NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
80 reportsClear category filter165,200 miles · Jun 1, 2009
Visibility
TL*THE CONTACT OWNS A 1996 DODGE PLYMOUTH VOYAGEER WHEN THE VEHICLE WAS STARTED, THE FRONT WINDSHIELD WIPERS OPERATED WITHOUT BEING ACTIVATED. MOMENTS LATER, THE WIPERS WOULD SHUT OFF ON THEIR OWN. IN COLD TEMPERATURES, THE WINDSHIELD WIPERS WOULD BECOME STUCK TO THE FRONT WINDSHIELD. THERE WERE NO RECALLS FOR THE FAILURES. …
Read full complaint
TL*THE CONTACT OWNS A 1996 DODGE PLYMOUTH VOYAGEER WHEN THE VEHICLE WAS STARTED, THE FRONT WINDSHIELD WIPERS OPERATED WITHOUT BEING ACTIVATED. MOMENTS LATER, THE WIPERS WOULD SHUT OFF ON THEIR OWN. IN COLD TEMPERATURES, THE WINDSHIELD WIPERS WOULD BECOME STUCK TO THE FRONT WINDSHIELD. THERE WERE NO RECALLS FOR THE FAILURES. THE FAILURE AND CURRENT MILEAGES WERE LESS 165,200. UPDATED 06/23/09. *LJ UPDATED 06/23/09.*JB
NHTSA ODI #10272529
116,250 miles · Aug 7, 2008
Electrical SystemEngine And Engine CoolingEquipment
TL*THE CONTACT OWNS A 1996 PLYMOUTH VOYAGER. SINCE NOVEMBER OF 2003, THE TRANSMISSION HAS BEEN REPLACED THREE DIFFERENT TIMES. AFTER PURCHASING A BRAND NEW TRANSMISSION, IT FAILED AGAIN THE VERY SAME DAY AND NEEDED TO BE REPLACED AGAIN. THE CONTACT HAS HAD THE TOP HALF OF THE ENGINE REBUILT. THE VEHICLE IS STUCK IN DRIVE AND…
Read full complaint
TL*THE CONTACT OWNS A 1996 PLYMOUTH VOYAGER. SINCE NOVEMBER OF 2003, THE TRANSMISSION HAS BEEN REPLACED THREE DIFFERENT TIMES. AFTER PURCHASING A BRAND NEW TRANSMISSION, IT FAILED AGAIN THE VERY SAME DAY AND NEEDED TO BE REPLACED AGAIN. THE CONTACT HAS HAD THE TOP HALF OF THE ENGINE REBUILT. THE VEHICLE IS STUCK IN DRIVE AND WILL NOT HOLD FLUID. THE FRONT WINDSHIELD WIPERS ACTIVATE WITHOUT A POWER SURGE IN THE VEHICLE. IN ADDITION, THE REAR BOLTS KEEP COMING OUT OF THE SHOCKS. THE CONTACT HAS TAKEN THE VEHICLE TO HAVE THE BOLTS TIGHTENED THREE OR FOUR TIMES. THE ENGINE IS TICKING AND SMOKING. THE SERPENTINE BELT SLIPS OFF IF IT GETS EVEN SLIGHTLY WET FROM SNOW OR RAIN. THE CHECK ENGINE LIGHT SPORADICALLY FLASHES ON AND OFF OR CONSTANTLY REMAINS ILLUMINATED. THE AIR CONDITIONER WAS COMPLETELY SERVICED; HOWEVER, IT CANNOT BE USED BECAUSE OF THE TRANSMISSION FAILURE. THE CURRENT MILEAGE WAS 155,000 AND FAILURE MILEAGE WAS 116,250. UPDATE 09/10/08 *CW UPDATED 09/15/08. *JB
NHTSA ODI #10237372
68,000 miles · Apr 15, 2008
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1996 CHRYSLER VOYAGER. AFTER PURCHASING THE VEHICLE, THE DEFOGGER FAILED TO OPERATE NORMALLY. THE DRIVER HAD TO STOP THE VEHICLE IN ORDER TO CLEAN THE WINDOWS. THERE HAVE BEEN SEVERAL FAILURES WITH THE VEHICLE SINCE IT WAS PURCHASED. THE ENGINE WAS REBUILT AND THE SERPENTINE BELT WAS REPLACED ON FIVE OC…
Read full complaint
TL*THE CONTACT OWNS A 1996 CHRYSLER VOYAGER. AFTER PURCHASING THE VEHICLE, THE DEFOGGER FAILED TO OPERATE NORMALLY. THE DRIVER HAD TO STOP THE VEHICLE IN ORDER TO CLEAN THE WINDOWS. THERE HAVE BEEN SEVERAL FAILURES WITH THE VEHICLE SINCE IT WAS PURCHASED. THE ENGINE WAS REBUILT AND THE SERPENTINE BELT WAS REPLACED ON FIVE OCCASIONS. THE STEERING WAS REPLACED INCORRECTLY BY A DEALER AND WAS AUTHORIZED BY THE MANUFACTURER TO BE REPLACED. THE BRAKES AND THE HEATING SYSTEM WERE REPLACED UNDER THE EXTENDED WARRANTY; HOWEVER, THE BRAKES WERE REPLACED FOUR TIMES. THE CONTACT WAS CHARGED $100 PER VISIT. INVOICES ARE AVAILABLE IF NEEDED. A COMPLAINT WAS ALSO FILED WITH THE STATE ATTORNEY GENERAL. THE CONTACT IS DISABLED AND AWARE OF THE SAFETY RISK INVOLVED IN THE NUMEROUS VEHICLE FAILURES. ON MARCH 27, 2008, THE DEALER REPLACED THE MANIFOLD AND CYLINDER. ON APRIL 14, 2008, WHILE MAKING A RIGHT TURN AT APPROXIMATELY 30 MPH, THE STEERING WHEEL LOCKED. THE VEHICLE WAS TOWED BACK TO THE DEALER. THE DEALER STATED THAT THEY REALLY CARE ABOUT THEIR CUSTOMERS AND WOULD BE WILLING TO DO A BUYOUT. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 80,995.
NHTSA ODI #10225109
116,250 miles · Nov 18, 2007
Engine And Engine CoolingPower TrainSuspension
I OWN A 1996 PLYMOUTH VOYAGER AND ON THIS MIN VAN THE WIPERS ACT VERY ERRATIC. THEY WORK WHEN THEY WANT. SOMETIMES THEY WON'T SHUT OFF AND OTHER TIMES THEY WILL NOT COME ON AT ALL OR STOP RIGHT IN THE MIDDLE OF YOUR VIEW. I ALSO HAVE AN ISSUE WITH THE SERPENTINE BELTS POPPING OFF THE DRIVE LINE LEAVING YOU WITH NO POWER STEER…
Read full complaint
I OWN A 1996 PLYMOUTH VOYAGER AND ON THIS MIN VAN THE WIPERS ACT VERY ERRATIC. THEY WORK WHEN THEY WANT. SOMETIMES THEY WON'T SHUT OFF AND OTHER TIMES THEY WILL NOT COME ON AT ALL OR STOP RIGHT IN THE MIDDLE OF YOUR VIEW. I ALSO HAVE AN ISSUE WITH THE SERPENTINE BELTS POPPING OFF THE DRIVE LINE LEAVING YOU WITH NO POWER STEERING OR POWER BRAKES AND COMPLETELY DISABLES THE VEHICLE. I ALSO EXPERIENCE ISSUES WITH THE REAR SHOCKS. THE BOLTS COME LOOSE AND DETACHES THE REAR SHICK FROM THE VAN LEAVING IT QUITE UNCONTROLLABLE WHILE DRIVING. ALL 3 ISSUES HAPPENS ON MANY OCCASIONS. ALL 4 OF THESE DEFECTS MAKE THIS VAN VERY DANGEROUS TO DRIVE OR TRAVEL WITH. CURRENTLY MY VAN IS SITTING IN MY DRIVE WITH A BAD TRANSMISSION. I HAVE OWNED THE VAN FOR 5 YEARS NOW AND IN 5 YEARS I HAVE BLOWN 3 TRANSMISSIONS. *TR
NHTSA ODI #10209285
63,000 miles · Nov 4, 2005
Visibility
DT: THE CONTACT STATED SINCE THE PURCHASE OF USED VEHICLE THE DEFROSTER DID NOT WORK. WITHOUT USE OF THE DEFROSTER THERE WAS POOR VISIBILITY. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER HAS MADE SEVERAL ATTEMPTS TO REPAIR THIS PROBLEM. HOWEVER, THEY HAVE BEEN UNABLE TO CORRECT THIS PROBLEM. THE MANUFACTURER WAS CONTAC…
Read full complaint
DT: THE CONTACT STATED SINCE THE PURCHASE OF USED VEHICLE THE DEFROSTER DID NOT WORK. WITHOUT USE OF THE DEFROSTER THERE WAS POOR VISIBILITY. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER HAS MADE SEVERAL ATTEMPTS TO REPAIR THIS PROBLEM. HOWEVER, THEY HAVE BEEN UNABLE TO CORRECT THIS PROBLEM. THE MANUFACTURER WAS CONTACTED , AND THEY OFFERED NO ASSISTANCE. *AK UPDATED 11/29/2005 - *NM
NHTSA ODI #10141757
63,320 miles · Nov 2, 2005
EquipmentService Brakes, HydraulicSteering
DT: THE CONTACT STATED THERE WERE SEVERAL SAFETY DEFECTS WITHIN VEHICLE. THE SERVICE DEALER ATTEMPTED TO REPAIR THE VEHICLE NUMEROUS TIMES. THERE WAS A PROBLEM WITH THE DEFROSTING SYSTEM, THE AIR CONDITIONING BELT, HEATER CORE, AND HEATER BLOWER, THEY WERE ALL REPLACED. THE REPLACEMENT OF THESE PARTS DID NOT SOLVE THE DE…
Read full complaint
DT: THE CONTACT STATED THERE WERE SEVERAL SAFETY DEFECTS WITHIN VEHICLE. THE SERVICE DEALER ATTEMPTED TO REPAIR THE VEHICLE NUMEROUS TIMES. THERE WAS A PROBLEM WITH THE DEFROSTING SYSTEM, THE AIR CONDITIONING BELT, HEATER CORE, AND HEATER BLOWER, THEY WERE ALL REPLACED. THE REPLACEMENT OF THESE PARTS DID NOT SOLVE THE DEFROSTING PROBLEM. THE STEERING COLUMN SHOOK WHILE DRIVING AT NORMAL SPEEDS. THE DEALER HAS NOT BEEN ABLE TO DIAGNOSE THE SOURCE OF THE STEERING VIBRATION. THERE WAS A SQUEAKING NOISE IN THE BRAKES. THE DEALER SAID THIS WAS NORMAL BECAUSE THE VEHICLE WAS NOT IN USE FOR A LONG PERIOD OF TIME. THE DEALER INDICATED THE NOISE WOULD END WITH NORMAL USE, BUT THE NOISE CONTINUED. *AK UPDATED 12/7/2005 - *NM
NHTSA ODI #10141538
Mileage unknown · Jan 19, 2005
Visibility
BODY CONTROL MODULE HAS FAILED--PARK CIRCUIT FAILING--CAUSES WINDSHIELD WIPERS NOT TO FUNCTION(DESCRIPTION GIVEN TODAY-JAN. 19. ON JAN. 18, SERVICE DEPT COULD NOT LOCATE PROBLEM. WHEN AT DEALERSHIP TO PICK UP VEHICLE, SERVICE DEPT STATED VEHICLE HAD BEEN REPAIRED; NO PROBLEM. BEFORE LEAVING PREMISES, WINDSHIELD WIPERS WER…
Read full complaint
BODY CONTROL MODULE HAS FAILED--PARK CIRCUIT FAILING--CAUSES WINDSHIELD WIPERS NOT TO FUNCTION(DESCRIPTION GIVEN TODAY-JAN. 19. ON JAN. 18, SERVICE DEPT COULD NOT LOCATE PROBLEM. WHEN AT DEALERSHIP TO PICK UP VEHICLE, SERVICE DEPT STATED VEHICLE HAD BEEN REPAIRED; NO PROBLEM. BEFORE LEAVING PREMISES, WINDSHIELD WIPERS WERE NOT FUNCTIONING. I HAD PAID $509.65. WHICH INCLUDED THE COST OF THE REPAIR OF THE WINDSHIELD WIPERS. IT WAS REPORTED THAT THE PROBLEM WAS A MULTI-FUNCTION SWITCH WHICH WAS SUPPOSED TO HAVE CORRECTED THE PROBLEM. NOW, I AM BEING CHARGED $385 FOR A BODY CONTROL MODULE THAT MUST BE ORDERED---MORE INCONVENIENCE FOR ME AS WELL AS RECHARGING ME FOR A PROBLEM THAT WAS SUPPOSED TO BE CORRECTED. *NM
NHTSA ODI #10107571
100,000 miles · Oct 19, 2004
Electrical SystemVisibility
WINDSHIELD WIPERS WORKED INTERMITTENTLY. THE CONSUMER ALSO EXPERIENCED ELECTRICAL DEFECTS. THE LIGHTS AND RADIO WERE SOMETIMES EFFECTED. PROVIDE FURTHER DETAILS. *JB CONSUMER FEELS THIS IS VERY DANGEROUS SINCE THE WIPERS STOP WORKING IN THE MIDDLE OF A RAIN STORM WHICH LEADS TO POOR VISIBILITY. *TT
NHTSA ODI #10091481
94,000 miles · Sep 29, 2004
Visibility
WE BOUGHT A PLYMOUTH VOYAGER AND WE HAVE HAD STEADY PROBLEMS WITH THE WINDSHIELD WIPERS. EITHER THEY STOP IN THE MIDDLE OF A PATH AND JUST QUIT WORKING. TWO YEARS AGO THEY STOPPED WORKING AT ALL, LUCKILY WE LIVED IN WYOMING WITH LITTLE RAIN. LAST YEAR WE MOVED TO FLORIDA AND THEY WORKED FOR A WHILE AND NOW STOPPED AGAIN. WE HAVE…
Read full complaint
WE BOUGHT A PLYMOUTH VOYAGER AND WE HAVE HAD STEADY PROBLEMS WITH THE WINDSHIELD WIPERS. EITHER THEY STOP IN THE MIDDLE OF A PATH AND JUST QUIT WORKING. TWO YEARS AGO THEY STOPPED WORKING AT ALL, LUCKILY WE LIVED IN WYOMING WITH LITTLE RAIN. LAST YEAR WE MOVED TO FLORIDA AND THEY WORKED FOR A WHILE AND NOW STOPPED AGAIN. WE HAVE REPLACED THE SWITCH ( AS THE DEALERSHIP SUGGESTED) BUT IT DID NOT HELP, ( 89.00) THEN WE WERE TOLD IT WAS A MOTOR SO WE REPLACED THAT AT 110.00, NO DIFFERENCE, THE RELAYS ARE GOOD AN NOW THEY THINK IT IS THE COMPUTER. 600.00. WINDSHIELD WIPERS SEEM TRIVIAL, BUT WHEN YOU LIVE IN FLORIDA AND CANNOT SAFELY EVACUATE FOR HURRICANES ( AND WE HAVE SEEN 4 IN THE LAST MONTH) BECAUSE DRIVING THE FAMILY VEHICLE IN THE RAIN ENDANGERS LIVES EITHER WAY. ONE OF MY BIG COMPLAINTS IS JUST THAT A 600.00 COMPUTER IS USED TO CONTROL WIPERS THAT SHOULD BE ABLE TO BE USED IN EMERGENCY, THERE IS NO WARNING OR BYPASS THEY JUST WILL NOT WORK. MINIVANS CARRY WHOLE FAMILIES, AND CAN CARRY THEM ALL TO THEIR DEATHS IF THIS HAPPENS IN A DOWNPOUR AND THE WIPERS STOP WITHOUT WARNING. IT IS AN OUTRAGE THAT COMPANIES LIKE DODGE ARE ALLOWED TO PRODUCE VEHICLES LIKE THIS AND NOT OFFER SUPPORT IN FIXING THEM OR EVEN KNOW WHAT IT IS FOR SURE. AND SINCE WE JUST SPENT SO MUCH PAYING THIS VAN OFF WE HAVE VERY LITTLE LEFT TO PUT INTO ANY MORE REPAIRS AND NOTHING LEFT FOR THE PURCHASE OF ANOTHER VEHICLE. IS THERE ANYONE I CAN WRITE TO PUT PRESSURE ON DODGE TO QUIT PRODUCING THESE TYPES OF VEHICLES AND TO MAYBE COME UP WITH A BETTER ANSWER TO OUR WIPER PROBLEMS SO THAT THEY ARE NOT COMPUTER CONTROLLED AND OUR LIVES ARE HANGING IN THE BALANCE OF A GLITCH IN SOMETHING SO SIMPLE AS WIPERS BUT SOMETHING SO BASIC AND SO NEEDED? I WILL KEEP LOOKING FOR SOME JUSTICE SOMEWHERE AND SEE IF THERE IS ANYONE OUT THERE WHO CAN HELP MAKE THIS RIGHT BEFORE SOMEONE DIES AS A RESULT. THANK YOU ! TAMMY KANE *AK
NHTSA ODI #10093314
Mileage unknown · Jul 15, 2004
Visibility
CONSUMER STATED THAT WINDSHIELD WIPERS AND BLADES WERE REPAIRED TWICE AND EACH TIME THEY BROKE AGAIN. THE WINDSHIELD WIPERS MALFUNCTIONED WHILE DRIVING OR THEY JUST STARTED WHILE DRIVING. CONSUMER STOPPED THEM BY CUTTING THE VEHICLE OFF. THE DEALER WANTED TO CHARGE THE CONSUMER THIS TIME FOR REPAIRS. BUT THE CONSUMER IN…
Read full complaint
CONSUMER STATED THAT WINDSHIELD WIPERS AND BLADES WERE REPAIRED TWICE AND EACH TIME THEY BROKE AGAIN. THE WINDSHIELD WIPERS MALFUNCTIONED WHILE DRIVING OR THEY JUST STARTED WHILE DRIVING. CONSUMER STOPPED THEM BY CUTTING THE VEHICLE OFF. THE DEALER WANTED TO CHARGE THE CONSUMER THIS TIME FOR REPAIRS. BUT THE CONSUMER INSISTED THAT IT WAS A MANUFACTURING DEFECT AND HAD ALREADY REPLACED THE WINDSHIELD WIPER MOTOR.*AK *JB
NHTSA ODI #10076215
Defect investigations
14EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96025 · Sliding Door Latch Failure
Opened Oct 15, 1996 · Closed Jul 30, 1998
Status: closed (inferred from source dates) · Structure
ANALYSIS OF KNOWN INCIDENTS INDICATES A DECLINING TREND OVER THE LAST FIVE CALENDAR QUARTERS.EXTENSIVE TESTING OF INCIDENT VEHICLES HAS FAILED TO REPRODUCE OCCURRENCES OF FULL LATCH DISENGAGEMENT.NO FAILURE MODE WHICH COULD CAUSE A PROPERLY LATCHED DOOR TO LOSE FULL LATCH ENGAGEMENT WHILE DRIVING HAS BEEN VERIFIED AS A CAUSAL FACTOR IN ANY OF THE KNOWN INCIDENT VEHICLES DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.HOWEVER, ODI WILL CONTINUE TO MONITOR COMPLAINT INPUT FOR THE NEXY YEAR AND WILL REQUEST UPDATED REPORTS FROM CHRYSLER DURING THAT PROCESS.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96038 · Sliding Door Latch Failure
Opened May 16, 1996 · Closed Oct 15, 1996
Status: closed (inferred from source dates) · Structure
CHRYSLER MAINTAINS THAT THE COMMON FACTOR CONTRIBUTING TO KNOWN SLIDING DOOR OPENING INCIDENTS IS PRIOR INCORRECT DEALER LATCH ADJUSTMENT.CHRYSLER ATTRIBUTES THIS PROBLEM TO AN INACCURATE SERVICE MANUAL PROCEDURE - SLIDING DOOR LATCH/LOCK CONTROL, REMOVAL AND INSTALLATION.CHRYSLER FURNISHED INFORMATION SHOWING THAT SIX OF ITS COMPLAINTS, AND TWO OF ODI'S, INVOLVED VEHICLES THAT HAD UNDERGONE PRIOR REPAIRS TO THE AFFECTED SLIDING DOOR.CHRYSLER HAS ADDRESSED THE PROBLEM BY ISSUING TWO TECHNICAL SERVICE BULLETINS.TSB 26-06-96, SERVICE MANUAL REVISIONS, WAS ISSUED IN JUNE 1996 AND INCLUDES A SERVICE REVISION (#81-370-6105A) CORRECTING SERVICE MANUAL SLIDING DOOR REPAIR PROCEDURES.TSB 23-39-96, SLIDING DOOR(S) DIFFICULT TO OPEN FROM THE OUTSIDE AND/OR INSIDE, WAS ISSUED JUNE 28, 1996.CHRYSLER IDENTIFIED THREE DESIGN CHANGES INVOLVING THE SUBJECT COMPONENTS: (1)SLIDING DOOR LATCH PAWL SPRING FORCE INCREASED FROM 5.4 NEWTONS TO 8.0 NEWTONS IN SEPTEMBER 1995 TO ENHANCE PAWL ROTATION RETURN TO NEUTRAL POSITION; (2)ADJUSTABLE SLIDING DOOR HINGE IMPLEMENTED IN NOVEMBER 1995 TO REDUCE VARIATION IN SLIDING DOOR FIT; AND(3)SLIDING DOOR STRIKER ATTACHMENT HOLES REVISED IN JANUARY 1996 TO ELIMINATE UP/DOWN ADJUSTMENT OF STRIKER TO IMPROVE INSTALLATION PROCESS AND REDUCE VARIABILITY OF ALIGNMENT BETWEEN LATCH AND STRIKER.AT PRESENT, ODI IS NOT AWARE OF ANY INCIDENTS INVOLVING VEHICLES BUILT IN OR AFTER JANUARY 1996.ODI HAS CONTINUED TO RECEIVE COMPLAINTS OF SLIDING DOORS OPENING WHILE THE VEHICLES ARE IN MOTION, INCLUDING VEHICLES WITH NO PRIOR SERVICE HISTORY TO THE AFFECTED SLIDING DOOR ASSEMBLY.OWNERS ALLEGE THAT THE DOORS OPEN ANYWHERE FROM A FEW INCHES TO FULLY OPEN, AT SPEEDS RANGING FROM 15 TO 60 MPH.ODI HAS ALSO RECEIVED NUMBEROUS COMPLAINTS ALLEGING DIFFICULTY IN LATCHING THE SUBJECT SLIDING DOORS AND/OR DIFFICULTY IN OPENING ONE OR BOTH SLIDING DOORS.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration