUEL, AND A CLICKING NOISE UNDER THE SEAT WHERE THE BATTERY WAS LOCATED. THE VEHICLE GOT HARDER TO START, UNTIL THE VEHICLE WOULD NO LONGER START IN OCTOBER 2005. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC FOR THIS PROBLEM. ALSO, WHILE TU…
Read full complaint
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE, THERE WAS A HESITATION, AN ODOR OF FUEL, AND A CLICKING NOISE UNDER THE SEAT WHERE THE BATTERY WAS LOCATED. THE VEHICLE GOT HARDER TO START, UNTIL THE VEHICLE WOULD NO LONGER START IN OCTOBER 2005. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC FOR THIS PROBLEM. ALSO, WHILE TURNING, THERE WAS A CRACKLING NOISE AND THE VEHICLE DID NOT COMPLETE TURNS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND AN INDEPENDENT REPAIR SHOP, WHERE THE RACK AND PINION WAS REPLACED FIVE TIMES. THE PROBLEM CAME BACK AND NO FURTHER REPAIRS WERE ATTEMPTED.
NHTSA ODI #10152002
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration