2 ITEMS OF CONCERN. THE AIRCONDITIONING UNIT HAS FAILED. WE OWN A BLUE GRAND VOYAGER MINIVAN AND THE PAINT IS PEELING FROM THE ROOF AND ENGINE HOOD OF THE CAR. WE HAVE NOTICED MANY OF THE SAME COLOR AND YEAR TRUCKS, VANS AND CARS WITH FAILING PAINT. A RECALL SHOULD HAPPEN. PAINT SHOULD NOT START PEELING AFTER 4 YEARS OF A …
Read full complaint
2 ITEMS OF CONCERN. THE AIRCONDITIONING UNIT HAS FAILED. WE OWN A BLUE GRAND VOYAGER MINIVAN AND THE PAINT IS PEELING FROM THE ROOF AND ENGINE HOOD OF THE CAR. WE HAVE NOTICED MANY OF THE SAME COLOR AND YEAR TRUCKS, VANS AND CARS WITH FAILING PAINT. A RECALL SHOULD HAPPEN. PAINT SHOULD NOT START PEELING AFTER 4 YEARS OF A CARS LIFE.*AK
NHTSA ODI #10028470
Mileage unknown · Aug 22, 2001
Engine And Engine CoolingEquipmentFuel System, Gasoline
WHILE DRIVING 55 MPH VEHICLE STALLED, DEALER REPLACED A LEAKING FUEL LINE. VEHICLE HAS STALLED SINCE. DEALER CANNOT REMEDY.*AK A/C IS COLD BUT NOT BLOWING THROUGH THE VENTS, ONLY BLOWING THROUGH THE DEFROST VENTS, ALSO A/C WAS BLOWING OUT HOT AIR, BLOWER MOTOR STOPPED WORKING FOR A SHORT PERIOD OF TIME, DUE TO A DEAD BATTERY,F…
Read full complaint
WHILE DRIVING 55 MPH VEHICLE STALLED, DEALER REPLACED A LEAKING FUEL LINE. VEHICLE HAS STALLED SINCE. DEALER CANNOT REMEDY.*AK A/C IS COLD BUT NOT BLOWING THROUGH THE VENTS, ONLY BLOWING THROUGH THE DEFROST VENTS, ALSO A/C WAS BLOWING OUT HOT AIR, BLOWER MOTOR STOPPED WORKING FOR A SHORT PERIOD OF TIME, DUE TO A DEAD BATTERY,FUEL GAUGE DROPS TO EMPTY EVEN THOUGH THERE IS PLENTY OF GAS LEFT, TIRES WERE REPLACED SUE TO EXCESSIVE WEAR,RIGHT DOOR ELECTRICAL LOCK IS INOPERATIVE.*JB
NHTSA ODI #894947
Mileage unknown · May 1, 2001
EquipmentSeats
DRIVER'S SEAT LEANED BACKWORDS/ SEAT GAVE AWAY. SEAT HAS BEEN REPAIRED 3 TIMES. *AK THE LAST FAILURE THE FRAME IN THE SEAT WAS COMPLETELY BROKEN IN HALF. CONSUMER STATED AIR CONDITIONER WAS NOT COOLING PROPERLY, DEALER FOUND NO PROBLEMS. *SLC
NHTSA ODI #887201
Mileage unknown · Oct 17, 2000
Equipment
THE COMPRESSOR FAILURE HAS OCCURRED IN ALL CHRYSLER PRODUCTS OF A PRIOR YEAR. IT HAS BEEN DESCRIBED AS A DEFAULTED PART BY THE DEALER AND SEVERAL OTHER ASE CERTIFIED TECHNICIANS INCLUDING SEARS AND PEP BOYS. THESE REPAIR FACILITIES HAVE COMMENTED ON THE NUMBER OF REPLACEMENTS THEY HAVE HAD TO DO ON THE CHYRSLER PRODUCTS ON THE…
Read full complaint
THE COMPRESSOR FAILURE HAS OCCURRED IN ALL CHRYSLER PRODUCTS OF A PRIOR YEAR. IT HAS BEEN DESCRIBED AS A DEFAULTED PART BY THE DEALER AND SEVERAL OTHER ASE CERTIFIED TECHNICIANS INCLUDING SEARS AND PEP BOYS. THESE REPAIR FACILITIES HAVE COMMENTED ON THE NUMBER OF REPLACEMENTS THEY HAVE HAD TO DO ON THE CHYRSLER PRODUCTS ON THE SAME PART DUE TO THE FAULTY PART. THE FAILURE OCCURS ON THE VEHICLE AT VARIOUS MILEAGE READINGS SOME EARLY AND SOME LATE MODEL CARS. IT SHOULD BE RECALLED AND REPLACED AT THE MANUFACTURERS EXPENSE SINCE THEY ARE AWARE OF THE DEFECTIVE PART AND DECIDED NOT TO FIX IT BEFORE LEAVING THE MANUFACTURER BUSINESS.*AK
NHTSA ODI #734585
Mileage unknown · Mar 20, 2000
EquipmentPower TrainStructure
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #720364
Mileage unknown · Aug 6, 1999
Electrical SystemEquipment
WE HAD TO REPLACE 2 TRANSMISSION TWICE IN THE LAST 18 MONTHS, DUE TO A PIN BREAKING IN THE TRANSMISSION, AND THEY DIDN'T REPLACE SEAL , THEY USED SILICONE INSTEAD. THE AIRCONDITIIONER HAS NEVER WORKED , IT WAS WINTER WHEN WE GOT IT AND TRUST THEM TO BE HONEST, THE FIRST DAY OF HOT WEATHER IT DID NOT WORK! THE LIGHTER AND HORN …
Read full complaint
WE HAD TO REPLACE 2 TRANSMISSION TWICE IN THE LAST 18 MONTHS, DUE TO A PIN BREAKING IN THE TRANSMISSION, AND THEY DIDN'T REPLACE SEAL , THEY USED SILICONE INSTEAD. THE AIRCONDITIIONER HAS NEVER WORKED , IT WAS WINTER WHEN WE GOT IT AND TRUST THEM TO BE HONEST, THE FIRST DAY OF HOT WEATHER IT DID NOT WORK! THE LIGHTER AND HORN CANNOT BE USED TOGETHER, BECAUSE THEY BLOW FUSES, AND THEY ALSO KNEW ABOUT THAT, AND SAID THEY WOULD TAKE CARE OF IT AND NEVER DID!!!!!!
NHTSA ODI #709685
Mileage unknown · Jul 16, 1998
EquipmentPower Train
AIR CONDITIONING FAILED. ALSO, TRANSMISSION WAS SLIPPING GEARS.
NHTSA ODI #538404
Mileage unknown · May 22, 1998
Equipment
THIS IS A KNOWN PROBLEM WITH CHRYSLER. NUMEROUS OTHER OWNERS I KNOW HAVE HAD EVAPORATORS FAIL RIGHT AFTER WARRANTY PERIOD. MY VEHICLE HAS 35,000 MILES BUT IS 4 YEARS OLD SO IT IS OUT OF WARRANTY. BOTH FRONT AND REAR EVAPORATORS HAVE FAILED AT SAME TIME.
NHTSA ODI #536179
Mileage unknown · Apr 6, 1998
Equipment
A/C EVAPORATOR CORE HAS PIN HOLE IN IT DUE TO DEFECTIVE FACTORY PART. *AK
NHTSA ODI #533855
Mileage unknown · Jan 22, 1998
EquipmentPower Train
TRANSMISSION SLIPPING GEARS AND EVAPORATOR CORE OF AIR CONDITIONER FAILURE.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Consequence & remedy
Consequence: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Remedy: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
1994 Plymouth Grand Voyager Problems, Complaints & Recalls | Skip That Year
Illustration