NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
37 reportsClear category filter195,000 miles · Dec 21, 2011
Engine And Engine CoolingFire
THIS 2000 PONTIAC BONNEVILLE 3.8L WITH APPROXIMATELY 195K MILES WAS OPERATING NORMALLY OVER THE LAST 72 HOURS. IT HAD BEEN DRIVEN APPROXIMATELY 300 MILES BETWEEN 12/16 AND 12/18 @ 12:50 PM THE DATE OF THE FIRE.THAT COLD MORNING (8 DEGREES F) IT WAS DRIVEN 10 MILES RT @ 9AM, 20 MILES RT BETWEEN 10:30 AND NOON, AND THEN SAT FOR AP…
Read full complaint
THIS 2000 PONTIAC BONNEVILLE 3.8L WITH APPROXIMATELY 195K MILES WAS OPERATING NORMALLY OVER THE LAST 72 HOURS. IT HAD BEEN DRIVEN APPROXIMATELY 300 MILES BETWEEN 12/16 AND 12/18 @ 12:50 PM THE DATE OF THE FIRE.THAT COLD MORNING (8 DEGREES F) IT WAS DRIVEN 10 MILES RT @ 9AM, 20 MILES RT BETWEEN 10:30 AND NOON, AND THEN SAT FOR APPROXIMATELY 1/2 HOUR BEFORE IT WAS DRIVEN 5 MILES TO A LOCAL STORE BY MY SON. WHEN HE ARRIVED AT THE STORE/GAS STATION HE PARKED NEAR THE PUMPS AND WHEN HE SHUT OFF ENGINE TO GO INTO STORE, SMELLED BURNING SMOKE FROM THE FRONT OF THE CAR. HE OPENED THE HOOD AND WAS GREETED BY ACTIVE FLAMES COMING FROM THE FRONT OF THE ENGINE. THE FIRE WAS SUBSEQUENTLY EXTINGUISHED AND THE BURNED PART OF THE ENGINE WAS THE TOP AND FRONT LEFT QUARTER (FACING THE VEHICLE). THE ANTI-FREEZE RESERVOIR WAS MELTED THROUGH. *TR
NHTSA ODI #10440893
142,000 miles · May 7, 2011
Engine And Engine CoolingFire
AFTER CAR WAS PARKED FOR 5 - 10 MINUTES FIRE IN ENGINE COMPARTMENT. *TR
NHTSA ODI #10399458
54,002 miles · Apr 3, 2011
Engine And Engine Cooling
I SMELLED A BURNING ODOR IN MY BONNEVILLE SSEI. THE LOCAL GM DEALER, ON THE INCIDENT DATE IN THIS FORM, TOLD ME THE CAUSE WAS OIL DRIPPING ON THE EXHAUST MANIFOLD AND THAT IT WAS A FIRE HAZARD. UPON FURTHER INVESTIGATION, I FOUND AN EXISTING NHTSA ACTION NUMBER (EA07008) FOR THE EXACT PROBLEM I AM HAVING FOR THE EXACT 3800 SER…
Read full complaint
I SMELLED A BURNING ODOR IN MY BONNEVILLE SSEI. THE LOCAL GM DEALER, ON THE INCIDENT DATE IN THIS FORM, TOLD ME THE CAUSE WAS OIL DRIPPING ON THE EXHAUST MANIFOLD AND THAT IT WAS A FIRE HAZARD. UPON FURTHER INVESTIGATION, I FOUND AN EXISTING NHTSA ACTION NUMBER (EA07008) FOR THE EXACT PROBLEM I AM HAVING FOR THE EXACT 3800 SERIES II V6 L67 GM ENGINE. THERE WERE 2 RECALLS FOR CARS WITH THIS ENGINE, BUT MY PONTIAC MODEL WAS NOT INCLUDED (EVEN THOUGH IT HAS THE EXACT SAME ENGINE). THE NHTSA CAMPAIGN ID NUMBERS ASSOCIATED WITH THE RECALLS ARE 08V118000 & 09V116000. I ESCALATED THIS PROBLEM WITHIN GM AND THEY TOLD ME TO TAKE THE VEHICLE BACK TO THE GM DEALER FOR ANOTHER INSPECTION. THE GM DEALER VERIFIED THAT MY ENGINE IS THE SAME AS THE RECALLED ENGINE AND THAT I HAVE THE SAME PROBLEM. GM REFUSED TO FIX THE PROBLEM BECAUSE MY VEHICLE'S VIN WASN'T SPECIFICALLY INCLUDED IN THE RECALLS. I STRONGLY BELIEVE MY VEHICLE SHOULD HAVE BEEN INCLUDED IN THE EARLIER RECALLS AND NOW SHOULD BE CONSIDERED FOR A NEW RECALL TO ELIMINATE THIS SAFETY HAZARD.
NHTSA ODI #10394914
74,000 miles · Dec 14, 2010
Electrical SystemEngine And Engine CoolingFuel System, GasolineFire
FIRE IGNITED IN THE ENGINE COMPARTMENT WHILE PARKED IN A MALL PARKING LOT ABOUT 5 TO 10 MINUTES AFTER LEAVING VEHICLE COMPLETELY DESTROYING THE FRONT OF THE VEHICLE.
NHTSA ODI #10371389
Mileage unknown · Mar 22, 2010
Engine And Engine Cooling
I HAVE A 2000 PONTIAC BONNEVILLE W/ A 3.8 V6 3800 SERIES LL ENGINE. I HAVE NOTICED OIL COMING FROM THE INTAKE DRIPPING DOWN ONTO THE MANIFOLD. THERE IS A RECALL ON THE SUPER CHARGED 3800 SERIES LL FOR THE REGAL AND GRAND PRIX. I WOULD LIKE TO NO WHY THERE IS NO RECALL ON THIS MODEL. SAME PROBLEM, JUST NOT SUPER CHARGED. WHAT HAP…
Read full complaint
I HAVE A 2000 PONTIAC BONNEVILLE W/ A 3.8 V6 3800 SERIES LL ENGINE. I HAVE NOTICED OIL COMING FROM THE INTAKE DRIPPING DOWN ONTO THE MANIFOLD. THERE IS A RECALL ON THE SUPER CHARGED 3800 SERIES LL FOR THE REGAL AND GRAND PRIX. I WOULD LIKE TO NO WHY THERE IS NO RECALL ON THIS MODEL. SAME PROBLEM, JUST NOT SUPER CHARGED. WHAT HAPPENS IF IT CATCHES FIRE LIKE SOME OF THE OTHERS HAVE? THEN WILL THERE BE A RECALL? I HAVE CALLED THE DEALERSHIP AND THERE IS NOTHING THEY CAN DO IT IS ALL ON ME. *DT
NHTSA ODI #10321431
65,000 miles · Jul 17, 2009
Engine And Engine Cooling
I'VE RUN INTO A DEX-COOL PROBLEM WITH MY PONTIAC 2000. THE CAR HAS 65.000 MI AND THE CYLINDER HEAD GASKET IS STARTING TO LEAK, EVENTUALLY DESTROYING THE ENGINE. WHAT KIND OF RECOURSE DO I HAVE AFTER THE DEX-COOL CLASS ACTION LAW SUIT IS CLOSED? THE POSTMARK AND ONLINE SUBMISSION DEADLINE TO SUBMIT A CLAIM STATEMENT WAS OCTOBER 2…
Read full complaint
I'VE RUN INTO A DEX-COOL PROBLEM WITH MY PONTIAC 2000. THE CAR HAS 65.000 MI AND THE CYLINDER HEAD GASKET IS STARTING TO LEAK, EVENTUALLY DESTROYING THE ENGINE. WHAT KIND OF RECOURSE DO I HAVE AFTER THE DEX-COOL CLASS ACTION LAW SUIT IS CLOSED? THE POSTMARK AND ONLINE SUBMISSION DEADLINE TO SUBMIT A CLAIM STATEMENT WAS OCTOBER 27, 2008. I DID NOT HAD ANY INFORMATION ABOUT THIS CLASS ACTION SUIT AND DEADLINE. SINCE THIS IS CLEARLY AN OEM DEFECT INVOLVING THOUSANDS OF CARS AND DRIVERS GM SHOULD HAVE REACTED RESPONSIBLY AND ISSUED A RECALL. *TR
NHTSA ODI #10277177
65,000 miles · Apr 17, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED A BURNING ODOR COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER AND AN OIL LEAK WAS DISCOVERED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT NO COMPENSATION WOULD BE PROVIDED BEC…
Read full complaint
TL*THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED A BURNING ODOR COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER AND AN OIL LEAK WAS DISCOVERED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT NO COMPENSATION WOULD BE PROVIDED BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 115,000.
NHTSA ODI #10265879
110,000 miles · Aug 15, 2008
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. WHILE DRIVING AT ANY SPEED, OIL LEAKED ONTO THE INTAKE EXHAUST MANIFOLD. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 07035, WHICH STATES THAT DROPS OF ENGINE OIL BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING CAUSES SMOKE THAT CAN IGNITE INTO SMALL FLAMES. ONCE …
Read full complaint
TL*THE CONTACT OWNS A 2000 PONTIAC BONNEVILLE. WHILE DRIVING AT ANY SPEED, OIL LEAKED ONTO THE INTAKE EXHAUST MANIFOLD. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 07035, WHICH STATES THAT DROPS OF ENGINE OIL BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING CAUSES SMOKE THAT CAN IGNITE INTO SMALL FLAMES. ONCE THE HEAT OR AIR CONDITIONING IS ACTIVATED, A BURNT OIL SMELL ENTERS THE PASSENGER COMPARTMENT. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10238405
110,000 miles · Aug 15, 2008
Engine And Engine Cooling
WHEN I DRIVE MY CAR MOST OF THE TIMES, MY ENGINE OIL LEAKS ONTO THE EXHAUST MANIFOLD WHICH CAUSES SMOKE AND A BURNED OIL SMELL. I NOTICED THAT GM HAS HAD A RECALL FOR 1997-2003 BUICK REGAL GS AND 1997-2003 PONTIAC GRAND PRIX GTP WITH 3.8 L V6 SUPERCHARGED ENGINE (VIN1 ? RPO L67). I HAVE THE SAME ENGINE (3.8 L V6 L67 SUPERCHARGE…
Read full complaint
WHEN I DRIVE MY CAR MOST OF THE TIMES, MY ENGINE OIL LEAKS ONTO THE EXHAUST MANIFOLD WHICH CAUSES SMOKE AND A BURNED OIL SMELL. I NOTICED THAT GM HAS HAD A RECALL FOR 1997-2003 BUICK REGAL GS AND 1997-2003 PONTIAC GRAND PRIX GTP WITH 3.8 L V6 SUPERCHARGED ENGINE (VIN1 ? RPO L67). I HAVE THE SAME ENGINE (3.8 L V6 L67 SUPERCHARGED ENGINE) ON MY 2000 PONTIAC BONNEVILLE SSEI AND HAVE THE EXACT SAME PROBLEM. I CANNOT WAIT ANY LONGER WITHOUT REPAIRED THE UNSAFE DAMAGE. I WILL BE REPAIRING IT MYSELF AND EXPECT PONTIAC TO REIMBURSE ME WITH THE MONEY. THIS HAS HAPPENED TO MY CAR MANY TIMES. *TR
NHTSA ODI #10238401
84,000 miles · Mar 22, 2008
Engine And Engine CoolingFire
WE ARE TRYING TO FIND OUT IF ANYONE KNOWS OF PROBLEMS WITH GM PONTIAC BONNEVILLE'S PLASTIC UPPER EXHAUST MANIFOLD. WE OWN A 2000 BONNEVILLE WITH 83K MILEAGE. THE PLASTIC MANIFOLD EXPLODED WHILE TRYING TO START THE CAR. WE ARE TRYING TO RESOLVE THIS WITH GM AT THIS TIME. WE LEARNED THAT THIS HAS OCCURRED BEFORE WITH OT…
Read full complaint
WE ARE TRYING TO FIND OUT IF ANYONE KNOWS OF PROBLEMS WITH GM PONTIAC BONNEVILLE'S PLASTIC UPPER EXHAUST MANIFOLD. WE OWN A 2000 BONNEVILLE WITH 83K MILEAGE. THE PLASTIC MANIFOLD EXPLODED WHILE TRYING TO START THE CAR. WE ARE TRYING TO RESOLVE THIS WITH GM AT THIS TIME. WE LEARNED THAT THIS HAS OCCURRED BEFORE WITH OTHER YEAR BONNEVILLES. *TR
NHTSA ODI #10222041
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration