NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
18 reportsClear category filterMileage unknown · Nov 29, 2005
Exterior Lighting
THE HEADLIGHT LENSES ON MY 1996 PLYMOUTH VOYAGER VAN ARE DETERIORATING. YOU COULD SAY THEY ARE FOGGING UP. I LOOKED AT THEM WITH A MAGNIFYING GLASS AND IT LOOKS LIKE THERE ARE TINY CRACKS. IT IS DEGRADING THE LIGHT EMANATING FROM THE LENSES TO SUCH AN EXTENT THAT NIGHT DRIVING IS REALLY DANGEROUS. MY BRIGHTS ARE DIMMER THAN MOST…
Read full complaint
THE HEADLIGHT LENSES ON MY 1996 PLYMOUTH VOYAGER VAN ARE DETERIORATING. YOU COULD SAY THEY ARE FOGGING UP. I LOOKED AT THEM WITH A MAGNIFYING GLASS AND IT LOOKS LIKE THERE ARE TINY CRACKS. IT IS DEGRADING THE LIGHT EMANATING FROM THE LENSES TO SUCH AN EXTENT THAT NIGHT DRIVING IS REALLY DANGEROUS. MY BRIGHTS ARE DIMMER THAN MOST CARS' LOW BEAMS. *NM
NHTSA ODI #10143864
Mileage unknown · Aug 9, 2005
Exterior Lighting
1996 PLYMOUTH GRAND VOYAGER SE, HEADLAMP LENSES TURN OPAQUE WHEN THEY AGE UNTIL THEY REACH A POINT WHERE IT IS DANGEROUS TO OPERATE THE VEHICLE AT NIGHT. I CALLED A DEALER AND HE SAID THEY ARE MADE OF PLASTIC AND IT IS UP TO THE CONSUMER TO REPLACE THEM AT A COST OF $558.00 ($279.00 EACH). I CONSIDER THIS A SAFETY DEFECT - THE…
Read full complaint
1996 PLYMOUTH GRAND VOYAGER SE, HEADLAMP LENSES TURN OPAQUE WHEN THEY AGE UNTIL THEY REACH A POINT WHERE IT IS DANGEROUS TO OPERATE THE VEHICLE AT NIGHT. I CALLED A DEALER AND HE SAID THEY ARE MADE OF PLASTIC AND IT IS UP TO THE CONSUMER TO REPLACE THEM AT A COST OF $558.00 ($279.00 EACH). I CONSIDER THIS A SAFETY DEFECT - THE LENSES SHOULD BE MADE OUT OF A MATERIAL THAT DOES NOT DEGRADE SIGNIFICANTLY WITH AGE. *JB
NHTSA ODI #10132089
108,000 miles · Jun 20, 2005
Exterior Lighting
DT: HEADLIGHT LENS GETS VERY CLOUDY OVER A PERIOD OF TIME. CAN NOT BE REPLACED UNLESS YOU BUY THE WHOLE UNIT AT ABOUT $250.00. CAN NOT GET LENS FROM ANYWHERE BECAUSE ALL OF THE LENSES ARE CLOUDY FOR THAT MODEL. DOES EFFECT VISIBILITY AT NIGHT. MANUFACTURER WILL NOT DO ANYTHING TO HELP. *NM *SB
NHTSA ODI #10120764
Mileage unknown · May 23, 2005
Exterior Lighting
HEADLIGHT LENS DEGRADATION
NHTSA ODI #10121863
115,000 miles · Mar 3, 2004
Exterior Lighting
WHILE DRIVING FRONT HEADLIGHT LENS WERE FOGGED, MAKING IT HARD FOR THE CONSUMER TO SEE DURING NIGHT HOURS. *AK
NHTSA ODI #10061236
Mileage unknown · Aug 10, 2002
Air BagsExterior Lighting
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #765478
Mileage unknown · Apr 10, 2001
Electrical SystemExterior LightingLatches/locks/linkages
EFECTIVE COMPONENTS INCLUDE: SPARK PLUG WIRES/ SLIDING DOOR MOTOR/CIRCUIT BOARD//DOOR HANDLES/BATTERY/IGNITION SWITCH/MULTIFUNCTION SWITCH, DOOR LOCK MOTOR/ WINDSHIELD MOTOR/ LATCH DOOR LIFT GATE, AND REAR SHOCK ABSORBER AND REAR STRUTS. PLEASE ATTACH A DESCRIPTION OF EACH OF THESE DEFECTS AND COPIES OF ANY WORK YOU HAVE HAD …
Read full complaint
EFECTIVE COMPONENTS INCLUDE: SPARK PLUG WIRES/ SLIDING DOOR MOTOR/CIRCUIT BOARD//DOOR HANDLES/BATTERY/IGNITION SWITCH/MULTIFUNCTION SWITCH, DOOR LOCK MOTOR/ WINDSHIELD MOTOR/ LATCH DOOR LIFT GATE, AND REAR SHOCK ABSORBER AND REAR STRUTS. PLEASE ATTACH A DESCRIPTION OF EACH OF THESE DEFECTS AND COPIES OF ANY WORK YOU HAVE HAD PERFORMED ON THE VEHICLE REGARDING THESE DEFECTS.*AK
NHTSA ODI #885520
Mileage unknown · Mar 24, 2001
Air BagsExterior LightingVisibility
IN MARCH MY AIRBAG LIGHT STAYED ON AND THEN THE WINDSHIELD WIPERS FAILED TO WORK. I THEN A BURNING ODOR CAME OUT OF THE HEATING UNIT. I BROUGHT IT INTO A CHRYSLER DEALERSHIP TO GET FIXED. THIS IS THE WORK NEEDED TO REPAIR THE CAR. SWITCH MULTIFUNTION, CLOCKSPRING FOR AIRBAG. COMPLETE REPLACEMENT OF THE BCM DUE TO THE AIRBA…
Read full complaint
IN MARCH MY AIRBAG LIGHT STAYED ON AND THEN THE WINDSHIELD WIPERS FAILED TO WORK. I THEN A BURNING ODOR CAME OUT OF THE HEATING UNIT. I BROUGHT IT INTO A CHRYSLER DEALERSHIP TO GET FIXED. THIS IS THE WORK NEEDED TO REPAIR THE CAR. SWITCH MULTIFUNTION, CLOCKSPRING FOR AIRBAG. COMPLETE REPLACEMENT OF THE BCM DUE TO THE AIRBAG MALFUNTION AND WIPER MALFUNCTION., REPLACED THE MULTIFUNCTION SWITCH. BCM RECONTROLLER REPROGRAMING AND REPLACED CLOCK SPRING TO REPAIR AIR BAG LAMP COMING ON. THE FINAL COST WITH LABOR TOTALED $843.44 I CALLED CHRYSLER TO SEE IF THIS MALFUNCTION WOULD BE COVERED AND I WAS TOLD NO. THE SERVICE DEPARTMENT SAID IT IS RARE THAT THE SYSTEM FAILS IN A CAR WITH MY MILAGE. CHRYSLER WAS VERY NASTY ON THE PHONE AND SAID THEY WOULD NOT CONSIDER ANY RESPONSIBILITY TOWARDS THE PAYMENT OF THE DEFECT. I ASKED TO SPEAK TO A MANAGER ETC....AND I WAS TOLD THAT I COULD NOT BE FORWARDED TO ANYONE ELSE. I WAS TOLD BY THE REP ON THE PHONE THAT THE FINAL DECISION WAS MADE. LAST WEEK I HEARD ON THE RADIO ABOUT AN INVESTIGATION ON THE POSSIBLE DEFECTS OF THE VEHICLES CLOCKSPRING ASSEMBLY WHICH PROVIDES THE ELECTRICITY FOR THE WIPERS ETC....I DID NOT CHECK TO SEE IF IT HAD AFFECTED THE HORN OR CRUISE CONTROL BECAUSE I HAD NOT USED BOTH DURING THAT TIME. IT SEEMS THE FAULTY CLOCKSPRING POSSIBLE BLEW OUT THE ELECTRICAL SYSTEM WHICH RESULTED IN THE NEED FOR A REPLACED BCM COMPONENT. I AM HOPING IF THIS IS FOUND TO BE A DEFECT CHRYSLER WILL REIMBURSE THE $843.44 TO ME.*AK
NHTSA ODI #742957
Mileage unknown · Nov 27, 2000
Electrical SystemExterior LightingFire
VEHICLE HAD BEEN TO DEALER TWICE , WOULD NOT START, BOUGHT NEW BATTERY. NEXT DAY DEAD AGAIN. DEALER SAID HEADLIGHT STAYED ON THAT CAUSED BATTERY TO BE DRAINED. NEXT NIGHT VEHICLE WAS BURNING, FLAMES AND SMOKE FROM UNDER THE HOOD. FIRE DEPARTMENT HAD TO CUT OPEN HOOD TO GET TO ENGINE, LEFT SIDE OF ENGINE WAS MELTED. VEHICLE AT…
Read full complaint
VEHICLE HAD BEEN TO DEALER TWICE , WOULD NOT START, BOUGHT NEW BATTERY. NEXT DAY DEAD AGAIN. DEALER SAID HEADLIGHT STAYED ON THAT CAUSED BATTERY TO BE DRAINED. NEXT NIGHT VEHICLE WAS BURNING, FLAMES AND SMOKE FROM UNDER THE HOOD. FIRE DEPARTMENT HAD TO CUT OPEN HOOD TO GET TO ENGINE, LEFT SIDE OF ENGINE WAS MELTED. VEHICLE AT DEALERS SINCE THEN. *AK
NHTSA ODI #875512
Mileage unknown · Apr 28, 2000
Exterior LightingVisibility
WHEN TURNING ON LEFT SIGNAL FRONT WINDSHIELD WIPERS WILL COME ON. SOMETIMES REAR WINDSHIELD WIPERS WILL ALSO COME ON. TOOK VEHICLE TO DEALER ABOUT 5 TIMES. EACH TIME THEY SAID THAT THEY HAD FIXED IT, BUT PROBLEM REOCCURRED. THIS IS UNSAFE BECAUSE WHILE DRIVING ON FREEWAY AND WINDSHIELD WIPERS COMING ON, IT WILL DISTRACT …
Read full complaint
WHEN TURNING ON LEFT SIGNAL FRONT WINDSHIELD WIPERS WILL COME ON. SOMETIMES REAR WINDSHIELD WIPERS WILL ALSO COME ON. TOOK VEHICLE TO DEALER ABOUT 5 TIMES. EACH TIME THEY SAID THAT THEY HAD FIXED IT, BUT PROBLEM REOCCURRED. THIS IS UNSAFE BECAUSE WHILE DRIVING ON FREEWAY AND WINDSHIELD WIPERS COMING ON, IT WILL DISTRACT THE DRIVER. *AK *ML
NHTSA ODI #861120
Defect investigations
14EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96025 · Sliding Door Latch Failure
Opened Oct 15, 1996 · Closed Jul 30, 1998
Status: closed (inferred from source dates) · Structure
ANALYSIS OF KNOWN INCIDENTS INDICATES A DECLINING TREND OVER THE LAST FIVE CALENDAR QUARTERS.EXTENSIVE TESTING OF INCIDENT VEHICLES HAS FAILED TO REPRODUCE OCCURRENCES OF FULL LATCH DISENGAGEMENT.NO FAILURE MODE WHICH COULD CAUSE A PROPERLY LATCHED DOOR TO LOSE FULL LATCH ENGAGEMENT WHILE DRIVING HAS BEEN VERIFIED AS A CAUSAL FACTOR IN ANY OF THE KNOWN INCIDENT VEHICLES DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.HOWEVER, ODI WILL CONTINUE TO MONITOR COMPLAINT INPUT FOR THE NEXY YEAR AND WILL REQUEST UPDATED REPORTS FROM CHRYSLER DURING THAT PROCESS.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96038 · Sliding Door Latch Failure
Opened May 16, 1996 · Closed Oct 15, 1996
Status: closed (inferred from source dates) · Structure
CHRYSLER MAINTAINS THAT THE COMMON FACTOR CONTRIBUTING TO KNOWN SLIDING DOOR OPENING INCIDENTS IS PRIOR INCORRECT DEALER LATCH ADJUSTMENT.CHRYSLER ATTRIBUTES THIS PROBLEM TO AN INACCURATE SERVICE MANUAL PROCEDURE - SLIDING DOOR LATCH/LOCK CONTROL, REMOVAL AND INSTALLATION.CHRYSLER FURNISHED INFORMATION SHOWING THAT SIX OF ITS COMPLAINTS, AND TWO OF ODI'S, INVOLVED VEHICLES THAT HAD UNDERGONE PRIOR REPAIRS TO THE AFFECTED SLIDING DOOR.CHRYSLER HAS ADDRESSED THE PROBLEM BY ISSUING TWO TECHNICAL SERVICE BULLETINS.TSB 26-06-96, SERVICE MANUAL REVISIONS, WAS ISSUED IN JUNE 1996 AND INCLUDES A SERVICE REVISION (#81-370-6105A) CORRECTING SERVICE MANUAL SLIDING DOOR REPAIR PROCEDURES.TSB 23-39-96, SLIDING DOOR(S) DIFFICULT TO OPEN FROM THE OUTSIDE AND/OR INSIDE, WAS ISSUED JUNE 28, 1996.CHRYSLER IDENTIFIED THREE DESIGN CHANGES INVOLVING THE SUBJECT COMPONENTS: (1)SLIDING DOOR LATCH PAWL SPRING FORCE INCREASED FROM 5.4 NEWTONS TO 8.0 NEWTONS IN SEPTEMBER 1995 TO ENHANCE PAWL ROTATION RETURN TO NEUTRAL POSITION; (2)ADJUSTABLE SLIDING DOOR HINGE IMPLEMENTED IN NOVEMBER 1995 TO REDUCE VARIATION IN SLIDING DOOR FIT; AND(3)SLIDING DOOR STRIKER ATTACHMENT HOLES REVISED IN JANUARY 1996 TO ELIMINATE UP/DOWN ADJUSTMENT OF STRIKER TO IMPROVE INSTALLATION PROCESS AND REDUCE VARIABILITY OF ALIGNMENT BETWEEN LATCH AND STRIKER.AT PRESENT, ODI IS NOT AWARE OF ANY INCIDENTS INVOLVING VEHICLES BUILT IN OR AFTER JANUARY 1996.ODI HAS CONTINUED TO RECEIVE COMPLAINTS OF SLIDING DOORS OPENING WHILE THE VEHICLES ARE IN MOTION, INCLUDING VEHICLES WITH NO PRIOR SERVICE HISTORY TO THE AFFECTED SLIDING DOOR ASSEMBLY.OWNERS ALLEGE THAT THE DOORS OPEN ANYWHERE FROM A FEW INCHES TO FULLY OPEN, AT SPEEDS RANGING FROM 15 TO 60 MPH.ODI HAS ALSO RECEIVED NUMBEROUS COMPLAINTS ALLEGING DIFFICULTY IN LATCHING THE SUBJECT SLIDING DOORS AND/OR DIFFICULTY IN OPENING ONE OR BOTH SLIDING DOORS.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration