Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1025–50K
3050–75K
2475–100K
21100–150K
7150K+
96 reports with mileage · 227 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports12 fire reports12 injury reports
What owners actually said
323 reports
45,000 miles · Jan 2, 2003
Power Train
I HAVE A PLYMOUTH VOYAGER WITH 47,000 MI. I'D ONLY HAD IT FOR 4 MOS. WHEN THE TRANSMISSION STARTED TO ACT UP. I HAVE BEEN TOLD THAT IT IS PROBABLY ON IT'S WAY OUT SEEING AS CHRYSLER KNOWS NOT HOW TO MAKE A WORKING PRODUCT. IT IS VERY DANGEROUS FOR ME TO TRY TO PULL OUT ONTO A ROAD WHEN I AM NOT SURE WHETHER OR NOT I AM GOING T…
Read full complaint
I HAVE A PLYMOUTH VOYAGER WITH 47,000 MI. I'D ONLY HAD IT FOR 4 MOS. WHEN THE TRANSMISSION STARTED TO ACT UP. I HAVE BEEN TOLD THAT IT IS PROBABLY ON IT'S WAY OUT SEEING AS CHRYSLER KNOWS NOT HOW TO MAKE A WORKING PRODUCT. IT IS VERY DANGEROUS FOR ME TO TRY TO PULL OUT ONTO A ROAD WHEN I AM NOT SURE WHETHER OR NOT I AM GOING TO BE ABLE TO GO. WHEN I DO AND IT DOESN'T MOVE, I THEN HAVE TO HURRY UP AND GUN IT SO AS NOT TO GET HIT FROM ONCOMING TRAFFIC. THE CAR THEN JERKS INTO GEAR AFTER REVING UP TO AROUND 50 IF I TAKE IT THAT FAR. I USUALLY DON'T BECAUSE THEN ENGINE SOUNDS LIKE IT IS SCREAMING. SHIFTING IS A PROBLEM. IT IS WELL KNOWN TO MOST CHRYSLER OWNERS THAT THERE IS A SERIOUS PROBLEM WITH THEIR TRANSMISSIONS, YET CHRYSLER DOES NOTHING TO UPGRADE OR FIX THE DEFECTS. HAD I KNOWN THIS INFORMATION BEFORE I HAD BOUGHT THE CAR, I WOULD'VE BOUGHT A DIFFERENT MAKE VEHICLE.
NHTSA ODI #10000469
Mileage unknown · Jan 1, 2003
Exterior Lighting
98 PLYMOUTH VOYAGER VIN #[XXX] PLEASE BE ADVISED THAT MY ACRYLIC HEAD LAMPS HAVE BECOME PITTED VIA NORMAL DRIVING. I BELIEVE THIS CAUSES LOSS OF VISIBILITY DURING NIGHTTIME OPERATION. VISIBILITY MAY BE LOWERED BY MORE THAN 50%. I THINK THIS MAY BE A COMMON SITUATION IN VEHICLES NATIONALLY. PLEASE ADVISE ME ON THE PROPER STEPS …
Read full complaint
98 PLYMOUTH VOYAGER VIN #[XXX] PLEASE BE ADVISED THAT MY ACRYLIC HEAD LAMPS HAVE BECOME PITTED VIA NORMAL DRIVING. I BELIEVE THIS CAUSES LOSS OF VISIBILITY DURING NIGHTTIME OPERATION. VISIBILITY MAY BE LOWERED BY MORE THAN 50%. I THINK THIS MAY BE A COMMON SITUATION IN VEHICLES NATIONALLY. PLEASE ADVISE ME ON THE PROPER STEPS TO RECTIFY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10000668
Mileage unknown · Dec 30, 2002
Electrical System
WHILE DRIVING VEHICLE AT ANY SPEED, SOME TIMES THE SPEEDOMETER GOES OUT, CAN'T TELL HOW FAST VEHICLE IS GOING. THE HORN STOPS BLOWING AND HEAD LIGHTS COME ON AND OFF WITHOUT WARNING. CONSUMER FEELS THERE MAY BE AN ELECTRICAL PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #10001647
Mileage unknown · Dec 14, 2002
SteeringUnknown Or Other
TENSIONER FREEZES UP AND HAS TO BE REPLACED. THIS HAS HAPPENED TWICE IN ONE YEAR. EACH OF THE TWO DIFFERENT DEALERS CHARGED ME DIFFERENT AMOUNTS,ONE CHARGED 106.00 AND THE OTHER CHARGED 275.00. I HAVE BEEN TOLD THIS CAN BE VERY DANGEROUS BY THE DEALER AND NEEDS TO BE FIXED. I WONDER WHY THEN IF IT IS SO DANGEROUS AND SO MANY PEO…
Read full complaint
TENSIONER FREEZES UP AND HAS TO BE REPLACED. THIS HAS HAPPENED TWICE IN ONE YEAR. EACH OF THE TWO DIFFERENT DEALERS CHARGED ME DIFFERENT AMOUNTS,ONE CHARGED 106.00 AND THE OTHER CHARGED 275.00. I HAVE BEEN TOLD THIS CAN BE VERY DANGEROUS BY THE DEALER AND NEEDS TO BE FIXED. I WONDER WHY THEN IF IT IS SO DANGEROUS AND SO MANY PEOPLE ARE HAVING THE SAME PROBLEM IT HAS NOT BEEN RECALLED.
NHTSA ODI #10000051
Mileage unknown · Dec 10, 2002
Unknown Or OtherCrash
CONSUMER STATES VEHICLE WAS IN ACCIDENT VEHICLE WAS TOTAL, THE SEATBELTS DIDN'T LOCK AND AIRBAGS DIDN'T DEPLOY. THE LISTED ITEMS WERE ON RECALL BUT THE CONSUMER WAS NOT NOTIFIED UNTIL A MONTH AFTER ACCIDENT BUT NOW VEHICLE HAS BEEN DESTROYED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS
NHTSA ODI #8024131
Mileage unknown · Dec 10, 2002
Vehicle Speed Control
CONSUMER STATES THAT AFTER THEY BROUGHT THEIR VEHICLE TO THE DEALERSHIP TO HAVE THE RECALL DONE FOR FUEL LEAKAGE, THE DEALERSHIP STATED THAT THEY HAD TO ORDER A SPECIAL PART TO COMPLETE THE RECALL AND THEY WILL CALL THE CONSUMER WHEN THEY RECEIVED THE PART. THE DEALERSHIP HAS NOT GOTTEN BACK IN CONTACT WITH CONSUMER, AND THE …
Read full complaint
CONSUMER STATES THAT AFTER THEY BROUGHT THEIR VEHICLE TO THE DEALERSHIP TO HAVE THE RECALL DONE FOR FUEL LEAKAGE, THE DEALERSHIP STATED THAT THEY HAD TO ORDER A SPECIAL PART TO COMPLETE THE RECALL AND THEY WILL CALL THE CONSUMER WHEN THEY RECEIVED THE PART. THE DEALERSHIP HAS NOT GOTTEN BACK IN CONTACT WITH CONSUMER, AND THE VEHICLE IS LEAKING FUEL. TS
NHTSA ODI #8024046
Mileage unknown · Dec 9, 2002
Power Train
CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE TRANSMISSION WILL START TO MAKE A CLUNKING NOISE CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS
NHTSA ODI #8023939
Mileage unknown · Dec 5, 2002
Visibility
MY WINDSHIELD WIPERS TURN ON AND DO NOT TURN OFF DESPITE HAVING REPLACED THE MULTIFUNCTION SWITCH (BY AAA SERVICE CENTER UPON ADVISEMENT OF CHRYSLER DEALER) AND REPLACEMENT OF WIPER MOTOR WITH A MOPAR REBUILT MOTOR WHILE TRAVELING. I CURRENTLY HAVE THE POWER DISCONNECTED TO THE WIPER MOTOR AND RECONNECT WHEN IT RAINS OR SNOWS. T…
Read full complaint
MY WINDSHIELD WIPERS TURN ON AND DO NOT TURN OFF DESPITE HAVING REPLACED THE MULTIFUNCTION SWITCH (BY AAA SERVICE CENTER UPON ADVISEMENT OF CHRYSLER DEALER) AND REPLACEMENT OF WIPER MOTOR WITH A MOPAR REBUILT MOTOR WHILE TRAVELING. I CURRENTLY HAVE THE POWER DISCONNECTED TO THE WIPER MOTOR AND RECONNECT WHEN IT RAINS OR SNOWS. THE WIPER BLADES WORKING ON THE DRY WINDSHIELD WEARS THEM OUT REDUCES VISABILITY. DT
NHTSA ODI #770471
Mileage unknown · Dec 2, 2002
Air Bags
AFTER DEALERSHIP DID THE RECALL FOR THE CLOCK SPRING THE SPEED CONTROL LIGHT CAME ON AND STAYED ON. TS
NHTSA ODI #8023543
Mileage unknown · Nov 21, 2002
Air Bags
INTERMITENTLY AIR BAG LIGHT. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION.TS
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1998 Plymouth Voyager Problems, Complaints & Recalls | Skip That Year
Illustration