Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
1 reports
Mileage unknown · Jul 2, 2010
SteeringCrashInjury
AS A SERGEANT WITH THE MASS STATE POLICE RECONSTRUCTION TEAM WITH A BSME DEGREE, I'M INVESTIGATING AN INCIDENT WHEREAS A PIERCE FIRE TRUCK ROLLEDOVER @ 30 MPH WHILE TRAVELING ON A FLAT, LEVEL, AND STRAIGHT ROADWAY. EVERYTHING POINT TO A OSHKOSH ALL STEER MALIFUNCTION. PIERCE SAID THE PROBLEM WAS CAUSE BY UNEVEN BRAKING, I (AS AN…
Read full complaint
AS A SERGEANT WITH THE MASS STATE POLICE RECONSTRUCTION TEAM WITH A BSME DEGREE, I'M INVESTIGATING AN INCIDENT WHEREAS A PIERCE FIRE TRUCK ROLLEDOVER @ 30 MPH WHILE TRAVELING ON A FLAT, LEVEL, AND STRAIGHT ROADWAY. EVERYTHING POINT TO A OSHKOSH ALL STEER MALIFUNCTION. PIERCE SAID THE PROBLEM WAS CAUSE BY UNEVEN BRAKING, I (AS AN ENGINEER) SAY NO. ALL EVIDENCE POINTS TO A MALFUNCTION OF THE REAR STEER AXLE. I CAN BE REACHED AT MASSACHUSETTS STATE POLICE C.A.R.S. UNIT[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.
Consequence & remedy
Consequence: Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on July 24, 2017. The recall began June 3, 2020. Owners may contact Pierce customer service at 1-888-974-3723.
PIERCE HAS DECIDED THAT CERTAIN MODEL YEAR 1995-2008 ARROW XT, DASH, CUSTOM CONTENDER, LANCE, ENFORCER, PIERCE ARROW, QUANTUM, SABER AND COMMERCIAL FIRE TRUCKS MANUFACTURED FROM JANUARY 2, 1995, THROUGH JANUARY 21, 2008, CONTAIN A SAFETY DEFECT. THESE VEHICLES ARE EQUIPPED WITH FUEL TANK STRAPS THAT MAY CORRODE DUE TO WINTER ROAD SALT OR LIQUID DE-ICING CHEMICALS. IF THE FUEL TANK STRAPS CORRODE SUFFICIENTLY, THE FUEL TANK SUPPORTING STRAPS MAY FRACTURE AND THE FUEL TANK MAY FALL FROM THE VEHICLE.
Consequence & remedy
Consequence: THE VEHICLES MAY LOSE POWER AND STALL. IN ADDITION, THE FUEL TANK MAY RUPTURE AND SPILL DIESEL FUEL ON THE ROADWAY. EITHER OF THESE OUTCOMES MAY CAUSE A FIRE TRUCK OR SURROUNDING VEHICLES TO SLIP OR SLIDE ON THE ROADWAY SURFACE, INCREASING THE RISK OF A CRASH.
Remedy: FOR FIRE TRUCKS THAT ARE LESS THAN 10 YEARS OLD, DEALERS WILL INSPECT THE FUEL TANK STRAPS AND REPLACE THEM IF NECESSARY WITH STAINLESS STEEL STRAPS FREE OF CHARGE. FOR VEHICLES THAT ARE OLDER THAN 10 YEARS, PIERCE IS NOT OFFERING A FREE REMEDY, BUT WILL OFFER FOR PURCHASE REPLACEMENT FUEL TANKS STRAPS AND PROVIDE INSTRUCTIONS FOR INSTALLATION. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
CERTAIN FIRE TRUCKS WITH COMMAND CABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207,"SEATING SYSTEMS." THE RESCUE BODY OFFERINGS DO NOT MEET THE PULL TEST REQUIREMENTS. THE PEDESTAL SEAT WAS MOUNTED BY DRILLING AND TAPPING THE CAB OR BODY FLOOR.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE PEDESTAL SEAT FASTENERS COULD FAIL TO RESTRAIN THE SEAT, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL INSPECT THE SEAT PEDESTALS. IF THE SEAT WAS MOUNTED WITH TAPPED FASTENERS, THE FASTENERS WILL BE REMOVED AND A HOLE WILL BE DRILLED TO REPLACE THE MOUNTING FASTENERS WITH 7/16" BOLTS AND NUTS. THE RECALL BEGAN ON AUGUST 19, 2005. OWNERS MAY CONTACT PIERCE AT 920-832-3249.
CERTAIN FIRE TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, 'SEATING SYSTEMS.' THE SEAT TETHER RESTRAINS THE SEAT DURING PULL TESTING AS THE SUSPENSION COMPONENTS ARE NOT DESIGNED TO RESTRAIN THE SEAT ON THEIR OWN. THE SUSPENSION SEAT TETHERS ARE TOO LONG.
Consequence & remedy
Consequence: THE OCCUPANT WILL EXPERIENCE INSUFFICIENT SUSPENSION SEAT RESTRAINT WHICH COULD LEAD TO PERSONAL INJURY OR DEATH IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE SUSPENSION SEAT TETHERS WITH SHORTER TETHERS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Pierce Quantum Problems, Complaints & Recalls | Skip That Year
Illustration