IllustrationAS SAID AS A RECALL THE CONTROL ARM BUSTED WHILE I WAS DRIVING AND ALMOST CAUSE ME TO WRECK.
1999 Plymouth Breeze
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Plymouth Breeze do not stand out strongly from the model-year median of 117.
About this comparison →How this year compares
Owner complaints by model year
Compare all Breeze years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
325–50K
1450–75K
975–100K
8100–150K
3150K+
40 reports with mileage · 77 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports25 fire reports9 injury reports
What owners actually said
117 reportsTL* THE CONTACT OWNS A 1999 PLYMOUTH BREEZE. WHILE DRIVING 60 MPH, THE VEHICLE DECELERATED FROM 60 TO 0 MPH BEFORE REGAINING POWER AND RETURNING TO NORMAL SPEED. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE MECHANIC WHERE THE MAP SENSOR WAS REPLACED; HOWEVER,…
Read full complaint
TL* THE CONTACT OWNS A 1999 PLYMOUTH BREEZE. WHILE DRIVING 60 MPH, THE VEHICLE DECELERATED FROM 60 TO 0 MPH BEFORE REGAINING POWER AND RETURNING TO NORMAL SPEED. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE MECHANIC WHERE THE MAP SENSOR WAS REPLACED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 182,434.
1999 PLYMOUTH BREEZE (2.4 ENGINE) CAUGHT FIRE WHEN I PARKED THE CAR IN FRONT OF MY HOUSE. *TR
MY 1999 PLYMOUTH BREEZE (2.4 ENGINE) CAUGHT FIRE IN FRONT OF MY HOUSE AS SOON AS I PARKED THE CAR. *TR
DROVE THE CAR TO A RESTAURANT FOR DINNER. PARKED THE CAR AND WENT INTO THE RESTAURANT. APPROXIMATELY 15 MINUTES LATER I SAW A FIRE TRUCK IN THE AREA OF MY VEHICLE. AFTER WATCHING FOR A MOMENT I REALIZED THERE WAS SMOKE BILLOWING OUT FROM UNDER THE HOOD. AFTER THE FIREMEN OPENED THE HOOD I COULD SEE THAT SEVERAL COMPONENTS …
Read full complaint
DROVE THE CAR TO A RESTAURANT FOR DINNER. PARKED THE CAR AND WENT INTO THE RESTAURANT. APPROXIMATELY 15 MINUTES LATER I SAW A FIRE TRUCK IN THE AREA OF MY VEHICLE. AFTER WATCHING FOR A MOMENT I REALIZED THERE WAS SMOKE BILLOWING OUT FROM UNDER THE HOOD. AFTER THE FIREMEN OPENED THE HOOD I COULD SEE THAT SEVERAL COMPONENTS WERE MELTED AS WELL AS SEE SOME FIRE. AFTER I GOT THE VEHICLE TOWED TO A SECURE ENVIRONMENT I CONTACTED A PLYMOUTH DEALERSHIP, WHO GAVE ME THE PHONE NUMBER OF ANOTHER PARTY OUT OF STATE. THIS PARTY SAID THAT A LETTER INFORMING ME OF THE RECALL WAS MAILED TO ME AND THAT THEY NO LONGER HAVE ANYTHING TO DO WITH THE PROBLEM. THE DEALERSHIP WILL NOT HELP WITH FIXING THE VEHICLE. THEY ALSO STATE IT IS NOT THEIR PROBLEM.
I DROVE MY CAR FOR ABOUT HALF AN HOUR TO A INTERVIEW FOR A JOB, IT TOOK ME MAYBE 20 MINUTES TO GET THERE AND 20 MINUTES TO GET BACK HOME. I PARKED MY CAR IN THE DRIVEWAY WENT IN TO THE HOUSE 5 TO 7 MINUTES AFTER I RETURNED HOME THE CAR WAS ON FIRE. THANK GOD I WASN'T IN IT WHEN IT CAUGHT FIRE. I CALLED THE FIRE DEPARTMENT THEY P…
Read full complaint
I DROVE MY CAR FOR ABOUT HALF AN HOUR TO A INTERVIEW FOR A JOB, IT TOOK ME MAYBE 20 MINUTES TO GET THERE AND 20 MINUTES TO GET BACK HOME. I PARKED MY CAR IN THE DRIVEWAY WENT IN TO THE HOUSE 5 TO 7 MINUTES AFTER I RETURNED HOME THE CAR WAS ON FIRE. THANK GOD I WASN'T IN IT WHEN IT CAUGHT FIRE. I CALLED THE FIRE DEPARTMENT THEY PUT THE FIRE OUT. I CALLED THE MANUFACTURING COMPANY THAT MADE THE CAR AND THEY SENT SOMEONE OUT TO THE LOCATION WHERE THE CAR WAS LEFT BURNT TO A CRISP. A WEEK LATER I RECEIVED A LETTER FROM THEM TELLING ME IT WASN'T THERE FAULT. ABOUT A MONTH LATER I GOT A RECALL NOTIFICATION IN THE MAIL TELLING ME THE CAR WAS ON RECALL FOR THE VERY SAME REASON IT CAUGHT ON FIRE. II AM STILL BEING TOLD THAT THEY ARE NOT GOING TO DO ANYTHING ABOUT THIS PROBLEM BECAUSE THEY DON'T HAVE TO. THIS IS THE REASON WHY THIS COUNTRY IS IN THE SHAPE WE ARE IN NOW BECAUSE BIG COMPANY'S SUCH AS CHRYSLER CAN SELL ANYTHING THEY WANT TO THE CONSUMER AND GET AWAY WITH A SLAP ON THE WRIST. THEY DON'T HAVE TO REPLACE MY CAR OR HELP TO REPLACE IT. IT IS NOT RIGHT OR IS IT FAIR TO THE CONSUMER WHEN YOU TRUST THESE COMPANIES WITH YOUR LIFE AND BUY THIS GARBAGE THEY THROW TOGETHER AND WE UNKNOWINGLY BUY IT THINKING IT SAFE TO DRIVE. WHAT HAPPENED TO FOR THE PEOPLE, I GUESS AS LONG AS YOU ARE RICH YOU CAN DO WHATEVER YOU WANT AS LONG AS IT DOESN'T AFFECT THE WRONG PEOPLE. WHO IS LOOKING OUT FOR THE LITTLE PEOPLE WHEN THEY DON'T KNOW WHO TO TRUST. I HOPE THAT WHAT I EXPERIENCED WAS NOT WHAT THE FIBER OF THIS COUNTRY STANDS BY. INSTEAD OF RECEIVING BIG BONUSES THEY SHOULD HAVE MADE SURE THAT THERE PRODUCT WAS SAFE FOR THEIR CUSTOMERS. *TR
SHOULD HAVE A FILE ON RECORD, 1999 PLYMOUTH BREEZE SHIFTED OUT OF PARK, WITH ENGINE TURNED OFF, AND NO KEY IN IGNITION, DRIFTED BACKWARDS, RIPPED FRONT PASSENGER DOOR OFF, NEARLY RAN OVER TWO CHILDREN IN THE STREET. CALLED CHRYSLER CUSTOMER SERVICE THEY ADVISED NO RECALL ON GEAR SHIFT WILL NOT PAY FOR REPAIR. REPAIRED CAR FILE…
Read full complaint
SHOULD HAVE A FILE ON RECORD, 1999 PLYMOUTH BREEZE SHIFTED OUT OF PARK, WITH ENGINE TURNED OFF, AND NO KEY IN IGNITION, DRIFTED BACKWARDS, RIPPED FRONT PASSENGER DOOR OFF, NEARLY RAN OVER TWO CHILDREN IN THE STREET. CALLED CHRYSLER CUSTOMER SERVICE THEY ADVISED NO RECALL ON GEAR SHIFT WILL NOT PAY FOR REPAIR. REPAIRED CAR FILED COMPLAINT, 1 YEAR LATER, RECEIVED A CARD THAT GEAR SHIFT IS A MAJOR RECALL, SENT CARD AND PROOF OF REPAIR IN TO CHRYSLER, THEY REFUSED TO TAKE ANY ACTION, CALLED CHRYSLER CUSTOMER SERVICE THEY TOLD ME WE REFUSED BEFORE WE REFUSING YOU AGAIN, EVEN IF IT IS RECALLED.. I KNOW WHY THE ARE IN FINANCIAL TROUBLE WITH CUSTOMER SERVICE THE WAY THEY ARE. MY TOTAL FOR DOOR AND SHIFTER CAME TO 1300, THE SHIFTER WAS ALONE 235,00 OR SO. *TR
DAVES AUTOSALES OWNER DAVE MALMFELDT 801-560-2754 OR 801-562-8884 NEVER INFORMED US OF A SAFETY RECALL ON E23 HIGH POWER STEERING HOSE WHICH RESULTED IN A FIRE AND TOTAL LOSS OF 1999 PLYMOUTH BREEZE .THE DEFECT AND RECALL INFORMATION ANALYSIS SAFETY ASSURANCE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION. FEDERAL TRADE COMMISS…
Read full complaint
DAVES AUTOSALES OWNER DAVE MALMFELDT 801-560-2754 OR 801-562-8884 NEVER INFORMED US OF A SAFETY RECALL ON E23 HIGH POWER STEERING HOSE WHICH RESULTED IN A FIRE AND TOTAL LOSS OF 1999 PLYMOUTH BREEZE .THE DEFECT AND RECALL INFORMATION ANALYSIS SAFETY ASSURANCE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION. FEDERAL TRADE COMMISSION ON FINAL APPROVAL SHOULD BE NOTIFIED AND ALL VEHICLES REPAIRED WITHIN A 120 DAYS AFTER RECEIVING THE RECALL NOTICE. SAFETY RECALLS COMPENDIUM,MOTOR VEHICLE AND MOTOR VEHICLE EQUIPMENT IN ACCORDANCE SWITCH TITLE 49 OF THE UNITED STATES CODE CHAPTER 301 AND SUPPORTING FEDERAL REGULATIONS. DAVES AUTO SALES HAD NO INSURANCE ON HIS DEALERSHIP TO COVER THE LOSS OF THE CAR,SO HE REPLACED IT AND THEN SAID WE HAD TO PAY FOR THE CAR,AGAIN,WE ALL READY PAID $1300.00 DOWN PAYMENT 20 MONTHS OF PAYMENTS OF $166.00 LOSING 2 MORE PAYMENTS .ACCORDING TO LAW HIS DEALERSHIPS INSURANCE SHOULD OF COVERED THE LOSS OF CAR AT NO COST TO SHANE E ALLEN.SO DAVE BEAT UP THE DAUGHTER WHO WEIGHS 90 LBS 17 YRS OLD AND TOLD BACK THE CAR HE REPLACED HER ,SATURN,THERE WAS A POLICE REPORT TAKEN AND WE WERE TOLD TO TAKE THE CAR BACK IT BELONGED TO US SO WE DID. WE WANT DAVES LICENSED REVOKED AND ARE CIVILLY AND CRIMINALLY CHARGING HIM IN COURT. THIS MAN IS A THREAT TO SOCIETY. WE NEED THE TITLE MAILED TO US TO LICENSE THE CAR. *TR
EXACTLY AS THE RECALL IS PRINTED ON YOUR WEB PAGE. YOU HAVE MY ADDRESS WRONG YOU ADDED A 0 IS WHY WE NEVER RECEIVED RECALL LETTER UNTIL CAR ALREADY BURNT UP WHEN FIRE DEPARTMENT PUT IT OUT THEY INFORMED US OF RECALL. SO WE LOOKED IT UP ON WEB SITE. THANK GOD MY 17 YR OLD WASN'T INJURED. SHE IS STILL TRAUMATIZED IT WAS SCARY TO …
Read full complaint
EXACTLY AS THE RECALL IS PRINTED ON YOUR WEB PAGE. YOU HAVE MY ADDRESS WRONG YOU ADDED A 0 IS WHY WE NEVER RECEIVED RECALL LETTER UNTIL CAR ALREADY BURNT UP WHEN FIRE DEPARTMENT PUT IT OUT THEY INFORMED US OF RECALL. SO WE LOOKED IT UP ON WEB SITE. THANK GOD MY 17 YR OLD WASN'T INJURED. SHE IS STILL TRAUMATIZED IT WAS SCARY TO HER AND I WOULD OF SUED YOU IF SHE WAS HURT BUT SHE WASN'T SO REPLACE THE MONEY OR THE CAR THANK YOU SHE EARNED IT HERSELF. WERE HONEST PEOPLE AND WANT A RESOLUTION WITHOUT IT COSTING YOU COURT COST. I RECEIVE LETTERS FROM ATTORNEYS IN THE MAIL OFFERING TO RESOLVE THE MATTER. JUST DO THE HONEST THING,AS THE LAW STATES. *TR
MY 1999 PLYMOUTH BREEZE CAUGHT ON FIRE AND ENTIRE ENGINE WAS BURNED DOWN AND CAR DESTROYED DUE TO ENGINE FIRE. *TR
Official recalls
306V001000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jan 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT AGE AND DEVELOP A LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE FREE OF CHARGE. THE THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V021000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V244000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 15, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE RIGHT REAR BRAKE TUBE CAN CONTACT THE EXHAUST SYSTEM CLAMP AND WEAR A HOLE IN IT.
Consequence & remedy
Consequence: DAIMLERCHRYSLER RECALL NO. 843. IF THIS HAPPENS, THE TUBE COULD LEAK, REDUCING THE EFFECTIVENESS OF ONE-HALF OF THE DIAGONALLY SPLIT BRAKING SYSTEM, AND RESULTING IN LONGER STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBES FOR VISIBLE EVIDENCE OF CONTACT WITH THE EXHAUST SYSTEM CLAMP. IF THE TUBE SHOWS EVIDENCE OF CONTACT, IT WILL BE REPLACED. IF NO EVIDENCE OF CONTACT EXISTS, THE TUBE WILL BE FASTENED WITH A CLIP.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA05019 · Power Steering Fluid Fires
Opened Nov 7, 2005 · Closed Jan 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Engine And Engine Cooling
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE05036 · Engine Compartment Fires
Opened Jun 29, 2005 · Closed Nov 7, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
ON JUNE 29, 2005, ODI OPENED PRELIMINARY EVALUATION PE05-036 TO INVESTIGATE COMPLAINTS OF ENGINE COMPARTMENT FIRES IN MODEL YEAR (MY) 1999-2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE PASSENGER CARS (JA CARS). THE JA CARS WERE INTRODUCED IN MY 1995 AND ENDED WITH MY 2000.THEY WERE PRODUCED WITH 2.0L, 2.4L AND 2.5L ENGINES.THE INCIDENT DATA IN THE FAILURE REPORT SUMMARY OF THIS RESUME ARE FOR SUBJECT VEHICLE ENGINE COMPARTMENT FIRES FOR ALL CAUSES. ACCORDING TO DAIMLERCHRYSLER, EVIDENCE COLLECTED FROM FIELD INSPECTIONS OF FIRE INCIDENT VEHICLES INDICATE THAT FLUID LEAKAGE FROM THE HIGH PRESSURE POWER STEERING HOSE IS THE MOST LIKELY CAUSE OF THE FIRES IN THE SUBJECT VEHICLES.THE SUBJECT HIGH PRESSURE POWER STEERING HOSE IS USED IN JA CARS WITH BOTH THE 2.4L AND 2.0L ENGINES IN MY 1995 THROUGH 2000.THE FIRE INCIDENT RATE IN THE MY 1999 THROUGH 2000 JA VEHICLES WITH 2.4L ENGINES IS SIGNIFICANTLY HIGHER THAN IN THE PRIOR MODEL YEAR VEHICLES USING THAT ENGINE AND IN ANY OF THE VEHICLES WITH THE 2.0L OR 2.5L ENGINES.DAIMLERCHRYSLER IS CONTINUING ITS INVESTIGATION OF THE ISSUE AND HAS PROVIDED PERIODIC UPDATES TO ODI. AN ENGINEERING ANALYSIS (EA05-019) HAS BEEN OPENED TO FURTHER ASSESS THE SCOPE AND FREQUENCY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ03005 · Auto Trans IGNITION-PARK Interlock
Opened Apr 8, 2003 · Closed Jul 16, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift
THREE OF THE MANFACTURER COMPLAINTS AND TWO OF THE MANUFACTURER CRASHES REPORTED ABOVE WERE DUPLICATES OF ODI REPORTS.THE MAJORITY OF CRASHES OCCURRED AFTER OPERATORS PARKED THE VEHICLE WITHOUT ENGAGING PARK GEAR POSITION; A NON-FUNCTIONAL IGNITION-PARK INTERLOCK SYSTEM SUBSEQUENTLY FAILED TO PREVENT KEY REMOVAL BEFORE THE OPERATORS EXITED THE VEHICLE.MOST OF THE CRASHES WERE MINOR AND INVOLVED MINOR PROPERTY DAMAGE.FOUR OF THE INJURY INCIDENTS OCCURRED WHEN UNATTENDED CHILDREN MOVED THE GEARSHIFT FROM THE PARK POSITION CAUSING THE VEHICLE TO ROLL AWAY, ONE INJURY OCCURRED WHEN THE OPERATOR WAS STRUCK BY A ROLL-AWAY VEHICLE AFTER PARKING AND EXITING.ALL INJURIES WERE RELATIVELY MINOR.A SIGNIFICANT NUMBER OF INTERLOCK SYSTEM FAILURES APPEAR TO BE RELATED TO DISENGAGEMENT OF THE INTERLOCK PIN THAT RIDES IN THE INTERLOCK LEVER SLOT WITHIN THE SHIFT MECHANISM.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER STUDY INTERLOCK SYSTEM FAILURES.